7.62×39mm

7.62x39
File:Yugo 7.62x39 M67.jpg Yugoslavian version of the 7.62x39 cartridge, named M67. It has a flat based fully lead core projectile.
Type	Rifle cartridge
Place of origin	Soviet Union
Service history
In service	World War II to present
Used by	Soviet, Russian forces
Wars	World War II, Afghanistan and later wars
Production history
Designed	World War II
Produced	World War II to present
Specifications
Case type	Rimless, necked
Bullet diameter	7.90 mm (0.311 in)
Neck diameter	8.64 mm (0.340 in)
Shoulder diameter	10.01 mm (0.394 in)
Base diameter	11.25 mm (0.443 in)
Rim diameter	11.30 mm (0.445 in)
Case length	38.65 mm (1.522 in)
Overall length	55.80 mm (2.197 in)
Primer type	Berdan
Filling	SSNF 50 powder
Filling weight	24.7 gr
Ballistic performance
Bullet mass/type Velocity Energy 123 gr (8 g) Spitzer 710 m/s (2,300 ft/s) 2,010 J (1,480 ft⋅lbf)
Source(s): 7.62x39 Data at ChuckHawks.com

The Soviet 7.62x39mm rifle cartridge was designed during World War II and first used in the SKS carbine. The cartridge was likely influenced by a variety of foreign developments, especially the pre-war German GeCo 7.75x39mm experimental round[1], and possibly by the late-war German 7.92 mm Kurz ("Kurz" meaning "short" in German). Shortly after the war the world's most recognized assault rifle was designed for this cartridge: the AK-47. The cartridge remained the standard Soviet load until the 1970s, and is still by far the most common intermediate rifle cartridge used around the world. Its replacement, the 5.45×39 mm cartridge, is slightly less powerful but longer ranged (due to its much higher velocity) and is more controllable in fully automatic fire (due to the lower recoil). The change was in part a response to NATO switching from the 7.62x51mm cartridge to 5.56x45mm NATO.

The original Soviet bullets are boat-tail bullets with a copper-plated steel jacket, a large steel core, and some lead between the core and the jacket. The cartridge itself consists of a berdan-primed, tapered (usually steel) case which seats the bullet and contains the powder charge. The taper makes it very easy to feed and extract the round, since there is little contact with the chamber walls until the round is fully seated. This taper is what causes the AK-47 to have distinctively curved magazines. While the bullet design itself has gone through a few redesigns, the cartridge itself remains largely unchanged.

7.62x39 ammunition has typically been inexpensive, one of the least-expensive centerfire rifle ammunition on the market at just over 10 cents a round for high-quality imported Russian brands and now 17 cents a round for quality imported ammo after a sharp price rise on mil-spec ammo in this caliber in early 2006. It is cheaper than most handgun rounds and even some expensive target .22 rimfire ammunition. However, in 2005/2006, prices began to soar (almost doubling in the US) due to the United States placing a massive order to supply the fledgling Afghan and Iraqi armies. Even so, as of Jan. 2007, it remains one of the least-expensive centerfire rifle ammo on the market. This cartridge has endeared itself to shooters in spite of its limited ballistics, which are analogous to the .30-30, because of the many inexpensive good semiautomatic rifles available for it, the availability of inexpensive ammunition, and because of its minimal recoil.

M43

Although the new cartridge represented a great leap forward from previous designs, the initial bullet design was flawed. The complete solidity of the M43 projectile causes its only drawback—it is stable even in tissue and begins to yaw only after traversing nearly 30cm of tissue. This greatly reduces the wounding effectiveness of the projectile against humans. Dr. Martin Fackler noted that the wounds from the M43 round were comparable to that of a small handgun round using non-expanding bullets. Unless the round struck something vital, the wound was usually small and healed quickly.

M67

In the 1960s the Yugoslavians experimented with new bullet designs to produce a round with a superior wounding profile to the M43. The M67 projectile is shorter and flatter-based than the M43. This is mainly due to the deletion of the mild steel insert. This has the side effect of shifting the center of gravity rearward in comparison to the M43. This allows the projectile to destabilize nearly 17cm earlier in tissue. This causes a pair of large stretch cavities at a depth likely to cause effective wound trauma. When the temporary stretch cavity intersects with the skin at the exit area, a larger exit wound will result, which takes longer to heal. Additionally, when the stretch cavity intersects a stiff organ like the liver, it will cause damage to that organ.

However, without fragmentation, the wounding potential of M67 is mostly limited to the small permanent wound channel the bullet itself makes. While a fragmenting round (like the 5.56x45 mm) might cause massive tissue trauma and blood loss (and thus rapid incapacitation) on a lung or abdominal hit, the M67 has a greater chance of merely wounding the target.

Chinese steel core

Chinese military-issue ammunition in this caliber is M43 style with a mild steel core and a thin jacket of copper or brass. Contrary to common belief, the use of steel was a cost saving measure rather than one to increase the penetration. Additionally, mild steel is not sufficiently hard to grant unusual armor penetrating capability. Despite this, Chinese ammunition is currently banned from importation in the US due to the fact that there are 7.62x39mm caliber handguns and the ammunition is an armor-piercing handgun round under the U.S. federal legal definition of the word, which is based on materials and bullet design rather than on tested ability to penetrate armor.

Other names for 7.62x39

On some occasions, this ammunition is referred to as 7.62mm Soviet, 7.62mm Warsaw Pact rounds, or 7.62mm ComBloc. It was also known in the United States as .30 Short Russian; the "Short" was to distinguish it from the older .30 Russian, which was the 7.62x54R. (Note that the "R" in 7.62x54R does not stand for "Russian", but "Rimmed")

Hunting

Since approximately 1990 the 7.62x39mm cartridge has seen some use in hunting arms in the US for hunting game up to the size of whitetail deer, as it is approximately as powerful as the old .30-30 Winchester round, and has a similar ballistic profile. Large numbers of inexpensive imported semiautomatic rifles, like the SKS and semi-auto AK-47 clones and variants, are available in this caliber, and the SKS is so inexpensive as to have begun displacing the .30-30 lever-action rifles as the new "poor man's deer rifle" by being less expensive than the .30-30 Marlins and Winchesters that long held that role. Inexpensive imported 7.62x39mm ammunition is also widely available, though much of it is of the non-expanding type that may be illegal to use for hunting in some US states. However, both imported Russian ammunition like Wolf brand and American civilian manufacturers produce both hollow-point and soft-point rounds, which are suitable and legal for hunting.

See also

• List of rifle cartridges
• 7.62 mm caliber

External links

• Various photos of 7.62 x 39mm ammunition
• Wolf Ammunition catalog of rifle cartridges
• Current 7.62x39 prices
• .30 Caliber cartridge article at Chuck Hawks