|This article contains information about a rocket launch that is scheduled to occur in the next 7 days.
Details may change rapidly as the countdown and ascent progress.
A Falcon 9 v1.1 carrying a Dragon cargo spacecraft
|Function||Orbital launch vehicle|
|Country of origin||United States|
|Cost per launch (2015)||v1.1: $61.2M|
|Height||v1.1: 68.4 m (224 ft)
v1.0: 54.9 m (180 ft)
|Diameter||3.66 m (12.0 ft)|
|Mass||v1.1: 505,846 kg (1,115,200 lb)
v1.0: 333,400 kg (735,000 lb)
|Payload to LEO||v1.1: 13,150 kg (28,990 lb)
v1.0: 10,450 kg (23,040 lb)
|v1.1: 4,850 kg (10,690 lb)
v1.0: 4,540 kg (10,010 lb)
|Launch sites||Cape Canaveral SLC-40
(v1.1: 8, v1.0: 5)
(v1.1: 8, v1.0: 4)
|Partial failures||1 (v1.0)|
|First flight||v1.1: September 29, 2013
v1.0: June 4, 2010
|Engines||v1.1: 9 Merlin 1D
v1.0: 9 Merlin 1C
|Thrust||v1.1: 5,885 kN (1,323,000 lbf)
v1.0: 4,940 kN (1,110,000 lbf)
Sea level: 282 s
Vacuum: 311 s
|Burn time||v1.1: 180 seconds
v1.0: 170 seconds
|Engines||v1.1: 1 Merlin Vacuum (1D)
v1.0: 1 Merlin Vacuum (1C)
|Thrust||v1.1: 801 kN (180,000 lbf)
v1.0: 445 kN (100,000 lbf)
|Specific impulse||Vacuum: 342 s |
|Burn time||v1.1: 375 seconds
v1.0: 345 seconds
Falcon 9 is a family of launch vehicles designed and manufactured by SpaceX, headquartered in Hawthorne, California. The family consists of the Falcon 9 v1.0, Falcon 9 v1.1, and the Falcon 9-R. Both stages of this two-stage-to-orbit vehicle are powered by rocket engines that burn liquid oxygen (LOX) and rocket-grade kerosene (RP-1) propellants. The current Falcon 9 can lift payloads of 13,150 kilograms (28,990 lb) to low Earth orbit, and 4,850 kilograms (10,690 lb) to geostationary transfer orbit. All three Falcon 9 vehicles are situated in the medium-lift range of launch systems.
The Falcon 9 and Dragon capsule combination won a Commercial Resupply Services (CRS) contract from NASA in 2008 to resupply the International Space Station (ISS) under the Commercial Orbital Transportation Services (COTS) program. The first commercial resupply mission to the International Space Station launched in October 2012. The initial version 1.0 design made a total of five flights before it was retired in 2013.
SpaceX is currently flying an improved and 60 percent heavier Falcon 9 launch vehicle—the Falcon 9 v1.1—which flew for the first time on a demonstration mission on the sixth overall launch of the Falcon 9 in September 2013.
The Falcon 9 v1.1 will be the base for the Falcon Heavy launch vehicle. Falcon 9 will also be human-rated for transporting NASA astronauts to the ISS as part of a Commercial Crew Transportation Capability contract.
- 1 Development and production
- 2 Launcher versions
- 3 Features
- 4 Launch sites
- 5 Launch prices
- 6 Launch history
- 7 See also
- 8 References
- 9 External links
Development and production
While SpaceX spent its own money to develop the previous launcher, Falcon 1, development of the Falcon 9 was initiated with NASA funding from the Commercial Orbital Transportation Services (COTS) program; SpaceX received a directly-funded Space Act Agreement (SAA) in 2006 "to develop and demonstrate commercial orbital transportation service" including three demonstration flights. NASA also became an anchor tenant for the vehicle by purchasing Commercial Resupply Services launches to the International Space Station in 2008 (two years before the first launch); the contract, worth $1.6 billion, was for at least 12 missions to carry supplies to and from the station.
SpaceX's statement about the NASA contract was:
SpaceX has only come this far by building upon the incredible achievements of NASA, having NASA as an anchor tenant for launch, and receiving expert advice and mentorship throughout the development process. SpaceX would like to extend a special thanks to the NASA COTS office for their continued support and guidance throughout this process. The COTS program has demonstrated the power of a true private/public partnership and we look forward to the exciting endeavors our team will accomplish in the future.
In 2011, SpaceX estimated that Falcon 9 v1.0 development costs were on the order of $300 million. NASA evaluated them using a traditional cost-plus contract approach initially at $3.6 billion.
In 2014, SpaceX released total combined development costs for both the Falcon 9 and the Dragon capsule. NASA provided US$396 million while SpaceX provided over US$450 million to fund rocket and capsule development efforts.
Development, production and testing history
SpaceX originally intended to follow its light Falcon 1 launch vehicle with an intermediate capacity vehicle, the Falcon 5. In 2005, SpaceX announced it was instead proceeding with development of the Falcon 9, a "fully reusable heavy lift launch vehicle," and had already secured a government customer. The Falcon 9 was described as being capable of launching approximately 9,500 kg (21,000 lb) to low Earth orbit, and was projected to be priced at $27 million per flight with a 3.7 m (12 ft) fairing and $35 million with a 5.2 m (17 ft) fairing. SpaceX also announced development of a heavy version of the Falcon 9 with a payload capacity of approximately 25,000 kg (55,000 lb). The Falcon 9 was intended to enable launches to LEO, GTO, as well as both crew and cargo vehicles to the ISS.
The original NASA COTS contract called for the first demonstration flight of Falcon in September 2008, and completion of all three demonstration missions by September 2009. In February 2008, the plan for the first Falcon 9/Dragon COTS Demo flight was delayed by six months to late in the first quarter of 2009. According to Elon Musk, the complexity of the development work and the regulatory requirements for launching from Cape Canaveral contributed to the delay.
