|Place of origin||United States|
|Manufacturer||Aeronutronic, Martin Marietta|
|Unit cost||from $1938 to $4052|
|Produced||88,194 from 1964 to 1971|
|Weight||MGM-51A : 59.1 lb (26.8 kg)
MGM-51B/C:61.3 lb (27.8 kg)
|Length||MGM-51A : 3 feet 7.7 inches (1.110 m)
MGM-51B/C: 3 feet 9.4 inches (1.153 m)
|Diameter||6 inches (150 mm)|
15 pounds (6.8 kg) Shaped Charge Warhead including 8 pounds (3.6 kg) of Octol Explosivesable to defeat 15.5 inches (390 mm) of RHA at 0° obliquity
|detonated on impact|
|Engine||Amoco Chemicals Hercules solid-fuel rocket|
|Wingspan||11.5 inches (290 mm)|
|MGM-51A :6,600 ft (2,000 m)
MGM-51B/C :10,000 ft (3,000 m)
|Speed||1,060 feet per second (320 m/s)|
|Infra-red signal link|
|Tank (M551 Sheridan and M60A2)|
The Ford MGM-51 Shillelagh was an American anti-tank guided missile designed to be launched from a conventional gun (cannon). It was originally intended to be the medium-range portion of a short, medium, and long-range system for armored fighting vehicles in the 1960s and '70s to defeat future armor without an excessively large gun. Developing a system that could fire both shells and missiles reliably proved complex and largely unworkable.
It was originally developed for the experimental but never produced MBT-70 tank and served most notably as a primary weapon of the M551 Sheridan light tank, but the missile system was not issued to units serving in Vietnam and was retired in 1996. It was also used on the M60A2 "Starship" which was phased out by 1981. Ultimately very few of the 88,000 rounds produced were ever fired in combat, and the system has largely been succeeded as a US anti-tank missile by the later BGM-71 TOW wire-guided missile first produced in 1970. As wire guidance and tube launcher has proved to be a simpler, TOW has seen combat fitted to 15,000 ground, light and armored vehicle and helicopter platforms of 40 international armed forces. Main battle tanks of the late 20th and 21st fielded improved conventional 100 to 125 mm guns and ammunition which proved effective against enemy armor threats. While Soviets designers have developed gun launched missiles, the US and NATO were developing guided tank shells.
The name of the system is that of a traditional wooden club from Ireland.
With the rapid increase in armor thickness during World War II, tanks were becoming increasingly able to survive rounds fired from even the largest of World War II-era anti-tank guns. A new generation of guns, notably the British 105 mm Royal Ordnance L7, were able to cope with newer tanks, but it appeared that in another generation the guns needed would be too large to be practical.
To overcome this potential difficulty the US Army began to favor high-explosive antitank (HEAT), or shaped charge rounds in the 1950s. A shaped charge's penetration is not dependent on the speed of the round, allowing rounds to be fired at much lower velocities, and thus from much lighter guns. They also work better at larger diameters, and a large-diameter low-velocity gun makes for an excellent assault gun that can be mounted on light or medium-weight vehicles. However, the low speed of the round makes it hard to aim over longer distances. The US Army sought to overcome this problem by developing guided missiles with shaped charge warheads that were accurate beyond a few hundred yards.
In 1958 the Army thought that existing knowledge was sufficient to begin work on a guided missile with a HEAT warhead, and in June 1959 Sperry and Ford Aeronutronic were asked for designs to fill the shorter range role. Ford won the contract and started work on the XM13. The first test shots were fired in 1960, and limited production started in 1964. The missile was then known as the MGM-51A.
The basic system was quite advanced for its day. The missile body consisted of a long tube with fold-out fins at the extreme rear, which was propelled from the new M81 gun with a small charge strapped on the rear. Once clear of the gun the fins popped open and the engine ignited. In order to keep it from spinning while in the gun due to the rifling, a small "key" fit into a straight groove in the rifled gun. Aiming the missile was simple; the gunner simply kept his gunsight on the target, while electronics in the sighting system tracked the missile optically and sent corrections through an IR link (similar to a TV remote control). In general the gunners were able to achieve excellent hit rates.
Because the system was so advanced, the development of the Shillelagh was fraught with problems. Ford Aeronutronic underestimated the complexity of the task of designing a missile as advanced as this, and there were major problems with the propellant, igniter, tracker and infrared command link of the missile.
