North American Sabreliner
|United States Navy CT-39E of VR-30 in 1980|
|Manufacturer||North American Aviation
|First flight||September 16, 1958|
|Status||In active service|
|Primary users||United States Air Force
United States Navy
United States Marine Corps
The North American Sabreliner, later sold as the Rockwell Sabreliner, is an American mid-sized business jet developed by North American Aviation. It was offered to the United States Air Force (USAF) in response to its Utility Trainer Experimental (UTX) program. It was named "Sabreliner" due to the similarity of the wing and tail to North American's F-86 Sabre jet fighter. Military variants, designated T-39 Sabreliner, were used by the USAF, United States Navy (USN) and United States Marine Corps (USMC) after the USAF placed an initial order in 1959. The Sabreliner was also developed into a commercial variant.
Design and development
North American began development of the Sabreliner as an in-house project, and in response to the UTX request for proposals, offered a military version to the USAF. UTX combined two different roles, personnel transport and combat readiness training, into the same aircraft.
The civilian version prototype, which carried the model number NA-265, made its first flight on September 16, 1958. It was powered by a pair of General Electric YJ85 turbojet engines. The type received its FAA type certification in April 1963. The UTX candidate, designated the T-39A, was identical in configuration to the NA-265, but when the contract was awarded and the T-39A entered production, it was powered by two Pratt & Whitney JT12A-8 turbojet engines.
The civilian production version, or Series 40, was slightly refined over the prototype, with more speed and a roomier cabin. North American then stretched the design by 3 feet 2 inches, providing greater cabin space, and marketed it as the Series 60, which was certificated in April 1967. The cabin was made taller for the Series 70 and General Electric CF700 turbofans were installed for the Series 75A (also branded as the Series 80).
By 1973, North American had merged with Rockwell Standard under the name Rockwell International. In 1976 Rockwell contracted Raisbeck Engineering to redesign the wing of the Sabreliner series. The resulting Raisbeck Mark V wing was the first supercritical wing in service in the United States. The Mark V wing was combined with Garrett AiResearch TFE731 turbofan engines, to create the Series 65. Sabreliner models 60 and 80 were retrofitted with the Mark V wing as the Series 60A (STC SA687NW) and Series 80A (STC SA847NW).
Sabreliner production came to a close in 1981. The next year, Rockwell sold its Sabreliner division to a private equity firm which formed Sabreliner Corporation, the support organization for continuing operators.
Over 800 Sabreliners were produced, of which 200 were T-39s. A number of retired military T-39s have also entered the civilian world, since the military versions also carry FAA type certification. As of May 2007[update], 56 examples have been lost in accidents. The Series 65 was the last series run and 76 of them were produced, mostly for the private market. Monsanto has the oldest continuously operating company corporate jet division starting with its purchase of a Saberliner 40.
T-39s were used in support of combat operations in Southeast Asia during the Vietnam War. In late 1965 T-39s replaced Martin B-57 Canberras on flights to transport high-priority cargo, such as exposed film from photoreconnaissance missions, from outlying bases to Saigon.
The original Navy version, the T3J-1, redesignated T-39D after the 1962 redesignation of USN/USMC/USCG aircraft, was initially fitted with the radar system from the McDonnell F3H-1 Demon all-weather fighter and used as a radar trainer for pilots of that aircraft. The T-39D aircraft was subsequently introduced into the Basic Naval Aviation Observer (NAO), later Student Naval Flight Officer (SNFO) program. Three versions of the T-39D were used throughout the 1960s, '70s and '80s: one without radar for high altitude instrument navigation training and low altitude visual navigation training in the SNFO Intermediate syllabus, a second variant equipped with the APQ-126 radar from the LTV A-7 Corsair II for training primarily bombardier/navigators, reconnaissance attack navigators and electronic countermeasures officers in attack aircraft, and a third variant with the APQ-94 radar from the Vought F-8 Crusader for training radar intercept officers in fighter aircraft.
The T-39N and T-39G are currently used in the NFO Strike and Strike Fighter syllabi in training USN and USMC student Naval Flight Officers, and various NATO/Allied/Coalition student navigators. Foreign students also train in the T-39 in place of the Beechcraft T-1 Jayhawk during the Intermediate Jet syllabus.
The Sabreliner requires a minimum crew of two, and depending on cabin configuration, can carry up to seven passengers (NA-265 through NA-265-40) or ten passengers (NA-265-60 and subsequent models). As a Navy flight training aircraft, it will typically fly with a pilot, one or two NFO instructors and two to three student NFOs or student navigators/CSOs.
