USS Greenling (SSN-614)
|Operators:||United States Navy|
|Preceded by:||Skipjack class|
|Succeeded by:||Sturgeon class|
|Length:||278 ft 5 in (84.86 m)|
|Beam:||31 ft 7 in (9.63 m)|
|Draft:||25 ft 2 in (7.67 m)|
|Range:||Unlimited, except by food supplies|
|Test depth:||1,300 ft (400 m)|
The Permit-class submarine, (known as the Thresher class until the lead boat USS Thresher was lost), was a class of nuclear-powered fast attack submarines (hull classification symbol SSN) in service with the United States Navy from the early 1960s until 1996. They were a significant improvement on the Skipjack class, with greatly improved sonar, diving depth, and silencing. They were the forerunners of all subsequent US Navy SSN designs. They served in the 1960s through middle 1980s, until retired due to age. They were followed by the Sturgeon and Los Angeles classes.
The Thresher class resulted from a study commissioned in 1956 by Chief of Naval Operations (CNO) Admiral Arleigh Burke. In "Project Nobska", the Committee on Undersea Warfare of the United States National Academy of Sciences, collaborating with numerous other agencies, considered the lessons of submarine warfare and anti-submarine warfare learned from various prototypes and experimental platforms.
The new class kept the proven S5W reactor plant from the immediately preceding Skipjacks, but were a radical change in many other ways. The Threshers had the large bow-mounted sonar sphere and angled, amidships torpedo tubes used in the concurrently-built Tullibee. This placed the sonar sphere in the optimum position for detection of targets at long range. Tullibee was an alternate design optimized for anti-submarine warfare, much smaller and slower than the Threshers and with a quiet turbo-electric propulsion system. Although they used the same HY-80 steel (yield strength 80,000 psi (550 MPa)) as the Skipjacks, the Threshers' pressure hulls were made using an improved design that extended test depth to 1,300 ft (400 m). The engineering spaces were also redesigned, with the turbines supported on "rafts" that were suspended from the hull on isolation mounts for acoustic quieting. Drag was reduced, with external fittings kept to a minimum and the sail greatly reduced in size.
The small sail of Thresher (the smallest fitted to an American SSN) compensated for the increased drag of the longer hull, giving Thresher a top speed of 33 knots (61 km/h; 38 mph), the same as the Skipjacks, according to one recollection. However, the small sail had disadvantages as well, including room for only one periscope and a reduced number of electronics masts, less convenient surfaced operation in rough seas, and an increased possibility of "broaching" (inadvertent surfacing) at periscope depth in rough seas.
Only Thresher was fitted with a five-bladed symmetric screw, very similar to the ones originally fitted to the Skipjacks, which allowed her to reach this speed. During trials of the Skipjack class, it was found that the propeller produced noise below cavitation depth. It was determined that the source of this noise, called blade-rate, was the blades of the screw vibrating when they hit the wake of the sail and control surfaces. This produced a noise that could carry for many miles and could be used by an enemy submarine to set up a firing solution because the frequency of blade-rate was directly related to the speed of the submarine (the RPM of the screw). The solution was to either make the screw smaller so it did not hit the wakes of the sail and control surfaces, which would cavitate more easily because of its increased speed, or have a large screw that gently interacted with these areas of disturbed water. The latter solution was chosen for all subsequent American SSNs. Permit and later submarines of this class had seven-bladed skewback screws, which reduced the problem of blade-rate, but reduced the submarines' top speed to 29–28 knots (54–52 km/h; 33–32 mph). Jack was designed with counter-rotating screws, each of which were smaller than the standard seven-bladed screw, as an alternative solution to the blade-rate problem.
The class received mid-life upgrades in the late 1970s and 1980s, including the BQQ-5 sonar suite with a retractable towed array, Mk 117 torpedo fire control equipment, and other electronics upgrades.
The ships had their torpedo tubes moved to the middle of the hull and angled outboard. This made available the required large space in the bow for the BQQ-2 (BQQ-5 as modernized from the late 1970s) sonar sphere, a new and powerful low-frequency detection sensor. Initially armed with Mark 37 torpedoes, by the late 1960s they carried the improved Mark 48 and the nuclear UUM-44 SUBROC short-range anti-submarine missile, replacing up to six Mk 48s. The Threshers were the first class fitted with the Mark 113 fire control system that enabled the use of SUBROC; they were later upgraded with the Mark 117 system. In the late 1970s the UGM-84 Harpoon anti-ship missile was introduced; typically four were carried in place of Mk 48s.
The first submarine commissioned in the class was the ill-fated Thresher, and so the class was known by her name. When Thresher was lost on 10 April 1963, the class took the name of the second ship in the class, Permit. Thresher had numerous advanced design features and embodied the future of US Navy submarine design, and her loss was a serious blow. As a result, the SUBSAFE program was instituted to correct design flaws and introduce strict manufacturing and construction quality control in critical systems. The seawater and main ballast systems of future classes (Sturgeon-class SSNs and Benjamin Franklin-class SSBNs) were redesigned, and some Threshers and other submarines were rebuilt to SUBSAFE standards. SUBSAFE includes specific training of SUBSAFE quality assurance inspectors in the engineering crew, and tracks extremely detailed information about every component of a submarine that is subject to sea pressure. Joints in any equipment carrying seawater must be welded (not brazed), and every hull penetration larger than a specified size can be quickly shut by a remote hydraulic mechanism. The program has been very successful, as no SUBSAFE submarines have been lost as of 2017 (Scorpion was not SUBSAFE).