The first multi-engine test (with two engines connected to the first stage, firing simultaneously) was successfully completed in January 2008, with successive tests leading to the full Falcon 9 complement of nine engines test fired for a full mission length (178 seconds) of the first stage on November 22, 2008. In October 2009, the first flight-ready first stage had a successful all-engine test fire at the company's test stand in McGregor, TX. In November 2009 SpaceX conducted the initial second stage test firing lasting forty seconds. This test succeeded without aborts or recycles. On January 2, 2010, a full-duration (329 seconds) orbit-insertion firing of the Falcon 9 second stage was conducted at the McGregor test site. The full stack arrived at the launch site for integration at the beginning of February 2010, and SpaceX initially scheduled a launch date of March 22, 2010, though they estimated anywhere between one and three months for integration and testing.
On February 25, 2010, SpaceX's first flight stack was set vertical at Space Launch Complex 40, Cape Canaveral, and on March 9, SpaceX performed a static fire test, where the first stage was to be fired without taking off. The test aborted at T-2 seconds due to a failure in the system designed to pump high-pressure helium from the launch pad into the first stage turbopumps, which would get them spinning in preparation for launch. Subsequent review showed that the failure occurred when a valve didn't receive a command to open. As the problem was with the pad and not with the rocket itself, it didn't occur at the McGregor test site, which didn't have the same valve setup. Some fire and smoke were seen at the base of the rocket, leading to speculation of an engine fire. However, the fire and smoke were the result of normal burnoff from the liquid oxygen and fuel mix present in the system prior to launch, and no damage was sustained by the vehicle or the test pad. All vehicle systems leading up to the abort performed as expected, and no additional issues were noted that needed addressing. A subsequent test on March 13 was successful in firing the nine first-stage engines for 3.5 seconds.
The first flight was delayed from March 2010 to June due to review of the Falcon 9 flight termination system by the Air Force. The first launch attempt occurred at 1:30 pm EDT on Friday, June 4, 2010 (1730 UTC). The launch was aborted shortly after ignition, and the rocket successfully went through a failsafe abort. Ground crews were able to recycle the rocket, and successfully launched it at 2:45 pm EDT (1845 UTC) the same day.
The second Falcon 9 launch, and first COTS demo flight, lifted off on December 8, 2010.
The second Falcon 9 version—v1.1—was developed in 2010-2013, and launched for the first time in September 2013.
In December 2010, the SpaceX production line was manufacturing one new Falcon 9 (and Dragon spacecraft) every three months, with a plan to double to one every six weeks. By September 2013, SpaceX total manufacturing space had increased to nearly 1,000,000 square feet (93,000 m2) and the factory had been configured to achieve a production rate of up to 40 rocket cores per year. The November 2013 production rate for Falcon 9 vehicles was one per month. The company has stated that this will increase to 18 per year in mid-2014 and 24 per year by the end of 2014
The original Falcon 9 flew five successful orbital launches in 2010–2013, and the much larger Falcon 9 v1.1 made its first flight—a demonstration mission with a very small 500 kilograms (1,100 lb) primary payload, the CASSIOPE satellite, that was manifested at a "cut rate price" due to the demo mission nature of the flight—on September 29, 2013. More realistic payloads have followed for v1.1 with the launch of the large SES-8 and Thaicom communication satellites, each inserted successfully into GTO. Both Falcon 9 v1.0 and Falcon 9 v1.1 are expendable launch vehicles (ELVs).
In addition, a reusable first stage is under development for the Reusable Falcon 9 launch vehicle, with initial atmospheric testing being conducted on the Grasshopper experimental technology-demonstrator reusable launch vehicle (RLV).
Common design elements
The Falcon 9 tank walls and domes are made from aluminum lithium alloy. SpaceX uses an all-friction stir welded tank, the highest strength and most reliable welding technique available. The second stage tank of a Falcon 9 is simply a shorter version of the first stage tank and uses most of the same tooling, material and manufacturing techniques. This saves money during vehicle production.
SpaceX uses multiple redundant flight computers in a fault-tolerant design. Each Merlin engine is controlled by three voting computers, each of which has two physical processors that constantly check each other. The software runs on Linux and is written in C++. For flexibility, commercial off-the-shelf parts and system-wide "radiation-tolerant" design are used instead of rad-hardened parts. Each stage has stage-level flight computers, in addition to the Merlin-specific engine controllers, of the same fault-tolerant triad design to handle stage control functions.
The Falcon 9 interstage, which connects the upper and lower stage for Falcon 9, is a carbon fiber aluminum core composite structure. Reusable separation collets and a pneumatic pusher system separate the stages. The original design stage separation system had twelve attachment points, which was reduced to just three in the v1.1 launcher.
Falcon 9 v1.0
The first version of the Falcon 9 launch vehicle, Falcon 9 v1.0, is an expendable launch vehicle (ELV) that was developed in 2005–2010, and was launched for the first time in 2010. Falcon 9 v1.0 made five flights in 2010–2013, after which it was retired.
The Falcon 9 v1.0 first stage was powered by nine SpaceX Merlin 1C rocket engines arranged in a 3x3 pattern. Each of these engines had a sea-level thrust of 556 kilonewtons (125,000 lbf) for a total thrust on liftoff of about 5,000 kilonewtons (1,100,000 lbf). The Falcon 9 v1.0 second stage was powered by a single Merlin 1C engine modified for vacuum operation, with an expansion ratio of 117:1 and a nominal burn time of 345 seconds.
Four Draco thrusters were used on the Falcon 9 v1.0 second-stage as a reaction control system. The thrusters are used to hold a stable attitude for payload separation or, as a non-standard service, could have been used to spin up the stage and payload to a maximum of 5 rotations per minute (RPM).[dated info]
SpaceX expressed hopes initially that both stages would eventually be reusable. But early results from adding lightweight thermal protection system (TPS) capability to the booster stage and using parachute recovery were not successful, leading to abandonment of that approach and the initiation of a new design. In 2011 SpaceX began a formal and funded development program for a reusable Falcon 9 second stage, with the early program focus however on return of the first stage.
