Mikoyan-Gurevich Ye-150 family
|Role||Prototype single-seat fighter|
|National origin||Soviet Union|
|First flight||Ye-152A – 10 July 1959, Ye-150 - 8 July 1960, Ye-152 – 21 April 1961|
|Number built||1x Ye-150, 2x Ye-152, 1x Ye-152A|
|Developed from||Mikoyan-Gurevich I-75|
Design and development
To fulfil the needs of the PVO (Protivovozdushnaya Oborona – air defence forces) for a heavy interceptor to carry out automatic interceptions, the MiG bureau had developed a range of large fighter aircraft starting with the swept wing I-3 series (a.k.a. I-380, I-410 and I-420), followed by the I-7 and the I-75. The requirement for supersonic interception speed and the ability to carry the heavy avionic systems dictated the size; in comparison the contemporary MiG-21F (similar in layout), weighed 4,819 kg (10,624 lb) and was 15.76m (51 ft 8-1/2in) long, compared with 12,345 kg (27,215 lb) and 18.14m (59 ft 6in) respectively, for the Ye-150.
The MAP (Ministerstvo Aviatsionnoy Promyshlennosti - ministry of aviation industry) ordered the Mikoyan OKB to build prototypes of the new interceptor, to be armed with either K-6, K-7, K-8, K-9, unguided rockets, or an aimable twin cannon installation. Automatic guidance to the interception point was to be provided by Urugan-5 (hurricane-5) integrated weapons systems.
The initial missile armed version, designated Ye-150, flew for the first time on 8 July 1960, after extensive ground checks of systems and a delay in delivery of a flightworthy engine. Flight tests progressed slowly, hampered by the very short life of the R-15 engine, (barely sufficient for pre-flight ground checks and a single flight), as well as problems with aileron buffeting, brake parachute failure and the engine accessory gearbox disintegrating. Manufacturers flight tests, over 42 flights, revealed very high rates of climb, impressive maximum speed (M2.65 @ 19,100m (62,664 ft) using less than full throttle), and a phenomenal service ceiling of at least 21,000m (68,900 ft).
Installation of weapons systems was not carried out on the Ye-150 and it was not authorised for production, but development continued with the Ye-151, and Ye-152.
The Ye-151 cannon armed version was designed in parallel with the Ye-150 but did not proceed to the hardware stage. The weapon system was to have consisted of twin TKB-495 or Makarov TKB-539 cannon, with a rate of fire of 2,000 rds/min, mounted on a rotating ring in tilting mounts. The mounts could tilt ±30° and the mounting ring could rotate 360°, which gave the installation a 60° cone of fire around the centreline of the mounting ring. To accommodate the ring turret the inlet duct was lengthened with the rotating ring forming the inlet lip, wind tunnel testing confirming that the extended inlet duct would actually improve aerodynamic and inlet performance; the lengthened inlet was retained for all later Ye-150 series aircraft (sans cannon installation). Further tunnel testing with an inlet mounting fitted with cannon revealed de-stabilising forces when the cannon were deflected, making accurate weapon aiming impossible and precluding further development. Studies were carried out with the cannon mount aft of the cockpit to reduce de-stabilising moment, as the Ye-151-2, but no hardware resulted.
The two single engined Ye-152's were completed with improved R-15-300 engines, as the Ye-152-1 and Ye-152-2, but reliability remained an issue, with only limited development flying, weapons system testing and world record flights carried out. The poor reliability of the engine and the cancellation of the intended K-9 / Urugan-5B weapon system brought the Ye-152 program to a close. Cropped delta wings with greater area allowed the large K-80 or K-9 missiles to be carried on wingtip launchers.
The second aircraft, Ye-152-2, was returned to Mikoyan for conversion to the Ye-152M, featuring an axi-symmetric convergent divergent nozzle and canards on either side of the forward fuselage, which were soon removed. The Ye-152M was retired to the Central Air Force Museum at Monino misleadingly marked as the Ye-166 which was, in fact, the unmodified Ye-152-1.
The Mikoyan-Gurevich Ye-152A was a twin-engined version of the Ye-152, sharing its general layout but utilising two Tumansky R-11 afterburning turbojets mounted side by side in a revised rear fuselage. The change in engine type, necessitated by the extremely poor reliability of the R-15, led to a widened rear fuselage with large ventral fins. The majority of the airframe was identical to the Ye-152, incorporating the extended inlet and fuselage found to be advantageous during testing for the proposed Ye-151 cannon armed variant of the Ye-150. Due to the use of fully developed and reliable R-11 engines the Ye-152A was ready for flight in July 1959 and continued to fly on test duties at the Mikoyan-Gurevich test centre until it crashed in 1965.
