Delta II

From Wikipedia, the free encyclopedia

This is an old revision of this page, as edited by Yobot (talk | contribs) at 12:34, 12 October 2012 (WP:CHECKWIKI error 61 fix, References after punctuation per WP:REFPUNC and WP:PAIC using AWB (8459)). The present address (URL) is a permanent link to this revision, which may differ significantly from the current revision.

This article is about the rocket. For the submarine see Delta class submarine.
Delta II
A Delta II rocket launches from Cape Canaveral carrying the Dawn spacecraft.
FunctionLaunch vehicle
ManufacturerUnited Launch Alliance (Boeing IDS)
Country of originUnited States
Cost per launchUS$51 million (7920-10 mod.)[1]
Cost per year1987
Size
Height38.2 - 39 m (125.3 - 127 ft)
Diameter2.44 m (8 ft)
Mass151,700 - 231,870 kg
(334,300 - 511,180 lb)
Stages2 or 3
Capacity
Payload to LEO
Mass2,700 - 6,100 kg
(5,960 - 13,440 lb)
Payload to GTO
Mass900 - 2,170 kg
(1,980 - 4,790 lb)
Payload to HCO
Mass1,000 kg (2,200 lb)
Launch history
StatusActive
Launch sitesCape Canaveral SLC-17
Vandenberg AFB SLC-2W
Total launches151
Delta 6000: 17
Delta 7000: 128
Delta 7000H: 6
Success(es)149
Delta 6000: 17
Delta 7000: 126
Delta 7000H: 6
Failure(s)1 (Delta 7000)
Partial failure(s)1 (Delta 7000)
First flightDelta 6000: 14 February 1989
Delta 7000: 26 November 1990
Delta 7000H: 8 July 2003
Last flightDelta 6000: 24 July 1992
Boosters (6000 Series) - Castor 4A
No. boosters9
Engines1 Solid
Thrust478.3 kN (107,530 lbf)
Specific impulse266 sec
Burn time56 seconds
PropellantSolid
Boosters (7000 Series) - GEM 40
No. boosters3, 4 or 9
Engines1 Solid
Thrust492.9 kN (110,800 lbf)
Specific impulse274 sec
Burn time64 seconds
Propellantsolid
Boosters (7000 Heavy) GEM 46
No. boosters9
Engines1 solid
Thrust628.3 kN (141,250 lbf)
Specific impulse278 sec
Burn time75 seconds
Propellantsolid
First stage - Thor/Delta XLT-C
Engines1 RS-27A[2]
Thrust1,054.2 kN (237,000 lbf)
Specific impulse302 sec
Burn time265 seconds
PropellantRP-1/LOX
Second stage Delta K
Engines1 AJ-10
Thrust43.6 kN (9,800 lbf)
Specific impulse319 sec
Burn time431 seconds
PropellantDinitrogen tetroxide/Aerozine
Third stage - PAM-D (optional)
Engines1 Star 48B
Thrust66.0 kN (14,837 lbf)
Specific impulse286 sec
Burn time87 seconds
PropellantSolid
[edit on Wikidata]

Delta II is an American space launch system, originally designed and built by McDonnell Douglas. Delta II is part of the Delta rocket family and entered service in 1989. Delta II vehicles included the Delta 6000, the Delta 7000, and two 7000 variants ("Light" and "Heavy").

After McDonnell Douglas merged with Boeing in 1997, Delta II rockets were built by Boeing Integrated Defense Systems, until Delta rocket production became the responsibility of United Launch Alliance (ULA) on December 1, 2006.[3][4] ULA now markets Delta II to U.S. government customers, and Boeing Launch Services (BLS) markets Delta II to commercial companies.[5]

History

All United States expendable launch vehicles were planned to be phased out in favor of the Space Shuttle, but the Challenger disaster of 1986 led to Delta development being restarted.[citation needed] The Delta II was specifically designed to accommodate the GPS Block II series of positioning satellites. As of August 2007, Delta IIs have successfully launched 125 projects,[citation needed] including several NASA missions to Mars:

Delta II manufacturing, assembly and integration currently take place at facilities in Decatur, Alabama; Harlingen, Texas; San Diego, California; and Denver, Colorado.[5]

Vehicle description

A spent Delta-K second stage of the Delta II, photographed in orbit.