The M81/MGM-51 was first installed on the M551 Sheridan. The Sheridan was a light aluminum-armored AFV designed to be air transportable and provide antitank support for airborne forces. In 1966 the US Army began pressing General Westmoreland to field the tank in South Vietnam, but he declined, stating that with no main gun ammunition, the Sheridan was basically nothing more than a $300,000 machine gun platform. In 1968 152mm main gun ammo became available, and the M551 General Sheridan was deployed to South Vietnam for combat operations in January 1969. Shillelagh missiles did not prove to be a problem in the Vietnam War: they were not used.
The Sheridans' 152mm main guns were used in combat operations in Vietnam but proved troublesome. The combustible casings of the 152mm caseless ammunition rounds did not burn completely, requiring a complicated and slow gas-driven scavenging system. They were also liable to detonate if the vehicle was hit. Firing the gun caused such a large recoil as to result in failures in the delicate missile firing electronics on the tank. These problems, in combination with the lack of suitable targets, resulted in the Sheridan's deployment to South Vietnam without the complex missile system.
The Shillelagh was considerably larger than a conventional round, so only a small number could be carried. Typical loads consisted of only 9 missiles and twenty M409 HEAT rounds for short-range use. In addition the missile proved to have a very long minimum range. Due to the layout of the vehicle, the missile did not come into the sight of the gun/tracker system until it was 800 yards (730 m) from the vehicle, at which point it could start to be guided. Because of its maximum range of about 2,200 yards (2,000 m), the system was only effective within a fairly narrow span of combat distances.
While the maximum range of 2,200 yards (2,000 m) was acceptable, the Army thought that it could and should be improved. Ford received a contract to develop a longer range version in 1963, and returned a slightly larger design the next year. Test firing of the new MGM-51B started the next May, and production began in October 1966. Besides the changes to the missile, the gun was modified. In testing it was found that the key slot in the gun led to cracking after firing only a few shells. After further study a version with a shallower slot and new barrel was selected, creating the M81E1/MGM-51C.
The new missile was about 45 inches (1,100 mm) long, about 6 inches (150 mm) in diameter, and weighed 60 pounds (27 kg). It remained in production until 1971, by which time 88,000 had been produced, probably in anticipation of use by main battle tanks (below). Nearly a half dozen missiles were fired at bunkers by Sheridans during Operation Desert Storm (Iraq/Kuwait) in January and February 1991. This was the only time the missile system was fired in combat.
Even with its problems the system had shown that it could be used by an airborne tank to destroy a main battle tank. The question of whether or not it could fill its original role as the main armament of all tanks was still open. The Army had originally started development of a low-profile turret with a short barrel for their existing M60 tanks in the 1960s, but did not place an order for delivery until 1971, when the main problems with the system had been resolved. The Shillelagh-equipped M60s entered service in 1974, but were hampered by reliability problems, and were phased out in 1980. The final revision of the M60A3 used the same gun and turret as the M60A1.
The most ambitious project based on the Shillelagh was the MBT-70, an advanced US-German tank. Design work on the MBT-70 began in 1963. The tank mounted a huge auto-loader turret on top of a very short chassis, so short that there was no room for a driver in the front hull. Instead of being located in the conventional position the driver was seated in the turret with other crew members, in a rotating cupola that kept him facing forward. The gun was a new longer-barreled design, the XM-150, which extended range and performance to the point where it was useful for sabot type rounds as well. However the project dragged on, and in 1969 the estimated unit cost had risen fivefold. Germany pulled out of the project. The Army proposed a "cut-down" version of the system, the XM-803, but Congress cancelled it in November 1971. It initiated and issued funds to the M1 Abrams project the next month. The M1 design incorporated a conventional gun.
The Soviet KBP Instrument Design Bureau developed the somewhat similar AT-11 Sniper missile, launched by a 125 mm gun. It utilizes a laser beam rider guidance system, and a tandem warhead to defeat explosive reactive armour as used on the T-80 and T-90 tanks.
- M551 Armored Reconnaissance/Airborne Assault Vehicle
- Christensen Allan R, et al., TETAM Model Verification Study. Volume II. Modified Representations of Intervisibility
- "Ford MGM-51 Shillelagh". Designation-systems.net. 2002-06-16. Retrieved 2015-11-21.
- R.P.Hunnicutt. Abrams. A History of the American Main Battle Tank, Vol. 2. — Presidio Press, 1990. ISBN 0-89141-388-X
- Cagle, Mary T., History of the TOW Missile System, OCT 1977
- TOW Weapon System Launched, Tracked and Guided with Precision Raytheon
- Technology and the American way of war. Thomas G. Mahnken. Columbia University Press, 2008. ISBN 978-0-231-12336-5
- Starry p. 142
- Starry p. 143
- Starry, Donn A., General. Mounted Combat in Vietnam. Department of the Army, Washington D.C. 1978.