Falcon 9 v1.1
The Falcon 9 v1.1 ELV is a 60 percent heavier rocket with 60 percent more thrust than the v1.0 version of the Falcon 9. It includes realigned first-stage engines and 60 percent longer fuel tanks, making it more susceptible to bending during flight. Development testing of the v1.1 first stage was completed in July 2013. The Falcon 9 v1.1 first launched on September 29, 2013, uses a longer first stage powered by nine Merlin 1D engines arranged in an "octagonal" pattern.
The v1.1 first stage has a total sea-level thrust at liftoff of 5,885 kilonewtons (1,323,000 lbf), with the nine engines burning for a nominal 180 seconds, while stage thrust rises to 6,672 kilonewtons (1,500,000 lbf) as the booster climbs out of the atmosphere. The engines have been upgraded to the more powerful Merlin 1D. These improvements will increase the payload capability from 9,000 kilograms (20,000 lb) to 13,150 kilograms (28,990 lb). The stage separation system has been redesigned and reduces the number of attachment points from twelve to three, and the vehicle has upgraded avionics and software as well. The new first stage will also be used as side boosters on the Falcon Heavy launch vehicle.
SpaceX President Gwynne Shotwell has stated the Falcon 9 v1.1 has about 30 percent more payload capacity than published on its standard price list, the extra margin reserved for returning of stages via powered re-entry. Though SpaceX has signed agreements with SES for two launches of satellites up to 5,330 kilograms (11,750 lb), exceeding the price list offering of 4,850 kilograms (10,690 lb) by approximately 10 percent, these satellites will be dropped off in a sub-GTO trajectory and subsequently use on board propellant to raise their orbits.
The v1.1 booster version arranges the engines in a structural form SpaceX calls Octaweb, aimed at streamlining the manufacturing process, and will eventually include four extensible landing legs, which will be used only for post-mission technology development testing in the early Falcon 9 v1.1 flights while supporting full vertical-landing capability in later flights once the technology is fully developed.
Following the September 2013 launch, the second stage igniter propellant lines were insulated to better support in-space restart following long coast phases for orbital trajectory maneuvers.
The sixth flight (CASSIOPE, 2013) was the first launch of the Falcon 9 configured with a jettisonable payload fairing, which introduced an additional separation event – a risky operation that has doomed many previous government and commercial launch missions, including the 2009 Orbiting Carbon Observatory and 2011 Glory satellite, both on Taurus rockets.
Fairing design was done by SpaceX, with production of the 13 m (43 ft)-long, 5.2 m (17 ft)-diameter payload fairing done in Hawthorne, California at the SpaceX rocket factory. Since the first five Falcon 9 launches had a capsule and did not carry a large satellite, no fairing was required on those flights. It was required on the CASSIOPE flight, as with most satellites, in order to protect the payload during launch. Testing of the new fairing design was completed at NASA's Plum Brook Station test facility in spring 2013 where the acoustic shock and mechanical vibration of launch, plus electromagnetic static discharge conditions, were simulated on a full-size fairing test article in a very large vacuum chamber. SpaceX paid NASA US$581,300 to lease test time in the $150 million NASA simulation chamber facility. The fairing separated without incident during the launch of CASSIOPE.
A third version of the rocket is in development. The Falcon 9-R, a partially reusable variant of the Falcon 9—with a reusable (RLV) booster stage—is being developed using systems and software tested on the Grasshopper and F9R Dev technology demonstrators, as well as a set of technologies being developed by SpaceX to facilitate rapid reusability of both the first, and in the longer term, second stages. Initially however, only the first-stage booster will be reused.
While the differences between the Falcon 9 v1.0 and the Falcon 9 v1.1 were significant, there are a much smaller set of differences between the Falcon 9 v1.1 and the emerging design of the returnable booster for the Falcon 9-R. While no changes in rocket length or thrust are planned, the principal visible change will be the presence of extensible landing legs on the lower portion of the first-stage booster in the F9-R. Additional changes will be less visible, including changes to the attitude control technology for the rocket and guidance control system software changes to regularly and reliably effect a ground landing.
SpaceX pricing and payload specifications published for the non-reusable Falcon 9 v1.1 rocket as of March 2014[update] actually include about 30 percent more performance than the published price list indicates; the additional performance is reserved for SpaceX to do reusability booster demonstration flight tests while still achieving the specified payloads for customers. Once all engineering changes to support reusability and recovery are made and testing is successful, SpaceX expects to have room to increase the payload performance for the Falcon 9-R, or decrease launch price, or both.
|Version||Falcon 9 v1.0 (retired)||Falcon 9 v1.1 (active)|
|Stage 1||9 × Merlin 1C||9 × Merlin 1D|
|Stage 2||1 × Merlin 1C Vacuum||1 × Merlin 1D Vacuum|
|Max height (m)||53||68.4 (224.4 ft)|
|Initial thrust (kN)||3,807||5,885|
|Takeoff mass (tonnes)||318||506|
|Fairing diameter (m)||N/A*||5.2|
|Payload to LEO (kg)||8,500–9,000 (launch at Cape Canaveral)||13,150 (launch at Cape Canaveral)|
|Payload to GTO (kg)||3,400||4,850|
* The Falcon 9 v1.0 only launched the Dragon spacecraft; it never launched with the clam-shell payload fairing.
** On SpaceX CRS-1, the primary payload, Dragon, was successful. A secondary payload was placed in an incorrect orbit following an engine failure on the first stage. Though enough fuel remained on the second stage for orbital insertion, NASA safety margins forbade any deviation from the original flight plan.
The reliability of the Falcon 9 will not be established until the vehicle has a significant launch record. The company has predicted that it will have high reliability based on the philosophy that "through simplicity, reliability and low cost can go hand-in-hand," but this remains to be shown. As a comparison, the Russian Soyuz series has more than 1,700 launches to its credit, far more than any other rocket. 75% of current launch vehicles have had at least one failure in the first three flights.
