Jump to content

Waco Custom Cabin series

From Wikipedia, the free encyclopedia

This is an old revision of this page, as edited by NiD.29 (talk | contribs) at 18:20, 13 April 2016 (ditto). The present address (URL) is a permanent link to this revision, which may differ significantly from the current revision.

Waco Custom Cabin series
Waco EQC-6 marked as Grant McConachie's aircraft
Role Four to five place cabin sesquiplane
Manufacturer Waco Aircraft Company
First flight 1935
Introduction 1935
Produced 1935-1939
Number built 350+
Variants Waco ZQC-6, Waco E series, Waco N series

The Waco Custom Cabins were a series of up-market single-engined four-to-five-seat cabin sesquiplanes of the late 1930s produced by the Waco Aircraft Company of the United States. "Custom Cabin" was Waco's own description of the aircraft which despite minor differences, were all fabric-covered biplanes.

Design

Nearly all of the Waco Custom Cabins were powered by radial engines (there being one factory-built exception, the MGC-8) and the purchaser could specify almost any commercially available engine and Waco would build an aircraft powered by it, hence the profusion of designations, as the first letter indicates the engine installed. Some models were offered in case someone wanted a specific engine but not all were built. Fuselage structure was typical for the period, being welded steel tubing with light wood strips to fair the shape in. The wings were made of spruce with two spars each, having ailerons on only the upper wings, mounted on a false spar. Split flaps were installed on the undersides of the upper wings, though two designs were used depending on model - placed either mid-chord (OC, UC and QC), or in the conventional position at the trailing edge of the wing (GC and N). The model N was unusual in being the only model with flaps on the lower wings while the model E was the only one with plain flaps. Wing bracing was with a heavily canted N strut joining upper and lower wings, assisted by a single strut bracing the lower wing to the upper fuselage longeron, except on the E series which replaced the single strut with flying and landing wires. Elevators and rudder were aerodynamically counterbalanced and braced with wire cables. Both could be trimmed, the rudder via a ground-adjustable tab, the elevators via jack screw on the OC, UC and QC, while the GC, E and N used a single trim tab on the port (left) elevator. The main landing gear was sprung with oleo struts, and a castoring tailwheel was fitted on all versions except the VN model, which had a nosewheel.

Designation clarification

Waco had been building a series of successful cabin biplanes, when in 1935 they introduced a new series of upmarket cabin sesquiplanes intended for the wealthy private individual or business. The original biplanes had been given a designation ending in C, however with the new Custom Cabin, Waco decided to differentiate the new design and existing C types that remained in production were recoded as C-S types to indicate Standard Cabin, until Waco changed their designation again in 1936 to just an S.[1] For example, the 1934 Standard Cabin YKC was redesignated as a YKC-S in 1935, and as a YKS-6 in 1936.[1] 1936 also saw the adoption of a numerical suffix to indicate the model year of the design, as "-6" for 1936, "-7" for 1937, etc. Since it referred to a model and not the year of production, the "-7" was carried into 1939 for some Custom Cabins, while others were designated "-8".[2] In 1936, Waco started using a short form to refer to the types of aircraft without the engine and model identifiers resulting in C-6, C-7 and C-8 however as Waco only built one type of Custom cabin in each of those years, they refer to the QC-6, GC-7 and GC-8 series respectively.[3]

Operational history

The Custom Cabin series, with its improved performance proved to be popular and many were purchased by small commercial aviation firms and non-aviation businesses. Approximately 300 Custom Cabin Wacos of all types (excluding the Waco E series and the Waco N series), were produced between 1935 and 1939. Some were employed as "executive transports". Many served in the Canadian bush country, where they normally operated on skis in winter and EDO floats in summer. Many of these Canadian Wacos were ordered and built as freighters with additional doors. In 1936 an EQC-6 operated by Speers Airways of Regina, Saskatchewan was the first non-military government operated air ambulance in Canada.[4] With the onset of World War II, examples were impressed into the air forces of many Allied nations, including the US (USAAC and US Navy), the United Kingdom, South Africa, Australia and New Zealand. Most were used as utility aircraft, however a small number were operated by the US Civil Air Patrol, conducting anti-submarine patrols off the US coastline from March 1942 to August 1943 armed with 50 or 100 pound bombs.[5] A single impressed ZGC-7 referred to as the Big Waco, RAF serial AX695, was used by the British Long Range Desert Group (LRDG) along with a Standard Cabin YKC named Little Waco to support their activities behind Axis lines.[6] Flight Regiment 19, Finnish Air Force (Swedish Volunteer Air Force) used one Waco ZQC-6 (OH-SLA) during the Russo-Finnish Winter War in support of Finnish military operations. Numerous Custom Cabin series aircraft of several sub-models are currently registered in the USA, and more are in under restoration. This is still a popular design among owners of classic aircraft.

