Northrop F-89 Scorpion
|Formation of three F-89Ds of the 59th Fighter Squadron, Goose Bay, Labrador|
|First flight||16 August 1948|
|Primary user||United States Air Force|
|Number built||1,050 and 2 prototypes|
The Northrop F-89 Scorpion was an American all-weather interceptor built during the 1950s, the first jet-powered aircraft designed as such from the outset to enter service. Though its straight wings limited its performance, it was among the first United States Air Force (USAF) jet fighters equipped with guided missiles and notably the first combat aircraft armed with air-to-air nuclear weapons (the unguided Genie rocket).
Design and development
The Scorpion stemmed from a United States Army Air Forces (USAAF) Air Technical Service Command specification ("Military Characteristics for All-Weather Fighting Aircraft") for a night fighter to replace the P-61 Black Widow. The preliminary specification, sent to aircraft manufacturers on 28 August 1945, required two engines and an armament of six guns, either .60-caliber (15 mm) machine guns or 20-millimeter (0.79 in) autocannon. The revised specification was issued on 23 November; it did not specify jet propulsion, but the desired maximum speed of 530 miles per hour (850 km/h) virtually dictated that all the submissions would be jet-powered. The aircraft was to be armed with aerial rockets stored internally and six guns split between two flexible mounts, four guns forward and two in the rear. Each mount had to be capable of 15° of movement from the longitudinal axis of the aircraft. Each mount's guns were to be automatically controlled by radar. For ground attack, it had to be capable of carrying 1,000-pound (450 kg) bombs and to be able to carry a minimum of eight rockets externally. Bell Aircraft, Consolidated-Vultee, Douglas Aircraft, Goodyear, Northrop and Curtiss-Wright all submitted proposals. In March 1946, the USAAF selected the Curtiss-Wright XP-87, adapted from their proposed XA-43 attack aircraft, and Northrop's N-24 design, one of four submitted by the company.
The N-24, designed by Jack Northrop, was a slim-bodied swept-wing aircraft with a two-man pressurized cockpit and conventional landing gear. To reduce drag, the two Allison J35 turbojet engines were buried in the lower fuselage, directly behind their air intakes, and they exhausted underneath the rear fuselage. The horizontal stabilizer was mounted just above the junction of the vertical stabilizer with the fuselage and had some dihedral.
A contract for two aircraft, now designated the XP-89, and a full-scale mock-up was approved on 13 June, although construction of the mock-up had begun immediately after the USAAF announced that the N-24 had been selected. It was inspected on 25 September, and the USAAF was not impressed. The inspectors believed that the radar operator needed to be moved forward, closer to the pilot, with both crewmen under a single canopy, the magnesium components of the wing replaced by aluminum, and the fuel stowage directly above the engines moved. Other changes had to be made as wind tunnel and other aerodynamic tests were conducted. The swept wings proved to be less satisfactory at low speeds, and a thin straight wing was selected instead. Delivery of the first prototype was scheduled for November 1947, 14 months after the inspection. The position of the horizontal stabilizer proved to be unsatisfactory, as it was affected by the engine exhaust, and it would be "blanked-out" by airflow from the wing at high angles of attack. It was moved halfway up the tail, but its position flush with the leading edge of the vertical stabilizer proved to cause extra drag through turbulence and reduced the effectiveness of the elevators and rudder. Moving the horizontal stabilizer forward solved the problem. Another major change occurred when USAAF revised its specification to delete the rear gun installation on 8 October. Another inspection of the mock-up was held on 17 December, and the inspectors only suggested minor changes, even though the fuselage fuel tanks were still above the engines. Northrop's efforts to protect the fuel tanks were considered sufficient, as the only alternative was to redesign the entire aircraft.