As with the company's smaller Falcon 1 vehicle, Falcon 9's launch sequence includes a hold-down feature that allows full engine ignition and systems check before liftoff. After first-stage engine start, the launcher is held down and not released for flight until all propulsion and vehicle systems are confirmed to be operating normally. Similar hold-down systems have been used on other launch vehicles such as the Saturn V and Space Shuttle. An automatic safe shut-down and unloading of propellant occurs if any abnormal conditions are detected.
Like the Saturn series from the Apollo program, the presence of multiple first-stage engines can allow for mission completion even if one of the first-stage engines fails mid-flight. Detailed descriptions of several aspects of destructive engine failure modes and designed-in engine-out capabilities were made public by SpaceX in a 2007 "update" that was publicly released.
SpaceX emphasized over several years that the Falcon 9 first stage is designed for engine out capability. The SpaceX CRS-1 mission was a partial success after an engine failure in the first stage: The primary payload was inserted into the correct orbit, but due to contractual requirements of the primary payload customer, NASA, the second firing of the Falcon 9 upper stage was not allowed to insert the secondary payload into a higher orbit. This risk was understood by the secondary payload customer at time of the signing of the launch contract. As a result, the secondary payload satellite reentered atmosphere a few days after launch.
In detail, the first stage experienced a loss of pressure in, and then shut down, engine no. 1 at 79 seconds after its October 2012 launch. To compensate for the resulting loss of acceleration, the first stage had to burn 28 seconds longer than planned, and the second stage had to burn an extra 15 seconds.[unreliable source?] That extra burn time of the second stage reduced its fuel reserves, so that the likelihood that the fuel would suffice to reach the planned orbit above the space station with the secondary payload dropped from 99% to 95%. Because NASA had purchased the launch and therefore contractually controlled a number of mission decision points, NASA declined SpaceX permission to restart the second stage and attempt to deliver the secondary payload into the correct orbit. The secondary payload was lost in earth's atmosphere a few days after launch, and was therefore considered a loss.
Although the first stages of several early Falcon flights were equipped with parachutes and were intended to be recovered to assist engineers in designing for future reusability, SpaceX was not successful in recovering the stages from the initial test launches using the original approach. The Falcon boosters did not survive post separation aerodynamic stress and heating. Although reusability of the second stage is more difficult, SpaceX intended from the beginning to eventually make both stages of the Falcon 9 reusable.
Both stages in the early launches were covered with a layer of ablative cork and possessed parachutes to land them gently in the sea. The stages were also marinized by salt-water corrosion resistant material, anodizing and paying attention to galvanic corrosion. In early 2009, Musk stated:
"By [Falcon 1] flight six we think it’s highly likely we’ll recover the first stage, and when we get it back we’ll see what survived through re-entry, and what got fried, and carry on with the process. ... That's just to make the first stage reusable, it'll be even harder with the second stage – which has got to have a full heatshield, it'll have to have deorbit propulsion and communication."
Musk said that if the vehicle does not become reusable, "I will consider us to have failed.”
In late 2011, SpaceX announced a change in the approach, ditching the parachutes and going with a propulsively-powered-descent approach. On September 29, 2011, at the National Press Club, Musk indicated the initiation of a privately funded program to develop powered descent and recovery of both Falcon 9 stages – a fully vertical takeoff, vertical landing (VTVL) rocket. Included was a video said to be an approximation depicting the first stage returning tail-first for a powered descent and the second stage, with heat shield, reentering head first before rotating for a powered descent.
Design was complete on the system for "bringing the rocket back to launchpad using only thrusters" in February 2012. The reusable launch system technology is under consideration for both the Falcon 9 and the Falcon Heavy, and is considered particularly well suited to the Falcon Heavy where the two outer cores separate from the rocket much earlier in the flight profile, and are therefore moving at lower velocity at stage separation.
A reusable first stage is now being flight tested by SpaceX with the suborbital Grasshopper rocket. By April 2013, a low-altitude, low-speed demonstration test vehicle, Grasshopper v1.0, had made five VTVL test flights including an 80-second hover flight to an altitude of 744 metres (2,441 ft).
In March 2013, SpaceX announced that, beginning with the first flight of the stretch version of the Falcon 9 launch vehicle—the sixth flight overall of Falcon 9, every first stage would be instrumented and equipped as a controlled descent test vehicle. SpaceX intends to do propulsive-return over-water tests and "will continue doing such tests until they can do a return to the launch site and a powered landing. ... [They] expect several failures before they 'learn how to do it right.'"
For the early-fall 2013 flight, after stage separation, the first-stage booster will do a burn to slow it down and then a second burn just before it reaches the water. When all of the over-water testing is complete, they intend to fly back to the launch site and land propulsively, perhaps as early as mid-2014. SpaceX has been explicit that they do not expect a successful recovery in the first several powered-descent tests.
Post-mission high-altitude launch vehicle testing of Falcon 9 v1.1 boosters
The post-mission test plan calls for the first-stage booster on the sixth Falcon 9 flight, and several subsequent F9 flights, to do a burn to reduce the rocket's horizontal velocity and then effect a second burn just before it reaches the water. SpaceX announced the test program in March 2013, and their intention to continue to conduct such tests until they can return to the launch site and perform a powered landing.
Falcon 9 Flight 6's first stage performed the first propulsive-return over-water tests on 29 September 2013. Although not a complete success, the stage was able to change direction and make a controlled entry into the atmosphere. During the final landing burn, the ACS thrusters could not overcome an aerodynamically induced spin, and centrifugal force deprived the landing engine of fuel leading to early engine shutdown and a hard splashdown which destroyed the first stage. Pieces of wreckage were recovered for further study.
Launch Complex 40 at Cape Canaveral Air Force Station was the Falcon 9's first launch site and is the main location for ISS cargo resupply launches and for payloads going to geostationary orbits. A second SpaceX-leased launch site is located at Vandenberg Air Force Base's SLC-4 and is used for polar-orbit launches. The Vandenberg site became active on 29 September 2013 when it launched the Canadian-built CASSIOPE satellite. A third site, intended solely for commercial launches, is planned. Locations in Texas, Florida, Georgia, and Puerto Rico were evaluated. The final location in Boca Chica, Texas was selected in August 2014.