Variants

Waco YOC at Virginia Aviation Museum. This aircraft was once owned by Hollywood artist Walter Matthew Jeffries who was responsible for the design of the original Starship Enterprise.

The Waco Custom cabin series included all of the enlarged-cabin sesquiplanes from 1935 and can be further divided into six basic models, OC, UC QC, GC, RE and VN, with additional subtypes differing primarily in engine installation (indicated by the first letter of the designation or by a low dash number, i.e. -1, -2) and by model year (dash numbers -6, -7, -8). Letters were not used sequentially. Each basic type was offered with almost any engine the customer wished and designations were created accordingly, however some engines were more popular than others resulting in some types being offered, but never built. Due to the wide variety of engines already offered, it was both relatively easy and common to change the installed engine, resulting in a lot of confusion as to the correct designation to use for a specific airframe.

The RE series is more refined aerodynamically than earlier models; the wings are fully plywood-skinned, and instead of a bulky compression strut carrying lift loads, a more conventional set of streamlined flying wires completes the wing structure. It has the fastest cruise speed of any of the Waco cabin models, with a Vne of 270 mph.

1935 OC Series (54+ built)

UOC
210 hp (157 kW) Continental R-670-A or 225 hp (168 kW) Continental R-670-B engine. four built.
1935 Waco YOC
YOC
225 hp (168 kW) Jacobs L-4 engine. 50+ YOC and YOC-1 built. Built as UOC and re-engined.
YOC-1
285 hp (213 kW) Jacobs L-5 engine. Built as UOC and re-engined. One impressed by USAAF as UC-72N.
Waco CUC of 1935. Anoka-Blaine airport near Minneapolis, June 2006

1935 UC Series (30+ built)

CUC
250 hp (186 kW) Wright R-760-E engine. 30+ built of all CUC types.
CUC-1
285 hp (213 kW) Wright R-760-E1 engine. Built as CUC and re-engined. One impressed by USAAF as UC-72F.
CUC-2
320 hp (239 kW) Wright R-760-E2 engine. Built as CUC and re-engined.
A Waco ZQC-6

1936 QC Series (C-6) (120 built)

AQC-6
330 hp (246 kW) Jacobs L-6 engine. Seven built. One impressed by USAAF as UC-72G.
AQC-6 Freighter: At least two aircraft ordered through Fleet Aircraft and built for use in Canada with additional freight doors on both sides of the fuselage and equipped for floats. Engine same as for standard AQC-6. Additional aircraft may have been modified.[7]
CQC-6
250 hp (186 kW) Wright R-760-E engine. None built.
DQC-6
285 hp (213 kW) Wright R-760-E1 engine. 11 built.
EQC-6
320 hp (239 kW) Wright R-760-E2 engine. 20 built. USCG used three as J2W-1[8]
SQC-6
300 hp (224 kW) Pratt & Whitney Wasp Jr. engine. None built.
UQC-6
210 hp (157 kW) Continental R-670 or 225 hp (168 kW);hp Continental W-670-K or 220 hp (164 kW);hp Continental W-670-6. None built.
VQC-6
250 hp (186 kW) Continental W-670-M1 engine. One built.
YQC-6
225 hp (168 kW) Jacobs L-4 engine. 13 built. One ex-RAAF example re-engined with 200 hp (149 kW);hp DeHavilland Gypsy 6 inline engine.
ZQC-6
285 hp (213 kW) Jacobs L-5 engine. 68 built. One impressed by the USAAF as UC-72Q and five as UC-72H.;[9] Swedish AF Tp-8a
ZQC-6 Freighter: At least eight aircraft ordered through Fleet Aircraft and built for use in Canada with additional freight doors on both sides of the fuselage and equipped for floats. Engine same as for standard ZQC-6. Additional aircraft may have been modified.[7]

1937-38 GC Series (C-7 and C-8) (96+ built)

WACO AGC-8
AGC-8
300 hp (224 kW) Jacobs L-6 engine. 17 built, two modified to EGC-8. Two impressed by USAAF as UC-72P.
DGC-7
285 hp (213 kW) Wright R-760-E1 engine. Two built.
EGC-7
320 hp (239 kW) Wright R-760-E2 engine. 38 built.
EGC-8
same as EGC-7 for 1938. Seven built, plus two modified from AGC-8, and one used to trial 260 hp (194 kW) Menasco C-6S-4 for MGC-8. Four impressed by USAAF as UC-72B
MGC-8
Menasco Buccaneer inline engine. One modified, unknown number built.
UGC-7
210 hp (157 kW) Continental R-670 engine. None built.
VGC-7
250 hp (186 kW) Continental W-670-M1 engine. None built.
YGC-7
225 hp (168 kW) Jacobs L-4 engine. None built.
YGC-8
225 hp (168 kW) Jacobs L-4 engine. Trailling edge flaps. None built.
ZGC-7
300 hp (224 kW) Jacobs L-5 engine. 28 built. Four impressed by USAAF as UC-72E
ZGC-8
same as ZGC-7 for 1938, four built.
Waco AVN-8 at the Historic Aircraft Restoration Museum.

