London Underground 1938 Stock
||This article includes a list of references, but its sources remain unclear because it has insufficient inline citations. (March 2013) (Learn how and when to remove this template message)|
A preserved train of 1938 Stock at Amersham station
|In service||1938–1988 on London Underground
1989–present on Island Line
|Car length||DM 52 ft 3 3⁄4 in (15.94 m)
NDM/UNDM/T 51 ft 2 3⁄4 in (15.61 m)
|Width||8 ft 6 1⁄4 in (2.597 m)|
|Height||9 ft 5 1⁄2 in (2.883 m)|
|Weight||DM 27.4 long tons (27.8 t; 30.7 short tons)
NDM 25.9 long tons (26.3 t; 29.0 short tons)
T 20.65 long tons (20.98 t; 23.13 short tons)
|Stock type||Deep-level tube|
The 1938 Tube Stock is a London Underground tube stock design. A total of 1,121 cars were built by Metro-Cammell and Birmingham RC&W. An additional 167 cars (91 new builds plus 76 conversions) were subsequently added to the fleet, and the stock was used on the London Underground until 1988. During their long lives they worked on the Bakerloo, Northern, Piccadilly, East London and Central lines. Some examples are still at work on the Isle of Wight as Class 483, making them the oldest passenger rolling stock operating timetabled services on the National Rail network.
There were four types of car, one of which was produced in two forms:
- Driving Motor (DM)
- Non-Driving Motor (NDM) – no driving or door controls
- Special Non-Driving Motor (SNDM) – door controls only
- Trailer (T) – no motors or controls
As built, the 1938 Stock was numbered as follows:
|'A' DM||'D' DM||NDM||SNDM||T|
|10012 – 10323
90324 – 90333
|11012 – 11323
91324 – 91333
|12000 – 12028
92029 – 92058
12059 – 12157
12409 – 12411
12422 – 12446
92447 – 92466
012158 – 012388
092389 – 092408
012412 – 012421
012467 – 012476
Use on different lines
The 1938 Stock was built as part of the London Passenger Transport Board's New Works Programme 1935–1940. The trains were primarily intended for use on the Northern and Bakerloo lines, with an additional seven trains also being used on the Piccadilly line.
As part of the New Works Programme, the Northern and Central lines were to be extended over London and North Eastern Railway (LNER) tracks, and because of a joint working agreement between the LPTB and the LNER, it was necessary for a proportion of the Underground fleet to be owned by the LNER. Accordingly, 289 cars of 1938 Stock (DM numbers 10238–323 and 11238–323, NDM numbers 12117–57 and T numbers 012313–88) were designated as LNER owned, and fitted with plates marked "Property of LNER". Although 129 of these were to cover extensions to the Central line, none of them actually worked Central line services - they were mixed with the Northern and Bakerloo line fleets.
Throughout the 1950s and 1960s the Northern line was worked exclusively by 1938/1949 Stock trains. They were starting to show their age by the late 1960s; the first withdrawals from the Northern line took place in the early 1970s with the introduction of the 1972 Stock trains.
In the mid-1970s the Bakerloo line started to use 1972 Stock (Mark II) cars in addition to 1938 Stock. The 1972 Stock cars were intended for eventual use on the Jubilee line (which opened in 1979), thereafter the remaining section of the Bakerloo line continued to be served exclusively by 1938 Stock cars until the 1980s. The Bakerloo line trains received an "Extra Heavy Overhaul" (EHO) to keep them in service long after their intended withdrawal date. The Bakerloo line was thus the last line to be operated solely by 1938 Stock trains.
The Piccadilly line's few 1938 Stock trains operated alongside 1959 Stock for much of their lives. They were replaced by London Underground 1973 Stock, with the 1959 Stock being transferred to the Northern line, replacing other 1938 Stock trains.
During the 1970s the East London Line was worked by 1938 Stock trains, replacing trains of Q Stock. Single 1938 Stock trailer carriages were also inserted into 1960 Stock trains in the mid 80's; these were used on the Woodford–Hainault and Epping–Ongar sections of the Central line. In addition, unit 10177 (latterly shipped to Alderney) worked the Epping-Ongar shuttle between 11/57 and 6/60.