Deltas are expendable launch vehicles (ELVs), which means they can only be used once. Each Delta II launch vehicle consists of:

  • Stage I: RP-1 and liquid oxygen tanks that feed the Rocketdyne RS-27 main engine for the ascent.
  • Solid rocket booster motors: Used to increase thrust during the initial two minutes of flight. The medium-capacity Delta II has nine motors total (six fire on the ground, three in flight); the other models use only three or four.
  • Interstage: A spacer between stage I and stage II. The first friction stir welded interstage module was launched in 1999.
  • Stage II: Fuel and oxidizer tanks feeding a restartable hypergolic Aerojet AJ10-118K engine that fires one or more times to insert the vehicle-spacecraft stack into low Earth orbit. This propellant mixture is highly corrosive, so once loaded the launch must occur within approximately 37 days, or the stage will have to be refurbished or replaced.[6] This stage also contains the vehicle's "brains", a combined inertial platform and guidance system that controls all flight events.
  • Stage III: Optional ATK-Thiokol solid rocket motor provides the majority of the velocity change needed to leave Earth orbit and inject the spacecraft on a trajectory to Mars or other target beyond Earth orbit. It is connected to the spacecraft until it is done firing, and then separates. This stage is spin-stabilized and has no active guidance control; it depends on the second stage for proper orientation prior to Stage II/III separation. It also includes a yo-yo de-spin mechanism to slow the spin before spacecraft release, as many spacecraft cannot handle the high spin rates needed for stability of this stage. Note that some Delta II vehicles are two-stage only, these generally being used for Earth-orbit missions.
  • Payload fairing: Thin metal or composite payload fairing (aka "nose cone") to protect the spacecraft during the ascent through Earth's atmosphere.

Naming system

The Delta II family uses a four-digit system to generate its technical names:[7]

  • The first digit is either 6 or 7, denoting the 6000- or 7000-series Deltas. The 6000-series, last flown in 1992, had an Extra Extended Long Tank first stage with RS-27 main engine, plus Castor IVA solid rocket boosters. The current model 7000-series have an RS-27A engine, with a longer nozzle for higher expansion ratio and better high-altitude performance, and GEM (Graphite-Epoxy Motor) boosters. GEMs are larger, and have a composite casing to reduce mass versus the steel-cased Castors. In addition, two LR101-NA-11 vernier engines provide guidance for the first stage.
  • The second digit indicates the number of boosters, usually 9. In such cases, six are lit at liftoff and three are lit one minute into flight. On vehicles with 3 or 4 boosters, all are ignited at liftoff.
  • The third digit is 2, denoting a second stage with an Aerojet AJ10 engine. This engine is restartable, for complex missions. Only Deltas prior to the 6000-series used a different engine, the TR-201.
  • The last digit denotes the third stage. 0 denotes no third stage, 5 indicates a Payload Assist Module (PAM) stage with Star 48B solid motor, 6 indicates a Star 37FM motor.

For example, a Delta 7925 has the later first stage, nine GEM boosters, and a PAM third stage. A Delta 7320 is a two-stage vehicle with three boosters.

  • A Delta II-Heavy has the larger GEM-46 boosters, originally designed for the Delta III. These are designated 79xxH.

Three payload fairings are available. The original aluminum fairing, seen above, is 9.5 feet in diameter. A 10-foot fairing is made of composite, and can be distinguished by its tapering front and rear. A lengthened 10-foot fairing is used for the largest payloads.

Launch description

Launch vehicle build-up
A Delta II launch vehicle is assembled vertically on the launch pad. Assembly starts by hoisting the first stage into position. The solid rocket boosters are then hoisted into position and mated with the first stage. Launch vehicle build-up then continues with the second stage being hoisted atop the first stage.[8]
Fueling
It takes approximately 20 minutes to load the first stage with 10,000 US gallons (37,900 L) of fuel.[9]

Delta II launches

See also: List of Delta II launches

The Delta II system has been used for 151 launches. On September 18, 2007, Delta II completed its 75th consecutive successful launch.[10] This is a record for modern launch vehicles.[11] As of 2012, it is the most reliable launch vehicle in service, which it has been since the presumed retirement of the Tsyklon 2 in 2006.[12] Eight launches took place in 2007.

However, the Delta II system does not have a perfect success record. One mission, the launch of Koreasat-1 in 1995, was a partial failure in which the satellite payload was able to compensate when the launch system placed the vehicle in an incorrect orbit.[13]

Another failure, this time complete, occurred on January 17, 1997, when a Delta II 7925 carrying the first GPS Block IIR satellite, GPS IIR-1, exploded only 13 seconds after liftoff, raining flaming debris all over Launch Complex 17 at Cape Canaveral Air Force Station. No one was injured, and the launchpad itself was not seriously damaged, though several cars were destroyed and a few buildings were damaged.[14] It was later determined that a "17-foot crack" in the rocket booster had caused the failure.[15]

Notable payloads

Furthermore, between May 1997 and November 1998, Delta II vehicles placed 55 Iridium satellites into orbit.[16]

Post MLV-3

Comparison of standard and heavy Delta II variants.
Delta rocket evolution.

