Pratt & Whitney JT8D
|This article needs additional citations for verification. (October 2008)|
|A JT8D pictured mounted on a McDonnell Douglas DC-9 operated by DHL at the Portland International Jetport in 2004|
|Manufacturer||Pratt & Whitney|
|Major applications||Boeing 727
McDonnell Douglas DC-9
McDonnell Douglas MD-80
|Developed from||Pratt & Whitney J52|
|Developed into||Volvo RM8|
The Pratt & Whitney JT8D is a low-bypass (0.96 to 1) turbofan engine, introduced by Pratt & Whitney in February 1963 with the inaugural flight of Boeing's 727. It was a modification of the Pratt & Whitney J52 turbojet engine, which powered the US Navy A-6 Intruder attack aircraft. The Volvo RM8 is an afterburning version that was license-built in Sweden for the Saab 37 Viggen fighter. A "fixed" version for powerplant and ship propulsion is known as the FT12.
The JT8D is an axial-flow front turbofan engine incorporating dual-spool design. There are two coaxially-mounted independent rotating assemblies: one rotating assembly for the low pressure compressor (LPC) which consists of the first six stages (i.e. six pairs of rotating and stator blades, including the first two stages which are for the bypass turbofan), driven by the second (downstream) turbine (which consists of three stages); and a second rotating assembly for the high-pressure compressor (HPC) section, which has seven stages. The high-pressure compressor is driven by the first (upstream) turbine, which has a single stage.
The front-mounted bypass fan has two stages. The annular discharge duct for the bypass fan runs along the full length of the engine, so that both the fan air and exhaust gases can exit through the same nozzle. This arrangement allows some noise attenuation, in that the still-hot fast-moving turbine exhaust is shrouded in much-cooler and slower-moving air (from the bypass fan) before interacting with ambient air. Thus the JT8D noise levels were significantly reduced from previous non-turbofan engines, although the low bypass ratio meant that, compared to subsequently developed turbofans, high noise levels were still produced.
Eight models comprise the JT8D standard engine family, covering the thrust range from 12,250 to 17,400 pounds-force (62 to 77 kN) and power 727, 737-100/200, and DC-9 aircraft. More than 14,000 JT8D engines have been produced, totaling more than one-half billion hours of service with more than 350 operators making it the most popular of all low-bypass turbofan engines ever produced.
Within the fan inlet case, there are anti-icing air bosses and probes to sense the inlet pressure and temperature. Similar units exist throughout the engine to check temperatures and pressures.
At the 13th (i.e. the final) compressor stage, air is bled out and used for anti-icing. The amount is controlled by the Pressure Ratio Bleed Control sense signal (PRBC). The diffuser case at the aft end of the compressor houses the 13th stage. Its increasing cross-sectional area allows the compressed air to slow down before entering one of the engine's nine burner cans. Again, there are two bosses to extract 13th stage air for anti-icing, de-icing of fuel, and airframe (cabin pressurization) use. Not all the compressed air enters the burner cans at the fuel-ignition point; some bypasses the can completely and cools the first turbine stage, and some is gradually introduced into the burner can's perimeter in such a way that the burning fuel is held near the can's centerline.
There are nine combustion chambers positioned in a can-annular arrangement. Each chamber has three air inlet hole sizes: the smallest is for cooling, the medium is for burning and the large for forming an air blanket.
In response to environmental concerns that began in the 1970s, the company began developing a new version of the engine, the JT8D-200 series. Designed to be quieter, cleaner, more efficient, yet more powerful than earlier models, the -200 Series power-plant was re-engineered with a significantly higher bypass ratio (1.74 to 1) covering the 18,500 to 21,700 pound-force (82 to 97 kN) thrust range and powering the McDonnell Douglas MD-80 series. This increase was achieved by increasing bypass fan diameter (from 39.9 to 49.2 inches) and reducing fan pressure ratio (from 2.21 to 1.92). Overall engine pressure ratio was also increased from 15.4 to 21.0. Since entering service in 1980, more than 2,900 of the -200 series engines have been produced.
The JT8D-217 and -219 engine(s) were tested in 2001 and were deemed suitable replacements for the old TF33 engines on military and commercial aircraft as part of the Super 27 re-engining program. The updated engines offer reduced (Stage-3) noise compliance standards without the need for hush kits, enhanced short field performance, steeper and faster climb rates with roughly a 10% reduction in fuel burn for extended range.