With the 1959 Stock approaching life-expiry, five ex-Bakerloo line trains of 1938 Stock were given a further overhaul in the mid-1980s. These were then used on the Northern line for a further two years, the last day of passenger service was on 19 May 1988. They were then sold for further use on the Isle of Wight (see below).
As part of the New Works Programme of 1935–1940, there were plans to operate nine-car trains of 1938 stock on the Northern line. These cars were originally numbered differently from the other cars, the first digit '1' being replaced by a '9'.
The formation for a nine-car train was DM + NDM + SNDM + T + NDM + T + SNDM + NDM + DM.
With the scaling back of the planned extensions for the Northern and Bakerloo lines, and the need to order further stock to balance the fleet(the 1949 stock), cars were renumbered in the early 1950s. The DMs and trailers had the '9' replaced by a '1', the DMs becoming 10324-10333, 11324-11333 and the trailers 012389-012408. Twenty-eight of the thirty NDMs were likewise renumbered, the exception being 92055 and 92058 which were rebuilt into Uncoupling Non-Driving Motors (UNDMs) along with all twenty SNDMs. The twenty two cars rebuilt into UNDMs were renumbered 30000-30021.
So successful was the 1938 Stock that, when in 1948 additional cars were needed, 91 almost identical cars were built, 70 non-driving-motor (NDM) cars and 21 trailer cars. These were known as 1949 stock and operated with the 1938 stock. They were numbered in the same scheme; the UNDMs were numbered 30022-30045, 31000-31045 and the trailers 012495-012515.
After World War II, the former 1935 stock streamlined DMs were rebuilt into trailers, and included with the 1938 stock, being renumbered 012477-012494. Before the war, three trailers were built for use with the streamlined DMs. These three cars differed from the 1938 trailers in that they were not equipped with compressors. However, the cars were not delivered until after the war and with the DMs rebuilt the three cars became part of the 1938 stock fleet, being numbered 012412-012414, and fitted with compressors.
Each motor car is fitted with two series DC motors, one on each of the two bogies and are designed to operate from the 630 volt traction supply. Each motor has an output of approximately 250 horsepower. The controllers and switchgear are operated from a 50 volt auxiliary supply provided by a motor-generator set. This system allows the master controller at one end of the train to simultaneously operate the switchgear on all the motor cars in a similar manner to the system developed by Sprague for the Elevated railway in Chicago, Illinois some 46 years earlier. This same supply is also used to power the train lighting as well as some other auxiliary circuits.
'A' and 'D' motor cars
The motor cars are divided into two distinct types, the 'A' end car and the 'D' end car. Each of the bogies fitted to the two cars are identical. This means that if the two motor cars at the two ends of a train were identical, they would attempt to pull the train in opposite directions. Consequently, the bogies on the 'D' end motor car are installed the other way around from the those on the 'A' end causing the two motor cars to move the train in the same direction.
The 'A' and 'D' designation is from the designation of the axles on the two bogies. The 'A' end car has the 'A' axle at the driving cab end of the car with the 'B' axle on the opposite end of the same bogie. The 'C' axle on the second bogie is nearest the driving cab with the 'D' axle closest to the coupled trailer car. The sequence is reversed on the 'D' end motor car. This is also why the alternate car is not designated the logically more obvious 'B' end.
Another mechanical difference between the two types of car is that the 'D' end car has a spring-loaded buffer at the driving cab end whereas the 'A' end car has a solid buffer.
These differences mean that when coupling two train sets together, the 'A' end of one set must be coupled to the 'D' end of the other. Although train sets are not normally split in day to day usage, they do have to be split when undergoing major maintenance tasks such as when the bodies are lifted off of the bogies. This is not a problem on most lines where all the train sets start and remain the same way around. However, on the Northern line the existence of the Kennington loop just south of Kennington station which allows Charing Cross branch trains to depart its southbound platform and arrive at its northbound platform reverses the complete train once every journey. This means that on this line, on average, half the trains will be facing the opposite direction to the remainder. Only sets facing the same way can be coupled together.