The XP-89 had a thin, straight, mid-mounted wing and a crew of two, seated in tandem. The slim rear fuselage and the high-mounted horizontal stabilizer led Northrop employees calling it the Scorpion—a name later formally adopted by the Air Force. The intended armament of four 20 mm M-24 cannon in a small nose turret was not ready when the XP-89 was completed in 1948. Pending the availability of either of the two turrets under development, an interim six-gun fixed installation, with 200 rounds per gun, was designed for the underside of the nose. The thin wing had a aspect ratio of 9% and used a NACA 0009-64 section, which was selected for its low drag at high speed and stability at low speeds. A further advantage of the straight wing was that it could accommodate heavy weights at the wingtips. The wing could not fit the circular-type ailerons used in the P-61, so Northrop used the "decelerons" designed for the unsuccessful XP-79 prototype. These were clamshell-style split ailerons, which could be used as conventional ailerons, as dive brakes, or function as flaps as needed. All flying surfaces, the flaps and the landing gear were hydraulically powered. The thin wing dictated tall, thin, high-pressure (200 psi (1,379 kPa; 14 kgf/cm2)) mainwheel tires, while the low height of the fuselage required the use of dual wheels for the nose gear.
The terms of the initial contract were revised and formalized on 21 May 1947 with the price increased to $5,571,111. The delivery date of the first aircraft was scheduled 14 months (July 1948) from signing and the second 2 months after that. A month before the prototype made its first flight on 16 August 1948 at Muroc Army Air Field, the USAF changed its designation for fighter aircraft from "P" to "F". The XF-89 was fitted with 4,000 lbf (17.8 kN) J-35-A-9 turbojets and proved to be seriously underpowered. Initial flights were made with conventional ailerons, decelerons not being installed until December.
Several months earlier the Air Force conducted a competitive evaluation of the three existing all-weather interceptor prototypes, the XF-87, the XF-89, and the US Navy's XF3D Skyknight. The evaluators were qualified night-fighter pilots, radar operators, and experienced maintenance non-commissioned officers. The pilots were not impressed with any of the aircraft and recommended procurement of an interim aircraft that resulted in the development of the Lockheed F-94 Starfire from the training version of the Lockheed F-80 Shooting Star. The F-89 proved to be the fastest of the three contenders, although it was in last place in cockpit arrangement and ease of maintenance. One pilot claimed that the XF-89 was the only real fighter and compared the XF-87 to a medium bomber and the XF3D to a trainer. The full Committee on Evaluation overruled those evaluators, preferring the Douglas design and selecting the XF-89, as it had the greatest potential for development. The Air Force subsequently canceled the production contract for the F-87 to free up money for the Scorpion.
By November 1949 the second aircraft was virtually complete, but the Air Force was concerned about the design's poor thrust-to-weight ratio and decided to implement a weight-reduction program, as well as upgrading the engines to the more powerful J-33-A-21 fitted with an afterburner. Other major changes included the replacement of the nose gun turret by the Hughes-designed six-gun nose, AN/ARG-33 radar, and E-1 fire-control system, permanent wing-tip fuel tanks, and the ability to lower the complete engine for better maintenance access. The new nose added 3 feet (0.91 m) to the length of the aircraft. It was redesignated YF-89A to better reflect its role as a pre-production testbed to evaluate equipment and changes planned for the F-89A production aircraft. The aircraft was essentially complete by February 1950.
After repairs from a crash landing on 27 June 1949, the XF-89 was flown to March AFB to participate in the RKO movie Jet Pilot in February 1950. Shortly afterward, the aircraft crashed on 22 February, killing the observer, when flutter developed in the elevator and the subsequent vibrations caused the entire tail to break off. Construction of the production models was suspended until the reasons for the accident were discovered. Engineering and wind-tunnel tests revealed that the geometry of the rear fuselage and the engine exhaust created flutter-inducing turbulence that was aggravated by the high-frequency acoustic energy from the exhaust. Fixes for the problem involved the addition of a "jet wake fairing" at the bottom rear of the fuselage between the engines, external ("ice tong") mass balances for the elevator, pending the design of internal mass balances, and the addition of exhaust deflectors to the fuselage to reduce the turbulence and the consequent flutter.