The Ye-152-2 was returned to the Mikoyan factory for conversion to the Ye-152M, fitted with small canard surfaces either side of the forward fuselage and an R-15-300 engine fitted with axi-symmetric convergent-divergent nozzle, allowing the ejector ring around the rear fuselage to be dispensed with. After initial flight testing the canards were removed leaving the mounting structures behind. Used for further testing of the R-15 engine and Urugan weapon systems, the Ye-152M was retired to the Central Air Force Museum at Monino bearing the erroneous identity Ye-166 and three red stars to signify the world records set by its sister ship, the Ye-152-1.
Fictitious designation of the Ye-152-1 used when registering the world records with the Federation Aeronautique Internationale (FAI). Also applied to the Ye-152M displayed at Monino as an intelligence ruse.
An erroneous designation applied by western intelligence observers to the Ye-152A after the display at Tushino in 1961.
Development of the Uragan-5 automatic weapon system was initiated by the Council of Ministers in 1955 to intercept supersonic bombers flying at 10-25,000m ( ft) altitude at 1600–2000 km/hour up to 100–120 km range from the interceptor base, (with sufficient warning). The system relied on ground based radar to guide the interceptor to an intercept with the target and aircraft based radar and weapon aiming systems to complete the mission using the following components:
- A high resolution ground based radar system, to provide accurate position and height data at a range of 345 km.
- Active interrogation system (SAZO)
- Automatic guidance facility
- Digital control computer
- Command data link (SPK)
- Interceptor-fighter with Airborne radar (detection range of 25 km minimum), Autopilot, and Weapon-aiming computer (SRP)
- Mikoyan-Gurevich Ye-150
- Mikoyan-Gurevich Ye-151
- Mikoyan-Gurevich Ye-152
- Mikoyan-Gurevich Ye-152A
- Mikoyan-Gurevich Ye-150P
- Mikoyan-Gurevich Ye-150M
Armament options included:
- 2 x 30mm cannon in a tilting rotatable mount.
- Unguided rockets.
- 2x Grushin K-6 air-to-air missiles
- 2x Toropov K-7 air-to-air missiles
- 2x Kaliningrad K-8 (R-8) air-to-air missiles
- 2x Raduga K-9 air-to-air missiles
A combination of delays in development of the electronic components, missiles and poor reliability of the Tumansky R-15 engines for the aircraft component led to the Uragan-5 system, fitted to Ye-150 derivatives being cancelled in 1962.
Data from Gordon
- Length: 19.656 m (64 ft 6 in)
- Wingspan: 8.793 m (28 ft 10 in)
- Wing area: 40.02 m2 (430.8 sq ft)
- Empty weight: 10,900 kg (24,030 lb) 10900
- Max takeoff weight: 14,350 kg (31,636 lb)
- Powerplant: 1 × Tumansky R-15-300 turbojet, 66.7 kN (15,000 lbf) thrust dry, 99.6 kN (22,400 lbf) with afterburner
- Maximum speed: 3,030 km/h (1,883 mph; 1,636 kn) @ 15400m (50,520ft) mach 2.8+
- Range: 1,470 km (913 mi; 794 nmi)
- Service ceiling: 22,680 m (74,410 ft)
- Rate of climb: 62.5 m/s (12,300 ft/min) 5.33min to 20000m (65620ft)
- Time to altitude: 4.5min to 20000m (65620ft)
- Guns: (Ye-151) 2x TKB-495 or TKB-539 cannon in an aimable mount
- Missiles: (proposed) 2xK-7 or 2xK-6 or 2xK-9 air-to-air missiles
- Uragan-5 Weapons control system
- Aircraft of comparable role, configuration and era
- Gordon, Yefim. Soviet Heavy Interceptors”. Hinkley, Midland. 2004. ISBN 1-85780-191-1
- Williams, Anthony G. & Gustin, Emmanuel. Flying Guns - The Modern Era. London. Crowood Press. 2004. ISBN 1-86126-655-3
- "Soviet X-Planes", Yefim Gordon and Bill Gunston, 2000. Page 106.
- Nemecek, Vaclav (1986). The History of Soviet Aircraft from 1918. London: Willow Books. ISBN 0-00-218033-2.
- Gunston, Bill. The Osprey Encyclopaedia of Russian Aircraft 1875–1995. London, Osprey. 1995. ISBN 1-85532-405-9
- Gordon, Yefim. Soviet/Russian Aircraft Weapons. Midland. 2004. ISBN 1-85780-188-1
- Gordon, Yefim. & Gunston, Bill SovietX-Planes”. Hinkley, Midland. 2000. ISBN 1-85780-099-0
- Gordon, Yefim & Komissarov, Dmitry. OKB Mikoyan”. Hinkley, Midland. 2009. ISBN 1-85780-307-8
|Wikimedia Commons has media related to Mikoyan-Gurevich Ye-166.|
- http://www.ctrl-c.liu.se/misc/ram/ye-152.html Russian Aviation Museum
- http://wp.scn.ru/en/ww3/s/709/1/0/3 WINGS PALETTE