The 1938 design stock features the (by this time) standard series/parallel traction control using bridge transition. The control system has an unusual feature. Ordinarilly, the driver moves the master controller from 'off' up to 'full series' and then further to the 'full parallel' position when the train will be under full power.
The unusual feature is that once the driver has moved the controller to 'full parallel' and the train has accelerated to the point where the switchgear is actually in full parallel, the driver can then move the master controller back to 'full series'. The traction switchgear will remain in 'full parallel' unless the driver moves the master controller from 'full series' to any position towards 'off'. Many drivers took advantage of this feature because it was more comfortable maintaining the downward pressure on the deadman's handle with the handle at the 6 o'clock position (the 'full series' position) rather than the 9 o'clock position (the 'full parallel' position).
In 1938 fifty-eight 'Standard Stock' trailers, originally built in 1927, were converted to operate with the 1938 Stock. These cars were renumbered 70513–70570. The first car withdrawn was 70550, as a result of damage sustained in an accident at Watford in 1962, and the last car, 70534, was withdrawn in 1973.
Isle of Wight
The only examples still in daily use are the six units that survive operating the Island Line service on the Isle of Wight, and allocated TOPS Class 483. Ten sets (nine serviceable; a total of twenty cars) were bought by Network SouthEast from London Underground in 1988.
According to an article in the October 2005 issue of Rail Professional, Island Line were paying "an eye-watering £140,000 a year" to lease the trains, meaning that "[s]ince privatisation, HSBC Rail has pocketed over £1m for leasing these relics that are effectively worthless."
After running many years in Network SouthEast (NSE) colours, the trains were repainted into 'dinosaur'[clarification needed] livery. However, as of mid-2008, all trains had been returned to an approximation of their original LT train red livery; albeit with yellow fronts, as per mainline regulations.
|'A' DM||'D' DM|
In addition, some other units survive in preservation, including cars from the first-built unit, which are preserved at the London Transport Museum Depot in Acton. The preserved sets have been restored into their original red liveries, one with an orange roof (Bakerloo line) and one with a grey roof (other lines). The LTM operates trips of its preserved four-car set for railtours around the LU system. The 1938 stock is also used for occasional filming work. Dates and times can be found at their website and people can sign up to receive the Museum's e-newsletter. A cab has been preserved at London Transport Museum
- The Chronicles of Narnia: Prince Caspian (2008). The fantasy film features 1938 tube stock at the beginning and end of the film.
On 9 January 2013, 1938 tube stock appeared on a £1.28 British postage stamp as part of a set commemorating the 150th anniversary of the first London underground train journey. The stamp's captions read "Classic rolling stock" and "1938", with the caption's background in Bakerloo line colour.
- Not applicable to the Northern Line as trains are turned through 180 degrees each time they traverse the Kennington loop.
- Connor, Piers (1989). The 1938 Tube Stock. Harrow Weald: Capital Transport. p. 32. ISBN 1-85414-115-5.
- Hardy, Brian (2001). Underground Train File: Tube Stock 1933-1959. Harrow Weald: Capital Transport. pp. 68, 78–79. ISBN 1-85414-235-6.
- The two ends of most older style trams were identified as 'A' and 'B' (marked on the inside of the driving position). This was a reminder to the electical maintenance staff to reverse the field connections at the 'B' end relative to those at the 'A' end.
- Although the driver can select 'full parallel' the switchgear itself only allows the mechanism to select the next step in the accelerating sequence once the train is moving fast enough.
- Randall, Chris (October 2005). "The Rail Professional Interview: Haydn Abbott - Angel Trains" (PDF). Rail Professional (103): 17. ISSN 1476-2196. Retrieved 6 November 2009.
- Department of the Environment: Railway Inspectorate (1976). Report on the Accident that occurred on 28 February 1975 at Moorgate Station. HMSO. ISBN 0-11-550398-6.. "PDF copy" (PDF). The Railways Archive.
- "Royal Mail celebrates 150 years of the London Underground" (Press release). Royal Mail. 8 January 2013. Retrieved 13 January 2013.
- Media related to London Underground 1938 Stock at Wikimedia Commons
- London Transport Museum Photographic Archive
- District Dave's London Underground Site -1938 Tube Stock photos
- Tubeprune - Rolling Stock Summary