Well before the YF-89A was complete, a $39,011,622 contract was awarded to Northrop on 13 May 1949 for 48 F-89A aircraft, one static test airframe and the modifications made to the YF-89A.
Production was authorized in January 1949, with the first production F-89A flying in September 1950. It had AN/APG-33 radar and an armament of six 20 mm (.79 in) T-31 cannons with 200 rpg. The swiveling nose turret was abandoned, and 300 US gal (1,100 l) fuel tanks were permanently fitted to the wingtips. Underwing racks could carry 16 5 in (127 mm) aerial rockets or up to 3,200 lb (1,455 kg) of bombs.
Only 18 F-89As were completed, which were mainly used for tests and trials, before the type was upgraded to F-89B standard, with new avionics. The type entered service with the 84th Fighter-Interceptor Squadron in June 1951. These had considerable problems with engines and other systems, and soon gave way to the F-89C. Despite repeated engine changes, problems persisted, compounded by the discovery of structural problems with the wings that led to the grounding of the F-89 and forced a refit of 194 -A, -B, and -C models.
The major production model was the F-89D, which first flew 23 October 1951 and entered service in 1954. It removed the cannon in favor of a new Hughes E-6 fire control system with AN/APG-40 radar and an AN/APA-84 computer. Armament was two pods of 52 2.75 in (70 mm) "Mighty Mouse" FFAR rockets, for a total of 104. A total of 682 were built. In August 1956 a pair of F-89D interceptors were scrambled from Oxnard Air Force Base to shoot down a runaway F6F-5K drone leading to The Battle of Palmdale incident.
Proposed re-engined F-89s, designated F-89E and F-89F, were not built, nor was a proposed F-89G that would have used Hughes MA-1 fire control and GAR-1/GAR-2 Falcon air-to-air missiles like the Convair F-106 Delta Dart.
The subsequent F-89H, which entered service in 1956, had an E-9 fire control system like that of the early F-102 and massive new wingtip pods each holding three Falcons (usually three semi-active radar homing GAR-1s and three infrared GAR-2s) and 21 FFARs, for a total of six missiles and 42 rockets. Problems with the fire control system delayed the -H's entry into service, by which time its performance was notably inferior to newer supersonic interceptors, so it was phased out of USAF service by 1959.
The final variant was the F-89J. This was based on the F-89D, but replaced the standard wingtip missile pod/tanks with 600 gal (2,271 l) fuel tanks and fitted a pylon under each wing for a single MB-1 Genie nuclear rocket (sometimes supplemented by up to four conventional Falcon air-to-air missiles). The F-89J became the only aircraft to fire a live Genie as the John Shot of Operation Plumbbob on 19 July 1957. There were no new-build F-89Js, but 350 -Ds were modified to this standard. They served with the Air Defense Command, later renamed the Aerospace Defense Command (ADC), through 1959 and with ADC-gained units of the Air National Guard through 1969. This version of the aircraft was extensively used within the Semi Automatic Ground Environment (SAGE) air defense system.
A total of 1,050 Scorpions of all variants were produced.
- First prototype, powered by two 4,000 lbf (17.8 kN) Allison J-35-A-9 engines.
- Second prototype. Fitted with more powerful (5,100 lbf (22.7 kN) dry, 6,800 lbf (30.3 kN) with afterburner) J-35-A-21A engines and revised, pointed nose with cannon armament.
- First production version, eight built. Fitted with revised tailplane and six cannon armament.
- F-89As converted into drone control aircraft.
- Second production version with upgraded avionics. 40 built.
- F-89Bs converted into drone control aircraft.
- Third production version with more powerful engines (5,600 lbf (25.0 kN) dry, 7,400 lbf (32.0 kN) with afterburning J-35-A-21 or −33). 164 built.