1938 VN Series (N-8) (20 ca. built)

Main article: Waco N series
AVN-8
330 hp (246 kW) Jacobs L-6 engine.
ZVN-8
285 hp (213 kW) Jacobs L-5 engine.
EAA AirVenture Museum's Waco ARE originally modified for the New York Daily News for aerial photography, with enlarged windows.

1939 RE Series (30 built)

Main article: Waco E series
ARE Aristocrat
330 hp (246 kW) Jacobs L-6 (four built, one impressed by USAAF as UC-72A)
HRE Aristocrat
300 hp (224 kW) Lycoming R-680-E3 (five built, two impressed by USAAF as UC-72C)
SRE Aristocrat
450 hp (336 kW) Pratt & Whitney Wasp Jr SB-2/-3 (21 built, 13 impressed by USAAF as UC-72)
WRE Aristocrat
450 hp (336 kW) Wright R-975 - none built

Military Designations

A-54
Royal Australian Air Force designation for impressed YQC-6[10]
Tp-8a
Swedish Air Force designation for ZQC-6. Tp-8 was a generic designation for all Wacos.[11]
J2W
US Coast Guard designation for three EQC-6 bought from Waco. Additional aircraft impressed by the US Navy were undesignated.[8]
UC-72/C-72
US Army Air Forces designation for impressed Custom Cabin series Wacos.[9]
Main article: Waco C-72
UC-72B   :   EGC-8   four impressed
UC-72E   :   ZGC-7   four impressed
UC-72P   :   AGC-8   two impressed
UC-72Q   :   ZQC-6   one impressed
UC-72G   :   AQC-6   one impressed
UC-72H   :   ZQC-6   five impressed
UC-72F   :   CUC-1   one impressed

Operators

Civil Operators

Wacos were used in small numbers by a very large number of individual operators in many countries.[12]

Military Operators

Most operators operated either a single example, or a very small number.

 Argentina
 Australia
 Brazil
 Canada
 Finland
 Netherlands
 New Zealand
 Nicaragua
 South Africa
 Sweden
 United Kingdom
 United States

Aircraft on display

Aside from the large number of privately owned Wacos that continue to exist,[22] a number have also found their way into museums.

Museum Location Type Identity
Canadian Museum of Flight[23] Langley, BC AQC-6 CF-CCW
EAA AirVenture Museum[24] Oshkosh, WI ARE NC20953
Historic Aircraft Restoration Museum[25] Maryland Heights, MO AVN-8 NC19378
Golden Wings Flying Museum[26] Minneapolis, MN CUC-1 NC15233
Virginia Aviation Museum[27] Richmond, VA YOC NC17740
War Eagles Air Museum[28] Santa Teresa, NM EGC-8 NC19354

Specifications (ZQC-6)

Data from Juptner, U.S. Civil Aircraft Series, Vol. 6[29]

General characteristics

  • Crew: one
  • Capacity: four passengers
  • Length: 26 ft 8 in (8.13 m)
  • Upper wingspan: 35 ft 0 in (10.67 m)
  • Lower wingspan: 24 ft 6 in (7.47 m)
  • Height: 8 ft 8 in (2.64 m)
  • Wing area: 244 sq ft (22.7 m2) total
  • Empty weight: 2,023 lb (918 kg)
  • Gross weight: 3,500 lb (1,588 kg)
  • Powerplant: 1 × Jacobs L-5 seven cylinder radial engine, 285 hp (213 kW) , first letter in designation (Z) indicates engine installed.
  • Propellers: 2-bladed

Performance

  • Maximum speed: 166 mph (267 km/h, 144 kn)
  • Cruise speed: 150 mph (240 km/h, 130 kn)
  • Service ceiling: 17,000 ft (5,200 m)

See also

Wikimedia Commons has media related to Waco Custom Cabin.