Pratt & Whitney, in a joint venture with Seven Q Seven (SQS) and Omega Air, has developed the JT8D-219 as a re-engine powerplant for Boeing 707-based aircraft. Northrop Grumman uses the -219 to re-engine the United States Air Force’s fleet of 19 Joint Surveillance Target Attack Radar System (E-8 Joint STARS) aircraft, which will allow the JSTARS more time on station due to the engine's 17%  greater fuel efficiency. NATO also plans to re-engine their fleet of E-3 Sentry AWACS aircraft. The -219 is publicized as being half the cost of the competing 707 re-engine powerplant, the CFM-56, for reasons of geometrical and balance similarity to the engine it is replacing and the associated relative up-front wing modification costs of the two choices.
- JT8D-1 - 14,000 lbf
- JT8D-5 - 12,250 lbf
- JT8D-7 - 12,600 lbf
- JT8D-9 - 14,500 lbf
- JT8D-11 - 15,000 lbf
- JT8D-15 - 15,500 lbf
- JT8D-17 - 16,000 lbf
- JT8D-17R - 16,400 lbf
- JT8D-217A/C - 20,000 lbf
- JT8D-219 - 21,000 lbf
Ratings are Normal Takeoff (Max. 5 min.).
- Boeing 707RE
- Boeing 727
- Boeing 737
- Dassault Mercure
- McDonnell Douglas DC-9
- McDonnell Douglas MD-80 series
- McDonnell Douglas YC-15
- Northrop Grumman E-8C Joint STARS
- Sud Aviation Caravelle 10B, 10R, 11R, and 12
- Kawasaki C-1( Japanese military transport) powered by the JT8D-M-9 manufactured by Mitsubishi
- 4 April 1977
- Southern Airways Flight 242 - both engines on the DC-9 failed when the pilots flew into a severe thunderstorm after misreading their onboard radar. The flight encountered severe rain and hail. The NTSB concluded that the "loss of thrust was caused by the ingestion of massive amounts of water and hail which in combination with thrust lever movement induced severe stalling in and major damage to the engine compressors." 63 people on-board and 9 on the ground died as a result of the accident.
- 22 August 1985
- British Airtours Flight 28M - an engine failed during take-off from Manchester Airport, the fire spreading into the cabin, resulting in 55 fatalities aboard the Boeing 737-236 Advanced.
- 21 December 1991
- Scandinavian Airlines Flight 751 - The engines on an MD-81 ingested wing ice during takeoff causing engine damage that led to a total loss of thrust on both engines. The aircraft crashed in a forest clearing with no fatalities.
- 6 July 1996
- An engine explosion happened on an MD-88, Delta Air Lines Flight 1288, just prior to take-off at Pensacola, Florida, USA, with two fatalities.
- 5 September 2005
- A Boeing 737-200 operated by Mandala Airlines crashed in Medan as Mandala Airlines Flight 091 with 96 passengers, five crew and 49 on the ground were killed. Sixteen passengers survived. The engine flamed out and lost power.
- 15 April 2008
- A DC9-51 operated by Hewa Bora Airways crashed and burned at Goma following an engine fire, with 40 fatalities.
Data from
- Type: Turbofan
- Length: 120.0" / 3048mm - 154.1" / 3914mm
- Diameter: 49.2" / 1250mm
- Dry weight: From 3200lb / 1454.5kg (JT8D) to 4740lb / 2154.5kg (JT8D-219)
- Compressor: Axial flow, 2-stage fan, 6-stage LP, 7-stage HP
- Combustors: Nine can-annular combustion chambers
- Turbine: 3-stage (1 stage HP 2 stage LP)
- Fuel type: 1
- Oil system: 1
- Maximum thrust: 21,700lbf / 96.5kN (JT8D-219)
- Overall pressure ratio: 16:1
- Air mass flow: 331 lb/sec
- Turbine inlet temperature: Unknown
- Fuel consumption: Unknown
- Specific fuel consumption: 0.744 [kg/daN.h]
- Thrust-to-weight ratio: About_4.8
- Related development
- Related lists
|Wikimedia Commons has media related to Pratt & Whitney JT8D.|
|This aircraft engine article is missing some (or all) of its specifications. If you have a source, you can help Wikipedia by adding them.|