- Conversion of one F-89B to test new avionics and armament of F-89D.
- Main production version which saw deletion of the six 20 mm (.79 in) cannons in favor of 104 rockets in wing pods, installation of new Hughes E-6 fire control system, AN/APG-40 radar and the AN/APA-84 computer. This new system allowed the use of a lead-collision attack in place of the previous lead-pursuit-curve technique. A total of 682 built.
- One-off prototype to test the Allison YJ71-A-3 engine (7,000 lbf (31.2 kN) dry, 9,500 lbf (42.4 kN) with afterburner), converted from F-89C.
- Proposed version with new fuselage, wings, and J71-A-7 engines (10,200 lbf (45.4 kN) dry, 14,500 lbf (64.5 kN) with afterburner), never built.
- Proposed version equipped with Hughes MA-1 fire control and GAR-1/GAR-2 Falcon air-to-air missiles, never built.
- Modified F-89D to test features of F-89H. Three converted.
- Version with E-9 fire control system, six GAR-1/GAR-2 Falcon missiles and 42 Folding Fin Aircraft Rockets (FFAR). 156 built.
- Conversion of F-89D with underwing hardpoints for two MB-1 (later AIR-2) Genie nuclear armed rocket and four Falcon missiles, and carrying either the standard F-89D rocket/fuel pod or pure fuel tanks. A total of 350 were converted from F-89Ds.
Aircraft on display
- 52-1862 – Elmendorf AFB, Anchorage, Alaska.
- 53-2463 – Museum of Aviation, Robins Air Force Base, Georgia.
- 53-2494 – home base of the 158th Fighter Wing, Vermont Air National Guard, Burlington Air National Guard Base, Vermont.
- 53-2519 – Planes of Fame Museum, Chino, California.
- 53-2536 – EAA AirVenture Museum, Oshkosh, Wisconsin.
- 53-2610 – Air Force Armament Museum, Eglin Air Force Base, Florida.
- 53-2646 – Friendship Park, Smithfield, Ohio.
- 53-2674 – Pima Air & Space Museum (adjacent to Davis-Monthan Air Force Base), Tucson, Arizona.
- 53-2677 – Minnesota Air National Guard Museum, Minneapolis, Minnesota.
- 54-0298 – Dyess Linear Air Park, Dyess Air Force Base, Texas.
- 54-0322 – Hill Aerospace Museum, Hill Air Force Base, Utah.
- 52-1856 – Bangor International Airport / Bangor Air National Guard Base (former Dow AFB), Maine.
- 52-1896 – New England Air Museum, Windsor Locks, Connecticut.
- 52-1911 (painted as 53-2509) – National Museum of the United States Air Force, Wright-Patterson Air Force Base, Dayton, Ohio. This aircraft was the last F-89 remaining in service when it was transferred to the Museum from the Maine Air National Guard in July 1969.
- 52-1927 – Castle Air Museum (former Castle AFB), Atwater, California.
- 52-1941 – Peterson Air and Space Museum, Peterson Air Force Base, Colorado.
- 52-1949 – March Field Air Museum, March Air Reserve Base (former March AFB), Riverside, California.
- 52-2129 – Air Power Park and Museum (near Langley Air Force Base), Hampton, Virginia.
- 53-2547 – 120th Fighter Wing of the Montana Air National Guard at Great Falls Air National Guard Base, Great Falls International Airport, Montana. It is the only F-89 to have ever fired a Genie rocket with a live nuclear warhead, having done so as part of Operation Plumbob.
- 53-2453 – Heritage Flight Museum, Bellingham, Washington.
- 53-2604 – 119th Wing of the North Dakota Air National Guard, Fargo Air National Guard Base / Hector Field, Fargo, North Dakota.