A 2007 article published by the Wall Street Journal speculated about the fate of the Delta II launch system after the U.S. Air Force discontinues its use of the Delta II.[17] Thomas Young, who was director of Goddard Space Flight Center from 1980 to 1982, is quoted as saying, "It's definitely an item people are quite worried about."

As of July 2012, three further Delta II launches are scheduled; carrying the SMAP and OCO 2 satellites in 2014, and the JPSS-1 satellite in 2016.[18] ULA had previously indicated that it had "around half a dozen" unsold Delta II rockets on hand.[19] A spokesperson indicated that ULA will change some aspects of the Delta II system once the current Medium Launch Vehicle 3 contract with the Air Force ends and requirements imposed by the contract are lifted. The Air Force contract required that Delta II be kept ready to launch within 40 days of call up, which led ULA to maintain two launch pads at Cape Canaveral. ULA indicated it would not continue to operate two launch pads.[19]

In August 2009, the NASA assistant associate administrator for the Launch Services Program stated that NASA might purchase additional Delta II launches beyond those it had planned at that time.[20] However on September 30, 2011, NASA modified the NASA Launch Services II (NLS-II) contract[21] to allow for the continuing order of Delta II launchers in agreement with ULA. Components for five additional Delta II vehicles had been built and two now remain unassigned to planned flights.[22] Under the terms of the revised NLS-II contract, only three Delta II configurations are available – the 7320-10, 7420-10 and 7920-10 – and launches are only available from SLC-2W at Vandenberg Air Force Base.[23] ULA has continued to update its product website[24] and continues to state that the vehicle is available for order for commercial or government offices.[25]

Comparable rockets

See also

References

  1. ^ http://www.spaceflight101.com/delta-ii-7920h-10.html
  2. ^ http://www.boeing.com/defense-space/space/delta/delta2/delta2.htm
  3. ^ United Launch Alliance Transaction completed
  4. ^ Delta rocket history, Boeing. Accessed 14 June 2008.
  5. ^ a b "United Launch Alliance Restructures Delta II Program for Long Term Viability". ULA. January 29, 2008.
  6. ^ Dr. Marc D. Rayman (2007-07-15). "DAWN Journal". JPL NASA. Retrieved 2008-09-06.
  7. ^ Forsyth, Kevin S. (2007-08-10). "Vehicle Description and Designations". History of the Delta Launch Vehicle. Retrieved 2008-03-15.
  8. ^ "Expendable Launch Vehicle Status Report". NASA. June 6, 2007.
  9. ^ "Swift Launch Pad Activities". 2004-11-18.
  10. ^ "DigitalGlobe Successfully Launches Worldview-1". DigitalGlobe.
  11. ^ Ray, Justin. "Mission Status Center (Delta 326)". Spaceflight Now. Retrieved 2007-09-26.
  12. ^ Space Launch Report - Active Launch Vehicle Reliability Statistics[dead link]
  13. ^ Krebs, Gunter Dirk. "Koreasat 1, 2 (Mugungwha 1, 2) / Europe*Star B".
  14. ^ "Unmanned rocket explodes after liftoff". CNN.com. 1997-01-17. Retrieved 2009-03-31.
  15. ^ The Deadly Aftermath of a Rocket Explosion Seconds After Launch
  16. ^ "Boeing Delta II to Launch New Additions to Iridium Constellation". Boeing.
  17. ^ Pasztor, Andy (2007-05-29). "Delta II's Fate Worries Nonmilitary Users". WSJ.
  18. ^ "NASA Selects Launch Services Contract For Three Missions". MarketWatch. 16 July 2012. Retrieved 16 July 2012.
  19. ^ a b Berger, Brian (2008-06-30). "Delta 2 Rockets to Remain Competitive Until 2015". Space News.
  20. ^ Stephen Clark (August 29, 2009). "NASA looking to solve medium-lift conundrum".
  21. ^ "NASA Launch Services Program Update". {{cite web}}: Missing or empty |url= (help); Text "http://www.nasa.gov/home/hqnews/2011/sep/HQ_C11-044_Delta_Ramp.html" ignored (help)
  22. ^ Ray, Justin. "NASA gives the Delta 2 rocket a new lease on life". SpaceFlightNow. Retrieved 17 July 2012.
  23. ^ "NASA Launch Services Program".
  24. ^ "Delta II website".
  25. ^ "2010 Delta II product card" (PDF).

External links

Media related to Delta (rocket) at Wikimedia Commons

Template:Link GA

Retrieved from "https://en.wikipedia.org/w/index.php?title=Delta_II&oldid=517383847"