At the time of its retirement, the price of a Falcon 9 v1.0 launch was listed at $54 million - $59.5 million. In 2013, the list price of a Falcon 9 v1.1 was $56.5 million, and was $61.2 million as of November 2014[update]. Dragon cargo missions to the ISS have an average cost of $133 million under a fixed price contract with NASA.
In 2004, Elon Musk stated, "long term plans call for development of a heavy lift product and even a super-heavy, if there is customer demand. [...] Ultimately, I believe $500 per pound ($1100/kg) [of payload delivered to orbit] or less is very achievable." At its 2013 launch price and at full LEO payload capacity, the Falcon 9 v1.1 cost $1,864 per pound ($4,109/kg).
In 2011, Musk estimated that fuel and oxidizer for the Falcon 9 v1.0 rocket cost a total of about $200,000. The first stage uses 39,000 US gallons (150,000 L) of liquid oxygen and almost 25,000 US gallons (95,000 L) of kerosene, while the second stage uses 7,300 US gallons (28,000 l; 6,100 imp gal) of liquid oxygen and 4,600 US gallons (17,000 L) of kerosene.
Secondary payload services
Falcon 9 payload services include secondary and tertiary payload connection via an ESPA-ring, the same interstage adapter first used for launching secondary payloads on US DoD missions that use the Evolved Expendable Launch Vehicles (EELV) Atlas V and Delta IV. This enables secondary and even tertiary missions with minimal impact to the original mission. As of 2011[update], SpaceX announced pricing for ESPA-compatible payloads on the Falcon 9.
As of January 2015, SpaceX has made 14 launches of the Falcon 9 since 2010, and all have successfully delivered their primary payloads to Earth orbit. However, in October 2012 a Falcon 9 failed to insert its secondary payload into the correct orbit due to an early engine shut down, although the primary payload was correctly delivered to the ISS.
The second launch of the Falcon 9, and the first of the SpaceX Dragon spacecraft atop it, occurred at 10:43 EST (15:43 UTC) on December 8, 2010, from Cape Canaveral. The Dragon spacecraft completed two orbits, then splashed down in the Pacific Ocean. A second NASA-contracted demonstration flight was flown in 2012, followed by the first two ISS resupply flights in late 2012 and early 2013.
The Falcon 9 Flight 6 successfully flew on September 29, 2013, and was the first launch of the substantially upgraded Falcon 9 v1.1 vehicle. The launch included a number of Falcon 9 "firsts":
- First use of the upgraded Merlin 1D engines, generating approximately 56 percent more sea-level thrust than the Merlin 1C engines used on all previous Falcon 9 vehicles.
- First use of the significantly longer first stage, which holds the additional propellant for the more powerful engines.
- The nine Merlin 1D engines on the first stage are arranged in an octagonal pattern with eight engines in a circle and the ninth in the center.
- First launch from SpaceX's new launch facility, Space Launch Complex 4, at Vandenberg Air Force Base, California, and the first launch over the Pacific Ocean using the facilities of the Pacific test range.
- First Falcon 9 launch to carry a satellite payload for a commercial customer, and also the first non-CRS mission. Each prior Falcon 9 launch was of a Dragon capsule or a Dragon-shaped test article, although SpaceX has previously successfully launched and deployed a satellite on the Falcon 1, Flight 5 mission.
- First Falcon 9 launch to have a jettisonable payload fairing, which introduces the risk of an additional separation event.
While a number of the new capabilities were successfully tested on the flight, there was a problem with the second stage on September 29, 2013. SpaceX was unsuccessful in reigniting the second stage Merlin 1D vacuum engine once the rocket had deployed its primary payload (CASSIOPE) and all of its nanosat secondary payloads.
On April 18, 2014, the Falcon 9 launched the Dragon spacecraft to orbit, carrying supplies and science experiments to the International Space Station. This was the third launch under SpaceX's Commercial Resupply Services (CRS) contract with NASA. In addition, the first stage of the rocket successfully "landed" in the Atlantic ocean.
On July 14, 2014, the Falcon 9 successfully launched a constellation of six Orbcomm OG2 satellites to orbit.
On August 5, 2014, the Falcon 9 successfully launched the AsiaSat 8 satellite to geosynchronous transfer orbit.
On September 7, 2014, the Falcon 9 successfully launched the AsiaSat 6 satellite to geosynchronous transfer orbit.
On September 21, 2014, the Falcon 9 successfully launched a Dragon spacecraft carrying supplies to the International Space Station.
On January 10, 2015, the Falcon 9 successfully launched a Dragon spacecraft carrying supplies and science experiments to ISS. SpaceX also attempted to land the first stage on its autonomous spaceport drone ship in the atlantic ocean. The first stage reached the platform but crashed due to loss of power to the fins, resulting in a hard ~45 deg angle, smashing legs and engine section, due to a lack of hydraulic fluid.
- "Capabilities & Services". SpaceX. Retrieved 28 September 2013.
- "Falcon 9". SpaceX. Retrieved 4 December 2013.
- "Falcon 9". SpaceX. Archived from the original on 23 March 2012. Retrieved 28 September 2013.
- Graham, Will. "SpaceX successfully launches debut Falcon 9 v1.1". NASASpaceFlight. Retrieved 29 September 2013.
- "Detailed Mission Data – Falcon-9 ELV First Flight Demonstration". Mission Set Database. NASA GSFC. Retrieved 2010-05-26.
- "Falcon 9". SpaceX. Archived from the original on 1 May 2013. Retrieved 29 September 2013.
- "SpaceX Falcon 9 Upper Stage Engine Successfully Completes Full Mission Duration Firing" (Press release). SpaceX. March 10, 2009.
- "SpaceX Falcon 9 rocket launch in California". CBS News. Retrieved 29 September 2013.