- (NA265 or NA246) Prototype powered by two General Electric J85-GE-X turbojet engines, one built sometimes unofficially called XT-39.
- Sabreliner 40
- (NA265-40 or NA282) Civil production variant for 11 passengers powered by two Pratt & Whitney JT12A-6A or -8 engines, two cabin windows each side; 65 built.
- Sabreliner 40A
A Sabreliner marketing version of the Sabre 40 with lighter avionics similar to the Aero Commander, also produced by Rockwell International at the time. In addition to the lighter avionics package, the interior was redesigned for lighter construction.
- Sabreliner 50
- (NA265-50 or NA287) One built in 1964 as a Model 60 with Pratt & Whitney JT12A engines, experimental platform for radome nose cowling.
- Sabreliner 60
- (NA265-60 or NA306) Stretched Model 40 for 12 passengers with two Pratt & Whitney JT12A-8 engines, five cabin windows each side, 130 built.
- Sabreliner 60A
- Series 60 with Mark V super-critical wing.
- Sabreliner 65
- (NA265-65 or NA465) Based on the Series 60 with Garrett AiResearch TFE731-3R-1D engines and new Mark V super-critical wing, 76 built.
- Sabreliner 75
- (NA265-70 or NA370) Series 60A with a raised cabin roof for greater cabin headroom, two Pratt & Whitney JT12A-8 engines; nine built.
- Sabreliner 75A (Sabreliner 80)
- (NA265-80 or NA380) Sabreliner 75 powered by two General Electric CF700 turbofan engines, 66 built.
- Sabreliner 80A
- Series 80 with Mark V super-critical wing.
- Sabreliner 90
- Series 80 without the Mark V super-critical wing. powered by two Pratt and Withney JT9D-3A compact engines.
- Pilot proficiency trainer and utility transport for the United States Air Force. Based on Sabreliner prototype but powered by two 3,000 lbf (13 kN) Pratt & Whitney J60-P3 engines, 143 built.
- T-39A modified as a cargo and personnel transport, powered by Pratt & Whitney J60-P3/-3A engines.
- One T-39A modified for electronic systems testing.
- Radar systems trainer for the United States Air Force, fitted with avionics of the Republic F-105D Thunderchief fighter bomber (including R-14 NASARR main radar and AN/APN-131 doppler radar) and with stations for three trainees, six built.
- Proposed radar systems trainer fitted with avionics of McDonnell F-101B Voodoo all-weather interceptor. Unbuilt.
- (NA265-20 or NA277) Radar systems trainer for the United States Navy, equipped with AN/APQ-94 radar for radar intercept officer training and the AN/APQ-126 radar for bombardier/navigator training. (T3J-1 prior to 1962 redesignation program.), 42 built.
- United States Navy cargo/transport version, with JT12A-8 engines, originally designated VT-39E, seven second-hand aircraft.
- Electronic warfare crew training conversion of the T-39A for the United States Air Force, for training of F-105G "Wild Weasel" crews.
- United States Navy cargo/transport version based on the stretched fuselage Sabreliner 60, Pratt & Whitney JT12A engines equipped with thrust reversers, 13 bought.
- CT-39G modified for the Undergraduate Flight Officer Training program.
- Navy trainer for the Undergraduate Flight Officer Training program.
- Original United States Navy designation that became the T-39D in 1962.
- Bolivian Air Force (One series 65 FAB-005 used as military and Presidential transport)
- Swedish Air Force (One series 65, local designation Tp 86)
- United States
- United States Air Force (149 with T-39 designations)
- United States Navy (51 with T-39 designations)
- BAE Systems Inc. (T-39A)
- Federal Aviation Administration (Series 80)
- National Test Pilot School
Accidents and incidents
On January 28, 1964, a USAF T-39 Sabreliner flying from West Germany on a training mission crossed into East German airspace and was shot down by a Soviet Mikoyan-Gurevich MiG-19 near Vogelsberg, killing all three on board.
On April 13, 1973, a Sabreliner NA-265-60 operated by Continental Airlines, N743R, crashed after takeoff at Montrose Airport in Montrose, Colorado following the uncommanded deployment of the port side thrust reverser. The two pilots, the only occupants of the aircraft, were killed and the aircraft was destroyed by impact forces and a post impact fire.