Related development

Aircraft of comparable role, configuration, and era

Related lists

References

Notes

  1. ^ a b Aerofiles 'That Waco Coding System' accessed 10 June 09
  2. ^ Brandly, 1981
  3. ^ Brandley, 1986, p.76
  4. ^ http://www.wdm.ca/skteacherguide/WDMResearch/AirAmbulance_TeacherGuide.pdf Saskatchewan's Air Ambulance Service, by Janet MacKenzie, 30 September 2002 - Accessed 29 May 2012
  5. ^ Congressional Record - Awarding a Congressional Gold Medal to members of the Civil Air Patrol Retrieved 27 June 2012
  6. ^ a b Jenner and List 1999, pp.9, 27, 45–46
  7. ^ a b Brandly, 1986, p.74
  8. ^ a b c d Swanborough & Bowers, 1990, p.534
  9. ^ a b c Aerofiles - USAAF Impressed Wacos, 2009
  10. ^ a b Francillon, 1970, p.8
  11. ^ a b Annerfalk, 1999, p.188
  12. ^ Golden Years of Aviation (aircraft registrations), accessdate 29 May 2012
  13. ^ http://www.worldairforces.com/Countries/argentina/arg.html Archived 2012-01-25 at the Wayback Machine
  14. ^ http://www.worldairforces.com/Countries/brazil/brz.html Archived 2012-10-18 at the Wayback Machine
  15. ^ http://www.worldairforces.com/Countries/canada/can.html Archived 2012-12-11 at the Wayback Machine
  16. ^ Brandley, Raymond H. (1981). Waco Airplanes - The Versatile Cabin Series. United States: R.H. Brandly. p. 67. ISBN 0-9602734-2-5.
  17. ^ http://www.worldairforces.com/Countries/finland/fin.html Archived 2012-01-25 at the Wayback Machine
  18. ^ http://www.worldairforces.com/Countries/netherlands/net.html Archived 2012-01-25 at the Wayback Machine
  19. ^ Duxbury, 1987, p.57
  20. ^ http://www.worldairforces.com/Countries/nicaragua/nic.html Archived 2012-01-25 at the Wayback Machine
  21. ^ Brandley, Raymond H. (1981). Waco Airplanes - The Versatile Cabin Series. United States: R.H. Brandly. p. 86. ISBN 0-9602734-2-5.
  22. ^ *FAA Registry Search for Waco accessed 12 June 2009
  23. ^ Waco AQC-6 Retrieved 28 June 2012
  24. ^ WACO ARE – NC20953 Retrieved 28 June 2012
  25. ^ Historic Aircraft Restoration Museum List of Aircraft Retrieved 28 June 2012
  26. ^ Golden Wings Flying Museum - The Collection Retrieved 27 June 2012
  27. ^ Virginia Aviation Museum Historic Aircraft (p 25) Retrieved 28 June 2012
  28. ^ War Eagles Air Museum Newsletter First Quarter 2005 Retrieved 28 June 2012
  29. ^ Juptner, 1993, pp.353-355

Bibliography

  • Annerfalk, Anders (1999). Flygvapnet - An illustrated history of the Swedish Air Force. Ljungsbro, Sweden: Aviatic Forlag. ISBN 91-86642-049.
  • Brandley, Raymond H. (1986). Waco Aircraft Production 1923-1942 - Troy, Ohio: Waco Aircraft Co (Second ed.). R.H. Brandly. ISBN 978-0960273454.
  • Brandley, Raymond H. (1989). Waco Airplanes - Ask Any Pilot - The Authentic History of Waco Airplanes and Biographies of... R.H. Brandly. ISBN 0-9602734-0-9.
  • Brandley, Raymond H. (1981). Waco Airplanes - Ask Any Pilot - The Versatile Cabin Series. R.H. Brandly. ISBN 0-9602734-2-5.
  • Duxbury, David; Ewing, Ross; MacPherson, Ross (1987). Aircraft of the Royal New Zealand Air Force. Singapore: Heinmann. ISBN 0-86863-412-3.
  • Francillon, Rene J. (1970). Royal Australian Air Force and Royal New Zealand Air Force in the Pacific. Aero Pictorials 3. Fallbrook CA: Aero Publishers Inc. LCCN 76-114412.
  • Green, William (1965). The Aircraft of the World. Macdonald & Co. (Publishers) Ltd.
  • Jenner, Robin; List, David; Badrocke, Mike (1999). The Long Range Desert Group 1940–1945. Oxford, UK: Osprey Publishing. ISBN 1-85532-958-1.
  • Juptner, Joseph P. (1962). U.S. Civil Aircraft Vol. 1. Los Angeles, California: Aero Publishers, Inc. LCCN 62-15967.

Juptner, Joseph P. (1993). U.S. Civil Aircraft Vol. 6. McGraw-Hill. ISBN 978-0830643714.

Retrieved from "https://en.wikipedia.org/w/index.php?title=Waco_Custom_Cabin_series&oldid=715100372"