- Mr. Alan Lindenmoyer, Manager, NASA Commercial Crew & Cargo Program, quoted in Minutes of the NAC Commercial Space Committee, April 26, 2010
- COTS 2006 Demo Competition. NASA (accessed August 26, 2014); and announcement "Commercial Orbital Transportation Services Demonstrations". Jan. 18, 2006 (accessed August 26, 2014)
- Space Exploration Technologies (SpaceX). NASA (accessed August 26, 2014)
- SpaceX, SPACEX'S DRAGON SPACECRAFT SUCCESSFULLY RE-ENTERS FROM ORBIT, Dec 15, 2010 (accessed 2 October 2014)
- "“The government is the necessary anchor tenant for commercial cargo, but it’s not sufficient to build a new economic ecosystem,” says Scott Hubbard, an aeronautics researcher at Stanford University in California and former director of NASA’s Ames Research Center in Moffett Field, California." Stewart Money. Competition and the future of the EELV program (part 2), The Space Review March 12, 2012 (accessed 2 October 2014)
- "NASA selects SpaceX's Falcon 9 booster and Dragon spacecraft for cargo resupply services to the International Space Station" (Press release). SpaceX. 2008-12-23.
- "THE FACTS ABOUT SPACEX COSTS". spacex.com. May 4, 2011.
- "Falcon 9 Launch Vehicle NAFCOM Cost Estimates". nasa.gov. August 2011.
- Shotwell, Gwynne (June 4, 2014). Discussion with Gwynne Shotwell, President and COO, SpaceX. Atlantic Council. Event occurs at 12:20–13:10. Retrieved June 8, 2014.
NASA ultimately gave us about $396 million; SpaceX put in over $450 million ... [for an] EELV-class launch vehcle ... as well as a capsule
- David, Leonard. "SpaceX tackles reusable heavy launch vehicle". MSN. MSNBC.
- "SpaceX Announces the Falcon 9 Fully Reusable Heavy Lift Launch Vehicle" (Press release). SpaceX. 2005-09-08. Archived from the original on August 15, 2008.
- Space Act Agreement between NASA and Space Exploration Technologies, Inc., for Commercial Orbital Transportation Services Demonstration (pdf)
- Coppinger, Rob (2008-02-27). "SpaceX Falcon 9 maiden flight delayed by six months to late Q1 2009". Flight Global.
- "SpaceX Conducts First Multi-Engine Firing of Falcon 9 Rocket" (Press release). SpaceX. 18 January 2008.
- "SpaceX successfully conducts full mission-length firing of its Falcon 9 launch vehicle" (Press release). SpaceX. November 23, 2008.
- "SpaceX announces Falcon 9 assembly underway at the Cape". Orlando Sentinel. 11 Feb 2010.
- "Updates". SpaceX. February 25, 2010. Retrieved 2010-06-04.
- Kremer, Ken (March 13, 2010). "Successful Engine Test Firing for SpaceX Inaugural Falcon 9". Universe Today. Retrieved 2010-06-04.
- Kaufman, Marc (June 4, 2010). "Falcon 9 rocket launch aborted". Washington Post. Retrieved June 4, 2010.
- Staff writer (August 20, 2010). "SpaceX Falcon 9 rocket enjoys successful maiden flight". BBC News. Retrieved 2010-06-05.
- "COTS Demo Flight 1 status". SpaceFlight Now.
- Q & A with SpaceX CEO Elon Musk: Master of Private Space Dragons, space.com, 2010-12-08, accessed 2010-12-09. "now have Falcon 9 and Dragon in steady production at approximately one F9/Dragon every three months. The F9 production rate doubles to one every six weeks in 2012."
- "Production at SpaceX". SpaceX. 2013-09-24. Retrieved 2013-09-29.
- Svitak, Amy (2013-11-24). "Musk: Falcon 9 Will Capture Market Share". Aviation Week. Retrieved 2013-11-28.
SpaceX is currently producing one vehicle per month, but that number is expected to increase to '18 per year in the next couple of quarters.' By the end of 2014, she says SpaceX will produce 24 launch vehicles per year.
- Amos, Jonathan (2013-12-03). "SpaceX launches SES commercial TV satellite for Asia". BBC News. Retrieved 2013-12-11.
The commercial market for launching telecoms spacecraft is tightly contested, but has become dominated by just a few companies - notably, Europe's Arianespace, which flies the Ariane 5, and International Launch Services (ILS), which markets Russia's Proton vehicle. SpaceX is promising to substantially undercut the existing players on price, and SES, the world's second-largest telecoms satellite operator, believes the incumbents had better take note of the California company's capability. 'The entry of SpaceX into the commercial market is a game-changer'
- Klotz, Irene (2013-09-06). "Musk Says SpaceX Being "Extremely Paranoid" as It Readies for Falcon 9’s California Debut". Space News. Retrieved 2013-09-13.
- "SpaceX's reusable rocket testbed takes first hop". 2012-09-24. Retrieved 2012-11-07.
- "Falcon 9 Overview". SpaceX. 8 May 2010.
- Mission Status Center, June 2, 2010, 1905 GMT, SpaceflightNow, accessed 2010-06-02, Quotation: "The flanges will link the rocket with ground storage tanks containing liquid oxygen, kerosene fuel, helium, gaserous nitrogen and the first stage ignitor source called triethylaluminum-triethylborane, better known as TEA-TAB."
- Svitak, Amy (2012-11-18). "Dragon's "Radiation-Tolerant" Design". Aviation Week. Archived from the original on 2013-12-03. Retrieved 2012-11-22.
- "Falcon 9 Launch Vehicle Payload User’s Guide, 2009". SpaceX. 2009. Retrieved 2010-02-03.
- "Musk ambition: SpaceX aim for fully reusable Falcon 9". NASAspaceflight.com. 2009-01-12. Retrieved 2013-05-09.
With Falcon I’s fourth launch, the first stage got cooked, so we’re going to beef up the Thermal Protection System (TPS). By flight six we think it’s highly likely we’ll recover the first stage, and when we get it back we’ll see what survived through re-entry, and what got fried, and carry on with the process. That’s just to make the first stage reusable, it’ll be even harder with the second stage – which has got to have a full heatshield, it’ll have to have deorbit propulsion and communication.