Flasher, Greenling, and Gato were fitted with a larger sail, to house additional masts, and built ten feet longer than the other units of the class to include more SUBSAFE features, additional reserve buoyancy, more intelligence gathering equipment and improved accommodations. Haddock was completed with the larger sail but the standard 279-foot (85 m) hull. The Sturgeon class was built with the Flasher-type hull as part of their SUBSAFE redesign, along with an even larger sail.
The engine room of Jack was lengthened by 10 feet (3.0 m) to accommodate an experimental direct-drive propulsion system using concentric counter-rotating propellers. Although counter-rotating propellers produced impressive gains in speed on the experimental Albacore, in Jack the results were disappointing because of the difficulty in sealing the shaft. Jack was also used to test polymer ejection that could reduce flow noises that degraded sonar performance.
Ships in class
|Name||Hull number||Builder||Laid Down||Launched||Commissioned||Fate|
|Thresher||SSN-593||Portsmouth Naval Shipyard||28 May 1958||9 July 1960||3 August 1961||Lost with 129 crewmembers and shipyard personnel on 10 April 1963, 200 nautical miles (370 km) east of Cape Cod, Massachusetts, exact cause unknown.|
|Permit||SSN-594||Mare Island Naval Shipyard||16 July 1959||1 July 1962||29 May 1962||Decommissioned 12 June 1991, recycled via the nuclear Ship and Submarine Recycling Program 20 May 1993.|
|Plunger||SSN-595||Mare Island Naval Shipyard||2 March 1960||9 December 1961||21 November 1962||Decommissioned 3 January 1990, recycled via the nuclear Ship and Submarine Recycling Program 8 March 1996.|
|Barb||SSN-596||Ingalls Shipbuilding, Pascagoula, Mississippi||9 November 1959||11 Feb 1962||24 August 1963||Decommissioned 20 December 1989, recycled via the nuclear Ship and Submarine Recycling Program 14 March 1996.|
|Pollack||SSN-603||New York Shipbuilding, Camden, New Jersey||14 March 1960||17 March 1962||26 May 1964||Decommissioned 1 March 1989, recycled via the nuclear Ship and Submarine Recycling Program 17 February 1995.|
|Haddo||SSN-604||New York Shipbuilding, Camden, New Jersey||9 September 1960||18 August 1962||16 December 1964||Decommissioned 12 June 1991, recycled via the nuclear Ship and Submarine Recycling Program 20 June 1992.|
|Jack||SSN-605||Portsmouth Naval Shipyard||16 September 1960||24 April 1963||31 March 1967||Decommissioned 11 July 1990, recycled via the nuclear Ship and Submarine Recycling Program 30 June 1992.|
|Tinosa||SSN-606||Portsmouth Naval Shipyard||24 November 1959||9 December 1961||17 October 1964||Decommissioned 15 January 1992, recycled via the nuclear Ship and Submarine Recycling Program 15 August 1992.|
|Dace||SSN-607||Ingalls Shipbuilding, Pascagoula, Mississippi||6 June 1960||18 August 1962||4 April 1964||Decommissioned 2 December 1988, recycled via the nuclear Ship and Submarine Recycling Program 1 January 1997.|
|Guardfish||SSN-612||New York Shipbuilding, Camden, New Jersey||13 February 1961||15 May 1965||20 December 1966||Decommissioned 2 February 1992, recycled via the nuclear Ship and Submarine Recycling Program 9 July 1992.|
|Flasher||SSN-613||Electric Boat||14 April 1961||22 June 1963||22 July 1966||Decommissioned 26 May 1992, recycled via the nuclear Ship and Submarine Recycling Program 11 May 1994.|
|Greenling||SSN-614||Electric Boat||15 August 1961||4 April 1964||3 November 1967||Decommissioned 18 April 1994, recycled via the nuclear Ship and Submarine Recycling Program 30 September 1994.|
|Gato||SSN-615||Electric Boat||15 December 1961||14 May 1964||25 January 1968||Decommissioned 25 April 1996, recycled via the nuclear Ship and Submarine Recycling Program.|
|Haddock||SSN-621||Ingalls Shipbuilding, Pascagoula, Mississippi||24 April 1961||21 May 1966||22 December 1967||Decommissioned 7 April 1993, recycled via the nuclear Ship and Submarine Recycling Program.|
- Attack submarine
- List of submarines of the United States Navy
- List of submarine classes of the United States Navy
- Friedman, Norman (1994). U.S. Submarines Since 1945: An Illustrated Design History. Annapolis, Maryland: United States Naval Institute. pp. 141–146, 243. ISBN 1-55750-260-9.
- Friedman, pp. 235-236
- Friedman, pp. 136-142, 243
- Polmar, Norman; Moore, K. J. (2004) Cold War Submarines: The Design and Construction of U.S. and Soviet Submarines, Potomac Books, p. 363
- Friedman, pp. 143-146
- War Machines Encyclopedia, Aerospace Publishing Ltd., Italian version printed by De Agostini, pp. 526-527)
- Gardiner, Robert and Chumbley, Stephen, Conway's all the world's fighting ships 1947-1995, London: Conway Maritime Press, 1995. ISBN 1-55750-132-7.
- Karam, P. Andrew and Thompson, Roger, Rig Ship for Ultra Quiet: Life on a nuclear attack boat at the end of the Cold War. Google Books link
- Hutchinson, Robert, Jane's Submarines, War Beneath The Waves, From 1776 To The Present Day, Harper Paperbacks, 2005. ISBN 0-06081-900-6.
- Polmar, Norman (2004). Cold War Submarines: The Design and Construction of U.S. and Soviet Submarines, 1945-2001. Dulles: Brassey's. ISBN 978-1-57488-594-1.
|Wikimedia Commons has media related to Thresher/Permit class submarines.|