On February 23, 1975, a Sabreliner 75A operated by General Motors with registration number N5107, crashed on final approach 4 miles from Pontiac, Michigan. The aircraft was damaged beyond repair. The only occupants of the aircraft were the pilot and co-pilot, of which the pilot was killed in the crash. The accident was attributed to improper IFR operation.
On December 21, 1975, BuNo 157352, a USN T-39E conducting a Transport Aircraft Commander-Syllabus One (TAC-1) flight, crashed along the Mendocino Ridge, approximately ten miles southwest of Ukiah, California. Two U.S. Navy pilots were aboard and both were killed.
On April 1, 1977, BuNo 150545, a USN T-39D conducting a Student Naval Flight Officer low-level flight training sortie, crashed in the Laguna Mountains eight miles east-southeast of Julian, California killing all five instructors and students aboard.
On April 20, 1985, AF ser. No. 62-4496, a USAF CT-39A experienced brake failure on landing at the Wilkes-Barre Scranton International Airport, killing all five passengers and crew aboard, including General Jerome F. O'Malley, Commander, Tactical Air Command.
On June 3, 1988, an Ecuadorian Air Force Rockwell Sabreliner 60 clipped a building and crashed in a residential area of Quito, killing all ten people on board (including the commander of the Ecuadorian Army), and another three people on the ground.
On July 12, 1988, a US Navy CT-39E ditched off the coast of Vietnam after running low on fuel following failure of the aircraft's navigation issues.[clarification needed] The crew of three was rescued by the Vietnamese Navy and returned to the United States.
On May 8, 2002, two USN T-39Ns from Training Squadron 86 (VT-86) at NAS Pensacola, Florida, collided in mid-air during Student Naval Flight Officer air intercept training 40 miles off the Gulf Coast, killing all seven instructors and students on board the two aircraft.
On January 13, 2006, a USN T-39N Sabreliner conducting Student Naval Flight Officer/Student USAF Navigator-Weapon Systems Officer low-level flight training crashed in a densely forested area in rural Georgia, killing all four crew members.
On August 16, 2015, a private Sabreliner collided with a Cessna 172 on approach to Brown Field Municipal Airport in southern San Diego County, California, killing the five people on board the two aircraft. The cause was found to be Air Traffic Control error.
Aircraft on display
- CT-39A, AF Ser. No. 61-0674, at Hill Aerospace Museum, Hill Air Force Base, Roy, Utah
- CT-39A, AF Ser. No. 60-3495, on pylon display at Scott Air Force Base, Illinois
- T-39A, AF Ser. No. 61-0634, Dyess Linear Air Park, Dyess Air Force Base, Texas
- CT-39A, AF Ser. No. 62-4449, Pima Air and Space Museum, adjacent to Davis-Monthan Air Force Base, Tucson, Arizona 
- CT-39A, AF Ser. No. 62-4461, at the Museum of Aviation, Robins Air Force Base, Warner Robins, Georgia
- CT-39A, AF Ser. No. 62-4462, at Travis Air Force Base Heritage Center / Jimmy Doolittle Air & Space Museum, Travis Air Force Base, Fairfield, California
- CT-39A, AF Ser. No. 62-4465, at March Field Air Museum, March Air Reserve Base (former March Air Force Base), Riverside, California
- CT-39A, AF Ser. No. 62-4478, at the Presidential Gallery of the National Museum of the United States Air Force, Wright-Patterson Air Force Base, Ohio 
- T-39A, AF Ser. No, 62-4487, at the Strategic Air and Space Museum in Ashland, Nebraska
- T-39D, BuNo 150985, Sherman Field area, Naval Air Station Pensacola, Florida 
- T-39D, BuNo 151338, Southern Museum of Flight, Birmingham-Shuttlesworth International Airport, Birmingham, Alabama 
- T-39E, AF Ser. No. undetermined, Air Classics Museum of Aviation, Aurora Municipal Airport, Sugar Grove, Illinois
- CT-39G, BuNo 160056, National Naval Aviation Museum, Naval Air Station Pensacola, Florida 
- Sabreliner 40 at Spartan College of Aeronautics and Technology in Tulsa, Oklahoma. It was Bob Hoover's demonstration plane.
- Sabreliner 40 at City Museum in St. Louis, Missouri. Displayed as an interactive work of art. 