Data from Scorpion with a Nuclear Sting
- Crew: 2
- Length: 53 ft 9 1⁄2 in (16.40 m)
- Wingspan: 59 ft 8 1⁄2 in (18.20 m)
- Height: 17 ft 6 in (5.33 m)
- Wing area: 606 ft2 (56.30 m2)
- Empty weight: 25,194 lb (11,428 kg)
- Loaded weight: 37,190 lb (16,869 kg)
- Max. takeoff weight: 42,241 lb (19,161 kg)
- Powerplant: 2 × Allison J35-A-35 afterburning turbojets
- Dry thrust: 5,440 lbf (24.26 kN) each
- Thrust with afterburner: 7,200 lbf (32.11 kN) each
- Maximum speed: 635 mph (552 knots, 1,022 km/h) at 10,600 ft (3,200 m)
- Ferry range: 1,366 mi (1,188 nm, 2,200 km)
- Service ceiling: 49,200 ft (15,000 m)
- Rate of climb: 7,440 ft/min (37.8 m/s)
- 104 × 2.75 in (70 mm) "Mighty Mouse" folding-fin aerial rockets
- 16 × 5 in (127 mm) aerial rockets on underwing racks or
- Bombs: 3,200 lb (1,500 kg)
- Aircraft of comparable role, configuration and era
- Avro Canada CF-100
- Lockheed F-94 Starfire
- North American F-86D Sabre
- Sud Aviation Vautour
- Yakovlev Yak-25
- Related lists
- Knaack 1978, p. 93.
- Knaack 1978, p. 96.
- Kinsey 1992, p. 3
- Blazer and Dorio 1993, pp. 1–3.
- Air International July 1988, pp. 44–45.
- Air International July 1988, p. 45.
- Isham and McLaren, p. 9.
- Blazer and Dorio 1993, pp. 5–7, 9.
- Isham and McLaren, pp. 9–10.
- Blazer and Dorio 1993, pp. 6–8.
- Davis and Menard 1990, p. 5.
- Air International July 1988, pp. 45–46.
- Davis and Menard 1990, p. 4.
- Air International July 1988, p. 46.
- Blazer and Dorio 1993, pp. 9–10.
- Blazer and Dorio 1993, p. 12.
- Blazer and Dorio 1993, p. 16.
- Blazer and Dorio 1993, pp. 15–16, 19.
- Davis and Menard 1990, p. 7.
- Blazer and Dorio 1993, p. 25.
- Knaack 1978, p. 85.
- Air International July 1988, pp. 47–48.
- Knaack 1978, p. 87.
- Knaack 1978, pp. 88–89.
- Air International August 1988, pp. 88–89.
- Green and Swanborough 1994, pp. 457–458.
- Angelucci and Bowers 1987, p. 370.
- Ramirez, Charles E. "Selfridge museum to restore fighter jet." The Detroit News, 18 April 2012. Retrieved: 18 April 2012.
- Air International August 1988, p. 92.
- "Standard Aircraft Characteristics: Northrop F-89F "Scorpion"." National Museum of the United States Air Force. Retrieved: 23 October 2016.
- Angelucci and Bowers 1987, p. 372.
- Air International August 1988, pp. 89–90.
- Air International August 1988, p. 90.
- "F-89 Scorpion/49-2457." aerialvisuals.ca Retrieved: 2 February 2015.
- "F-89 Scorpion/52-1862." aerialvisuals.ca Retrieved: 2 February 2015.
- "F-89 Scorpion/53-2463." Robins Air Force Base. Retrieved: 25 September 2011.
- "F-89 Scorpion/53-2494." aerialvisuals.ca Retrieved: 2 February 2015.
- "F-89 Scorpion/53-2519." Planes of Fame Museum. Retrieved: 25 September 2011.
- "F-89 Scorpion/53-2536." EAA AirVenture Museum. Retrieved: 12 January 2015.
- "F-89 Scorpion/53-2610." Eglin Air Force Base. Retrieved: 25 September 2011.
- "F-89 Scorpion/53-2646." aerialvisuals.ca Retrieved: 12 January 2015.
