Boeing Model 40
|First flight||July 20, 1925|
|Introduction||July 1, 1927|
|Primary users||Boeing Air Transport
Varney Air Lines
Pacific Air Transport
|Number built||ca. 80|
The Boeing Model 40 was a United States mail plane of the 1920s. It was a single-engined biplane that was widely used for airmail services in the United States in the 1920s and 1930s, especially by airlines that later became part of United Airlines. It became the first aircraft built by the Boeing company to carry passengers.
Development and design
In 1925, the US Post Office issued a requirement for a mailplane to replace the ex-military DH-4s then in use. The new aircraft was required to use the same water-cooled Liberty V12 engine as used by the DH-4, of which large stocks of war-built engines were available. The resultant aircraft, the Boeing Model 40, was a conventional tractor biplane, with the required Liberty engine housed in a streamlined cowling with an underslung radiator. The aircraft's fuselage had a steel tube structure, with an aluminum and laminated wood covering. Up to 1,000 lb (450 kg) of mail was carried in two compartments in the forward fuselage, while the single pilot sat in an open cockpit in the rear fuselage. The wings and tail were of wooden construction, and the Model 40 had a fixed conventional landing gear.
The Contract Air Mail Act of 1925 set out the gradual privatization of the Post Office's Air Mail routes. In late 1926, bids were requested for the main transcontinental trunk mail route, which was to be split into eastern and western sections, with Boeing bidding for the western section. Boeing revived the design for the tender, with the Model 40A replacing the Liberty engine with a 425 hp (317 kW) air-cooled Pratt & Whitney Wasp radial engine, which was 200 lb (91 kg) lighter than the Liberty, ignoring the weight of the Liberty's radiator and cooling water. The fuselage was redesigned to make more extensive use of welded steel tubing, and an enclosed cabin was fitted between the mail compartments, allowing two passengers to be carried as well as 1,200 lb (540 kg) of mail. Boeing's bid of $3 per lb was much less than any of the competing bids, and Boeing was awarded the San Francisco to Chicago contract in January 1927, building 24 Model 40As for the route (with a further aircraft being used as a testbed by Pratt & Whitney).
The next model to reach production was the Model 40C, with an enlarged cabin allowing four passengers to be carried. Meanwhile, Boeing Air Transport's Model 40As were modified by replacing their Wasp engines with 525 hp (391 kW) Pratt & Whitney Hornet radial engines to become the Model 40B-2. The Model 40B-4 was a new-build aircraft combining the four-passenger cabin of the Model 40C with the Hornet engine of the B-2. Production continued until February 1932.
Boeing's airline, Boeing Air Transport, commenced operations on the San Francisco–Chicago route on July 1, 1927.
- Model 40
- Original 1925 design with Liberty engine.
- Model 40A
- Revised 1927 design for BATC. the aircraft was powered by a Pratt & Whitney Wasp radial engine, plus seating for two passengers in an enclosed cabin; 25 built. Received Dept of Air Commerce Approved Type Certificate #2.
- Model 40B
- Model 40As re-engined with a 525 hp (391 kW) Pratt & Whitney Hornet radial piston engine. 19 Model 40A were converted. Redesignated Model 40B-2.
- Model 40B-4
- Revised Model 40B with seating for four passengers and other improvements. Equipped with openable windows, plus seating for four passengers; 38 built.
- Model 40B-4A
- One Model 40B used as engine testbed by Pratt & Whitney.
- Model 40H-4
- Four Model 40B-4s built by Boeing Canada. Two aircraft were exported to New Zealand.
- Model 40C
- Similar to Model 40B-4 but with Pratt & Whitney Wasp engine of Model 40A. (ten built, all later converted to Model 40B-4 standard).
- Model 40X
- Unique special-order machine similar to Model 40C with only two-passenger cabin and extra open cockpit forward of pilot's cockpit.
- Model 40Y
- Unique special-order machine similar to Model 40X, but with Pratt & Whitney Hornet engine.
As of February 17, 2008, Boeing 40C c/n 1043 became the only airworthy example in the world. It also holds the title of the oldest flying Boeing in the world. In 1928, the aircraft was substantially damaged in a crash near Canyonville, OR. After being recovered, it was completely rebuilt over an eight-year period from 2000 to 2008 and an estimated 18,000 man hours by Pemberton and Sons Aviation in Spokane, Washington. On May 8, 2010, this airplane had an aerial rendezvous with Boeing's newest passenger aircraft, the Boeing 787 Dreamliner. This aircraft spends its winters living at the Western Antique Aeroplane & Automobile Museum in Hood River, Oregon.
The Museum of Flight in Seattle, Washington has a complete full-scale replica and two partially finished replica fuselages (showing what the original Boeing factory would have looked like circa 1928-29) on display.