- Sabreliner 50 at Evergreen Aviation & Space Museum in McMinnville, Oregon. It was donated to the museum in January 2013 
Data from T-39 Sabreliner on Boeing History site
- Crew: four–five
- Capacity: five–seven passengers
- Length: 44 ft (13.41 m)
- Wingspan: 44 ft 6 in (13.56 m)
- Height: 16 ft (4.88 m)
- Wing area: 342.1 ft² (31.79 m²)
- Empty weight: 9,257 lb (4,199 kg)
- Max. takeoff weight: 17,760 lb (8,056 kg)
- Powerplant: 2 × Pratt & Whitney J60-P-3 turbojet, 3,000 lbf (13.3 kN) each
- Maximum speed: 478 knots (550 mph, 885 km/h)
- Cruise speed: 435 knots (500 mph, 800 km/h)
- Range: 2,170 nm (2,500 mi, 4,020 km)
- Service ceiling: 40,000+ ft (12,200+ m)
- Thrust/weight: 0.338
- Aircraft of comparable role, configuration and era
- T-39 Sabreliner at Boeing History
- The Rockwell Sabreliner on Airliners.net
- "North American T-39A Sabreliner". National Museum of the United States Air Force.
- "Sabreliner Structural Repair Manual – All Models NA-265 Aircraft", Report No. NA-66-1032 Revision 10, March 16, 1990.
- Company Bio Archived 2014-10-06 at the Wayback Machine. Retrieved August 18, 2014.
- Timmons, Lawrence M. "Improving Business Jet Performance – The Mark V Sabreliner", SAE 790582, presented at the Business Aircraft Meeting and Exposition Century II, Wichita Kansas, April 1976
- Mathwing, George E., "The Rockwell International Sabreliner 65 Case Study in Aircraft Design"
- "Rockwell Sabreliner. 56 hull-loss occurrences, last updated 5 May 2007." Aviation Safety Network.
- Jeremy R. C. Cox, St Louis Air and Space Museum. St. Louis Aviation.
- Harvey 1966, p. 69
- Air International July 1976, pp. 8–9.
- Air International July 1976, pp. 9–10.
- Air International July 1976, p. 10.
- Air International July 1976, pp. 10, 12.
- "San Diego air crash kills 5". Star-News. Pasadena,CA. 2 April 1977. p. 1.
- Casey, Aloysius G.; Casey, Patrick A. (2007). Velocity : speed with direction : the professional career of Gen Jerome F. O'Malley. Maxwell Air Force Base, AL: Air University Press. pp. 247–253. ISBN 978-1585661695.
- "accident record". Retrieved 21 August 2015.
- "National Briefing – South: Florida: Search For Crash Victims". The New York Times. May 10, 2002.
- "Arlington Cemetery website". Retrieved 2 March 2012.
- Perry, Tony (16 August 2015). "Two planes collide near San Diego's Brown Field; 3 dead". Los Angeles Times. Retrieved 16 August 2015.
- "AUTHORITIES: 5 DEAD IN MIDAIR COLLISION OF SMALL PLANES IN SAN DIEGO COUNTY". Associated Press. 16 August 2015. Archived from the original on 18 August 2015. Retrieved 16 August 2015.
- "Educating Controllers on Two Midair Collisions" (PDF). National Transportation Safety Board. 14 November 2016. Retrieved 19 November 2016.
- "Archived copy" (PDF). Archived from the original (PDF) on 2013-02-21. Retrieved 2014-08-22.
- "Archived copy". Archived from the original on 2015-01-20. Retrieved 2014-08-22.
- "Archived copy". Archived from the original on 2014-04-21. Retrieved 2014-08-22.
- "North American T-39A Sabreliner." National Museum of the US Air Force. Retrieved: 13 September 2015.
- "Archived copy". Archived from the original on 2014-08-21. Retrieved 2014-08-21.
- T-39D Sabreliner - Birmingham, AL – Waymarking.com
- [Attractions Archived 2008-03-22 at the Wayback Machine.. City Museum. Retrieved on 2010-11-03.]
- Type Certificate Data Sheet A2WE
- "Model Designation of Military Aerospace Vehicles" (PDF). United States Department of Defense. 2004-05-12. pp. 60–61. Archived from the original (PDF) on 2004-11-14. Retrieved 2007-01-20.
- "The Stylish Sabreliner". Air International, Volume 11, No. 1, July 1976. pp. 7–14, 36–39.
- Harvey, Frank (November 1966). "The Air War in Vietnam". Flying. New York: Ziff-Davis Publishing Company. pp. 38–95.
|Wikimedia Commons has media related to North American Sabreliner.|