- "F-89 Scorpion/53-2674." Pima Air & Space Museum. Retrieved: 12 January 2015.
- "F-89 Scorpion/53-2677." Minnesota Air Guard Museum. Retrieved: 12 January 2015.
- "F-89 Scorpion/54-0298." aerialvisuals.ca Retrieved: 2 February 2015.
- "F-89 Scorpion/54-0322." Hill Aerospace Museum. Retrieved: 9 October 2012.
- "F-89 Scorpion/52-1856." aerialvisuals.ca Retrieved: 2 February 2015.
- "F-89 Scorpion/52-1896." New England Air Museum. Retrieved: 9 October 2012.
- "F-89 Scorpion/52-1911." National Museum of the USAF. Retrieved: 9 October 2012
- "F-89 Scorpion/52-1927." Castle Air Museum. Retrieved: 12 January 2015.
- "F-89 Scorpion/52-1941." Peterson Air and Space Museum. Retrieved: 12 January 2015.
- "F-89 Scorpion/52-1949." March Field Air Museum. Retrieved: 12 January 2015.
- "F-89 Scorpion/52-2129." Hampton Air Power Park. Retrieved: 25 September 2011.
- "F-89 Scorpion/53-2547." aerialvisuals.ca Retrieved: 12 January 2015.
- "F-89 Scorpion/52-2453." Heritage Flight Museum. Retrieved: 12 January 2015.
- "F-89 Scorpion/53-2604." aerialvisuals.ca Retrieved: 12 January 2015.
- Air International July 1988, p. 49.
- Angelucci, Enzo and Peter Bowers. The American Fighter. Yeovil, UK: Haynes Publishing Group, 1987. ISBN 0-85429-635-2.
- Blazer, Gerald and Mike Dario. Northrop F-89 Scorpion. Leicester, UK; Aerofax, 1993. ISBN 0-942548-45-0.
- Davis, Larry and Dave Menard. F-89 Scorpion in Action (Aircraft Number 104). Carrollton, Texas: Squadron/Signal Publications, 1990. ISBN 0-89747-246-2.
- Green, William and Gordon Swanborough. The Complete Book of Fighters: An Illustrated Encyclopedia of Every Fighter Aircraft Built and Flown. London: Salamander Books, 1994. ISBN 1-85833-777-1.
- Isham, Marty J. and David R. McLaren. Northrop F-89 Scorpion: A Photo Chronicle. Atglen, Pennsylvania: Schiffer Military History, 1996. ISBN 0-7643-0065-2.
- Jenkins, Dennis R. and Tony R. Landis. Experimental & Prototype U.S. Air Force Jet Fighters. North Branch, Minnesota: Specialty Press, 2008. ISBN 978-1-58007-111-6.
- Kinsey, Bert. F-89 Scorpion, (Detail and Scale Vol. 41). Waukesha, Wisconsin: Kalmbach Publishing, 1992. ISBN 1-85310-630-5.
- Knaack, Marcelle Size. Encyclopedia of US Air Force Aircraft and Missile Systems, Volume 1, Post-World War Two Fighters, 1945–1973. Washington, D.C.: Office of Air Force History, 1978. ISBN 0-912799-59-5.
- "Scorpion with a Nuclear Sting: Northrop F-89". Air International, Vol. 35, No. 1, July 1988, pp. 44–50. Bromley, UK: Fine Scroll. ISSN 0306-5634.
- "Scorpion with a Nuclear Sting: Northrop F-89—Part Two". Air International, Vol. 35, No. 2, August 1988, pp. 86–92. Bromley, UK: Fine Scroll. ISSN 0306-5634.
- Swanborough, F. Gordon and Peter M. Bowers. United States Military Aircraft Since 1909. London: Putnam, 1963. ISBN 0-87474-880-1.
|Wikimedia Commons has media related to F-89 Scorpion.|