- Simberg, Rand (2012-02-08). "Elon Musk on SpaceX’s Reusable Rocket Plans". Popular Mechanics. Retrieved 2013-03-08.
- "Falcon 9's commercial promise to be tested in 2013". Spaceflight Now. Retrieved 17 November 2012.
- "SpaceX Test-fires Upgraded Falcon 9 Core for Three Minutes". Space News. Retrieved 2013-08-11.
- Bergin, Chris (20 June 2013). "Reducing risk via ground testing is a recipe for SpaceX success". NASASpaceFlight (not affiliated with NASA). Retrieved 21 June 2013.
- "The Annual Compendium of Commercial Space Transportation: 2012". Federal Aviation Administration. February 2013. Retrieved 17 February 2013.
- Clark, Stephen (2012-05-18). "Q&A with SpaceX founder and chief designer Elon Musk". SpaceFlightNow. Retrieved 2013-03-05.
- "Falcon 9". SpaceX. Retrieved 2013-08-02.
- "Capabilities & Services". SpaceX. 2013. Retrieved 2013-09-09.
- "Space Launch report, SpaceX Falcon Data Sheet". Retrieved 2011-07-29.
- de Selding, Peter (2014-03-27). "SpaceX Says Requirements, Not Markup, Make Government Missions More Costly". Space News. Retrieved 2014-04-03.
- Selding, Peter. "SES Books SpaceX Falcon 9 for Hybrid Satellite’s Debut". Spacenews.com. Retrieved November 20, 2014.
- "Octaweb". SpaceX. 2013-07-29. Retrieved 2013-07-30.
The Octaweb structure of the nine Merlin engines improves upon the former 3x3 engine arrangement. The Octaweb is a metal structure that supports eight engines surrounding a center engine at the base of the launch vehicle. This structure simplifies the design and assembly of the engine section, streamlining our manufacturing process.
- "Landing Legs". SpaceX. 2013-07-29. Retrieved 2013-07-30.
The Falcon 9 first stage carries landing legs which will deploy after stage separation and allow for the rocket’s soft return to Earth. The four legs are made of state-of-the-art carbon fiber with aluminum honeycomb. Placed symmetrically around the base of the rocket, they stow along the side of the vehicle during liftoff and later extend outward and down for landing.
- Lindsey, Clark (2013-03-28). "SpaceX moving quickly towards fly-back first stage". NewSpace Watch. Retrieved 2013-03-29. (subscription required (. ))
- Messier, Doug (2013-03-28). "Dragon Post-Mission Press Conference Notes". Parabolic Arc. Retrieved 2013-03-30.
Q. What is strategy on booster recover? Musk: Initial recovery test will be a water landing. First stage continue in ballistic arc and execute a velocity reduction burn before it enters atmosphere to lessen impact. Right before splashdown, will light up the engine again. Emphasizes that we don’t expect success in the first several attempts. Hopefully next year with more experience and data, we should be able to return the first stage to the launch site and do a propulsion landing on land using legs. Q. Is there a flight identified for return to launch site of the booster? Musk: No. Will probably be the middle of next year.
- Mangels, John (2013-05-25). "NASA's Plum Brook Station tests rocket fairing for SpaceX". Cleveland Plain Dealer. Retrieved 2013-05-27.
- Abbott, Joseph (2013-05-08). "SpaceX’s Grasshopper leaping to NM spaceport". Waco Tribune. Retrieved 2013-05-09.
- Bergin, Chris (2013-06-20). "Reducing risk via ground testing is a recipe for SpaceX success". NASAspaceflight.com. Retrieved 2013-10-24.
- Gwynne Shotwell (2014-03-21). Broadcast 2212: Special Edition, interview with Gwynne Shotwell (mp3) (audio file). The Space Show. Event occurs at 08:15–11:20. 2212. Archived from the original on 2014-03-22. Retrieved 2014-03-22.
[Falcon 9 v1.1] vehicle has thirty percent more performance than what we put on the web and that extra performance is reserved for us to do our reusability and recoverability [tests] ... current vehicle is sized for reuse.
- "Falcon 9 Overview". SpaceX. 2010. Retrieved 4 Apr 2011.
- Clark, Stephen (October 11, 2012). "Orbcomm craft falls to Earth, company claims total loss". Spaceflight Now. Retrieved 2014-04-05.
- Space Exploration Technologies, Inc., Reliability brochure, v 12, undated (accessed Dec. 29, 2011)
- "Russia scores success in its 1,700th Soyuz launch". Retrieved October 7, 2012.
- "SpaceX Falcon 9 rocket facts".
- NASA PAO, Hold-Down Arms and Tail Service Masts, Moonport, SP-4204 (accessed 26 August 2010)
- Behind the Scenes With the World's Most Ambitious Rocket Makers, Popular Mechanics, 2009-09-01, accessed 2012-12-11. "It is the first since the Saturn series from the Apollo program to incorporate engine-out capability—that is, one or more engines can fail and the rocket will still make it to orbit."
- "Updates: December 2007". Updates Archive. SpaceX. Dec 2007. Retrieved 2012-12-27.
Once we have all nine engines and the stage working well as a system, we will extensively test the “engine out” capability. This includes explosive and fire testing of the barriers that separate the engines from each other and from the vehicle. ... It should be said that the failure modes we’ve seen to date on the test stand for the Merlin 1C are all relatively benign – the turbo pump, combustion chamber and nozzle do not rupture explosively even when subjected to extreme circumstances. We have seen the gas generator (which drives the turbo pump assembly) blow apart during a start sequence (there are now checks in place to prevent that from happening), but it is a small device, unlikely to cause major damage to its own engine, let alone the neighboring ones. Even so, as with engine nacelles on commercial jets, the fire/explosive barriers will assume that the entire chamber blows apart in the worst possible way. The bottom close out panels are designed to direct any force or flame downward, away from neighboring engines and the stage itself. ... we’ve found that the Falcon 9’s ability to withstand one or even multiple engine failures, just as commercial airliners do, and still complete its mission is a compelling selling point with customers. Apart from the Space Shuttle and Soyuz, none of the existing  launch vehicles can afford to lose even a single thrust chamber without causing loss of mission.