Specifications (Model 40A)
Data from Boeing Aircraft since 1916
- Crew: one
- Capacity: two passengers and 1,200 lb (540 kg) mail
- Length: 33 ft 2 1⁄4 in (10.12 m)
- Wingspan: 44 ft 2 1⁄4 in (13.47 m)
- Height: 12 ft 3 1⁄8 in (3.74 m)
- Wing area: 547 sq ft (50.82 m²)
- Empty weight: 3,531 lb (1605 kg)
- Max. takeoff weight: 6000 lb (2727 kg)
- Powerplant: 1 × Pratt & Whitney Wasp, 420 hp (313 kW)
- Maximum speed: 128 mph (111 knots, 206 km/h)
- Cruise speed: 105 mph (91 knots, 169 km/h)
- Range: 650 mi (565 nmi, 1046 km)
- Service ceiling: 14,500 ft (4420 m)
- Rate of climb: 770 ft/min (3.9 m/s)
Accidents and incidents
- February 26, 1928: A Boeing Air Transport Model 40B (c/n 891, registration NC280) crashed near Marquette, Nebraska after the aircraft struck trees when flying low to avoid air turbulence; the passenger was killed, but the pilot survived.
- April 17, 1928: A Boeing Air Transport Model 40B (c/n 893, registration NC282) crashed at Federal, Wyoming, killing one of two on board.
- October 2, 1928: A Pacific Air Transport Model 40C (c/n 1043, registration NC5339) crashed on Canyon Mountain near Canyonville, Oregon, killing one of two on board.
- November 18, 1930: A Pacific Air Transport Model 40B-4 (c/n 1036, registration NC5340) crashed into a mountainside at 4500 feet in a snowstorm, killing all three on board.
- January 22, 1931: A Varney Air Lines Model 40B-4 (c/n 1148, registration NC741K) crashed into Bluff Mountain in dense fog, killing the pilot.
- May 5, 1931: A Pacific Air Transport Model 40B-4 (c/n 1044, registration NC5390) crashed into Las Tunas Canyon while attempting to land at Burbank Airport in low visibility, killing both crew.
- September 16, 1931: A Pacific Air Transport Model 40B-4 (c/n 1428, registration NC10347) crashed into San Francisco Bay after takeoff for reasons unknown, killing all four on board.
- November 23, 1931: A Boeing Air Transport Model 40, registration NC7465, crashed eight miles west of Salt Lake Airport, killing the pilot; it was believed that the plane overturned while attempting to land at night.
- November 26, 1931: A Varney Air Lines Model 40B-4 (c/n 1419, registration NC10338) crashed near Pasco, Washington in low visibility while attempting to land, killing the pilot.
- February 2, 1932: A Boeing Air Transport Model 40, registration NC7470, crashed on landing at Rio Vista, California; the plane struck an irrigation ditch and caught fire, killing one of two on board.
- May 3, 1932: A Varney Air Lines Model 40B-4 (c/n 1155, registration NC830M) crashed at Portland, Oregon, killing both crew.
- May 16, 1932: A Pacific Air Transport Model 40, registration NC5589, crashed and burned in fog while attempting to land at Burbank Airport, killing all three (both pilots, radioman) on board.
- December 14, 1932: A Boeing Air Transport Model 40B-4 (c/n 1168, registration NC842M) crashed at Rocky Ridge, Colorado, killing the pilot.
- Davies Air Enthusiast January/February 2007, p. 65.
- Bowers 1989, pp. 124–125.
- Taylor Air Enthusiast August–November 1983, p. 67.
- Bowers 1989, pp. 116–117.
- Davies Air Enthusiast January/February 2007, pp. 66–67.
- Taylor Air Enthusiast August–November 1983, p. 69.
- Bowers 1989, p. 129.
- Bowers 1989, p. 130.
- Davies Air Enthusiast January/February 2007, pp. 68–69.
- Gann (April 1973). "The Golden Age of Air Transport". Flying Magazine: 34.
- Boeing 40C Flies For the First Time in 80 Years VintageAircraft, 2008 - 02/21
- Lee Bottom Flying Field Archived May 9, 2008, at the Wayback Machine. This Just In
- Hagedorn Air Enthusiast July–November 1986, p. 60.
- Pemberton & Sons Aviation
- Boeing on 787 aerial rendezvous with 1928 Model 40. Seattlepi.com
- Bowers 1989, p. 127.
- Davies Air Enthusiast January/February 2007, p. 69.
- Bowers, Peter M. (1989). Boeing Aircraft since 1916 (Third ed.). London: Putnam Aeronautical Books. ISBN 0-85177-804-6.
- Davies, Ed (January–February 2007). "Boeing's Airline: The Life and Times of Boeing Air Transport: Part One". Air Enthusiast. No. 127. pp. 64–74. ISSN 0143-5450.
- Davies, Ed (March–April 2007). "Boeing's Airline: The Life and Times of Boeing Air Transport: Part Two". Air Enthusiast. No. 128. pp. 62–73. ISSN 0143-5450.
- Hagedorn, Daniel P. (July–November 1986). "From Caudillos to COIN". Air Enthusiast. No. Thirty-one. pp. 55–70. ISSN 0143-5450.
- Taylor, H. A. (August–November 1983). "When Boeing Flew The Mails". Air Enthusiast. No. Twenty-two. pp. 64–74. ISSN 0143-5450.
- Taylor, Michael J. H. (1989). Jane's Encyclopedia of Aviation. London: Studio Editions. p. 170.
- World Aircraft Information Files. London: Bright Star Publishing. File 890 Sheet 52.
|Wikimedia Commons has media related to Boeing 40.|