Basic lead carbonate
|Molar mass||775.633 g/mol|
|Main hazards||Lead poisoning|
Except where otherwise noted, data are given for materials in their standard state (at 25 °C [77 °F], 100 kPa).
|what is ?)(|
White lead is the basic lead carbonate, 2PbCO3·Pb(OH)2. It is a complex salt, containing both carbonate and hydroxide ions. White lead occurs naturally as a mineral, in which context it is known as hydrocerussite, a hydrate of cerussite. It was formerly used as an ingredient for lead paint and a cosmetic called Venetian Ceruse, because of its opacity and the satiny smooth mixture it made with dryable oils. However, it tended to cause lead poisoning, and its use has been banned in most countries.
What is commonly known today as the "Dutch method" for the preparation of white lead was described as early as Theophrastus of Eresos (ca. 300 BC), in his brief work on rocks or minerals, On Stones or History of Stones. His directions for the process were repeated throughout history by many authors of chemical and alchemical literature. The uses of cerussa were described as an external medication and pigment.
Clifford Dyer Holley quotes from Theophrastus' History of Stones as follows, in his book The Lead and Zinc Pigments.
Lead is placed in earthen vessels over sharp vinegar, and after it has acquired some thickness of a sort of rust, which it commonly does in about ten days, they open the vessels and scrape it off, as it were, in a sort of foulness; they then place the lead over vinegar again, repeating over and over again the same method of scraping it till it has wholly dissolved. What has been scraped off they then beat to powder and boil for a long time, and what at last subsides to the bottom of the vessel is ceruse.
Later descriptions of the Dutch process involved casting metallic lead as thin buckles and corroded with acetic acid in the presence of carbon dioxide. This was done by placing them over pots with a little vinegar (which contains acetic acid). These were stacked up and covered with a mixture of decaying dung and spent tanner's bark, which supplied the CO2, and left for six to fourteen weeks, by which time the blue-grey lead had corroded to white lead. The pots were then taken to a separating table where scraping and pounding removed the white lead from the buckles. The powder was then dried and packed for shipment or shipped as a paste. One benefit of the process was that it was not necessary to dry the paste of white lead, removing its water. All that needed was to mill the paste with linseed oil, and the white lead would take up the oil and reject the residual water, to give white lead in oil.
White lead has been the principal white pigment of classical European oil painting. There have been claims that it is partly responsible for darkening of old paintings over time, reacting with trace amounts of hydrogen sulfide in the air to produce black lead sulfide. Other authorities dispute this; the most traditional view is that impermanent pigments and dirty varnish (which is often cleanable) are more likely responsible for darkening.
Paintings and the role of varnish, which might protect the white lead yet itself darken, aside—according to Michelle Facini, a paper conservator at the National Gallery of Art, lead carbonate to lead sulfide is indeed what happens to some lead chalks/paints in drawings and watercolors and other works done on paper and unvarnished. Varnish is meant to be removable from an oil painting, to strip off when it dirties or cracks; but on paper it soaks through and becomes inseparable from the paper fibers, ruinous as it ages. This is why works on paper are never, or should never, be varnished.
In any event, white lead has been mostly supplanted in artistic use by titanium white, which has much higher tinting strength than white lead. Critics argue that many of these substitutes are much less permanent. White lead is less used by today's painters, not because of its toxicity directly; but simply because its toxicity in other contexts has led to trade restrictions that make white lead difficult for artists to obtain in sufficient quantities. Winsor & Newton, the English paint company, was restricted in 2014 from selling its flake white in tubes and now must sell exclusively in 150 mL tins.
Other synonyms (as an art pigment)
Among the synonyms for white lead are Berlin white, Cremnitz white, Dutch white lead, flake white, Flemish white, Krems white, London white, Pigment White 1, Roman white, silver white, slate white, Vienna white, and white lead.
- Inorganic Chemistry,Egon Wiberg, Arnold Frederick Holleman Elsevier 2001 ISBN 0-12-352651-5
- see mineral hydration
- Hernberg, Sven (September 2000). "Lead Poisoning in a Historical Perspective" (PDF). American Journal of Industrial Medicine. 38 (3): 244–254. CiteSeerX 10.1.1.477.2081. doi:10.1002/1097-0274(200009)38:3<244::AID-AJIM3>3.0.CO;2-F. PMID 10940962.
- Klemgard, E.N. (1937). "Lead base greases". Lubricating Greases Their Manufacture And Use. Reinhold Publishing Corporation. p. 677.
- J. R. Partington, A Short History of Chemistry (1937)
- Stillman, John Maxson (1924). The Story of Early Chemistry. D. Appleton. pp. 19–20.
- Theophrastus, History of Stones, p.223
- Holley, Clifford Dyer (1909). The Lead and Zinc Pigments. John Wiley & Sons. p. 2.
- Lead411.org based on Warren, Christian. 'Toxic Purity: The progressive era origins of America’s lead paint poisoning epidemic'. Business History Review. Winter 1999, Vol. 73(4)
- "Stack Process White Lead (Old Dutch Method)". Commercial supplier, offering original pigments to the conservation and reproduction markets
- Laver, M. Titanium Dioxide Whites, in Fitzhugh, E.W. (Ed), Artists' Pigments, Vol 3, Oxford university Press, 1997, p. 309
- "Zinc White Problems in Oil Paint". The Smithsonian's Museum Conservation Institute exposes long-term problems with zinc white
- "Choosing a white in oil colour". winsornewton.com. Retrieved 18 October 2014.
For reasons of toxicity these Lead White colours are only available in tins in the EU.
- Hough, Richard (1994). Captain James Cook. Hodder and Stoughton. p. 56. ISBN 978-0-340-82556-3.
- "Lead white". Conservation and Art Materials Encyclopedia Online (CAMEO). Museum of Fine Arts, Boston (Massachusetts). Retrieved 6 June 2019.
- Gettens, R.J., Kühn, H. and Chase, W.T. Lead White, in Roy, A., (Ed), Artists' Pigments, Vol 2, Oxford University Press, 1993, pp. 67–81
|Wikisource has the text of The New Student's Reference Work article "White Lead".|
- Lead white, Colourlex