- "Falcon 9 Overview". SpaceX. 8 May 2010.
- de Selding, Peter B. (2012-10-11). "Orbcomm Craft Launched by Falcon 9 Falls out of Orbit". Space News. Retrieved 2012-10-12.
Orbcomm requested that SpaceX carry one of their small satellites (weighing a few hundred pounds, vs. Dragon at over 12,000 pounds)... The higher the orbit, the more test data [Orbcomm] can gather, so they requested that we attempt to restart and raise altitude. NASA agreed to allow that, but only on condition that there be substantial propellant reserves, since the orbit would be close to the space station. It is important to appreciate that Orbcomm understood from the beginning that the orbit-raising maneuver was tentative. They accepted that there was a high risk of their satellite remaining at the Dragon insertion orbit. SpaceX would not have agreed to fly their satellite otherwise, since this was not part of the core mission and there was a known, material risk of no altitude raise.
- Leitenberger, Bernd. "SpaceX CRS-1 Nachlese". Retrieved 2012-10-29.
- Lindsey, Clark S. "Interview* with Elon Musk". HobbySpace. Retrieved 17 June 2010.
- Simburg, Rand. "SpaceX Press Conference". Retrieved 16 June 2010.. Musk quote: “We will never give up! Never! Reusability is one of the most important goals. If we become the biggest launch company in the world, making money hand over fist, but we’re still not reusable, I will consider us to have failed.”
- "Elon Musk says SpaceX will attempt to develop fully reusable space launch vehicle". Washington Post. 2011-09-29. Retrieved 2011-10-11.
Both of the rocket’s stages would return to the launch site and touch down vertically, under rocket power, on landing gear after delivering a spacecraft to orbit.
- Wall, Mike (2011-09-30). "SpaceX Unveils Plan for World's First Fully Reusable Rocket". SPACE.com. Retrieved 2011-10-11.
- National Press Club: The Future of Human Spaceflight, cspan, 29 Sep 2011.
- Boyle, Alan (2012-12-24). "SpaceX launches its Grasshopper rocket on 12-story-high hop in Texas". MSNBC Cosmic Log. Retrieved 2012-12-25.
- First test of the Falcon 9-R (reusable) ignition system, 28 April 2013
- Graham, William (2013-09-29). "SpaceX successfully launches debut Falcon 9 v1.1". NASAspaceflight.com. Archived from the original on 2013-09-29. Retrieved 2013-09-29.
- Norris, Guy (2014-04-28). "SpaceX Plans For Multiple Reusable Booster Tests". Aviation Week. Retrieved 2014-04-28.
- "SpaceX Press Conference". Retrieved 2012-11-06.
- "Texas, Florida Battle for SpaceX Spaceport". Parabolic Arc. Retrieved 2012-11-06.
- Dean, James (2013-05-07). "3 states vie for SpaceX's commercial rocket launches". USA Today. Archived from the original on 2013-09-29.
- "SpaceX Is Building a New Launch Site In Texas". Time. August 5, 2014. Retrieved August 9, 2014.
- SpaceX.com. SpaceX http://web.archive.org/web/20130831171457/http://www.spacex.com/about/capabilities
|archiveurl=missing title (help). Archived from the original on August 31, 2013.
- "Why the US can beat China: the facts about SpaceX costs". May 4, 2011. Archived from the original on March 28, 2013.
- Testimony of Elon Musk (May 5, 2004). "Space Shuttle and the Future of Space Launch Vehicles". U.S. Senate.
- Upgraded Spacex Falcon 9.1.1 will launch 25% more than the old Falcon 9 and bring the price down to $4109 per kilogram to LEO, NextBigFuture, 22 Mar 2013.
- "National Press Club: The Future of Human Spaceflight" (Press release). c-span.org. 2012-01-14.
- Foust, Jeff (2011-08-22). "New opportunities for smallsat launches". The Space Review. Retrieved 2011-09-27.
SpaceX ... developed prices for flying those secondary payloads ... A P-POD would cost between $200,000 and $325,000 for missions to LEO, or $350,000 to $575,000 for missions to geosynchronous transfer orbit (GTO). An ESPA-class satellite weighing up to 180 kilograms would cost $4–5 million for LEO missions and $7–9 million for GTO missions, he said.
- de Selding, Peter (October 12, 2012). "Satellite Left Stranded by SpaceX Rocket Falls From Space". Space.com. Retrieved September 27, 2014.
- BBC News. "Private space capsule's maiden voyage ends with a splash." December 8, 2010. December 8, 2010. http://www.bbc.co.uk/news/science-environment-11948329
- "Spaceflight Now - Worldwide launch schedule". Spaceflight Now. June 1, 2013. Retrieved June 24, 2013.
- Foust, Jeff (March 27, 2013). "After Dragon, SpaceX’s focus returns to Falcon". NewSpace Journal. Retrieved 2013-04-05.
- Ferster, Warren (2013-09-29). "Upgraded Falcon 9 Rocket Successfully Debuts from Vandenberg". Space News. Retrieved 2013-09-30.
- SpaceX Launches Fourth Cargo Mission to Space Station
- Davis, Jason (2015-01-16). "Watch the Incredible 'Rapid Unscheduled Disassembly' of SpaceX's Falcon 9 Rocket". Planetary society.
- Klotz, Irene (2014-01-10). "SpaceX rocket nails launch but narrowly misses landing test". Reuters. Retrieved 2014-01-11.
|Wikimedia Commons has media related to Falcon 9.|
|Wikinews has related news: SpaceX successfully test fires Falcon 9 rocket in Texas|
- Falcon 9 official page
- Falcon Heavy official page
- Test firing of two Merlin 1C engines connected to Falcon 9 first stage, Movie 1, Movie 2 (January 18, 2008)
- Press release announcing design (September 9, 2005)
- SpaceX hopes to supply ISS with new Falcon 9 heavy launcher (Flight International, September 13, 2005)
- SpaceX launches Falcon 9, With A Customer (Defense Industry Daily, September 15, 2005)