Jump to content

Lynemouth power station

From Wikipedia, the free encyclopedia

This is an old revision of this page, as edited by Fintan264 (talk | contribs) at 10:34, 27 September 2009 (→‎Coal supply and transport). The present address (URL) is a permanent link to this revision, which may differ significantly from the current revision.

Not to be confused with Blyth Power Station.

Template:Infobox UK power station

Alcan Lynemouth Power Station (generally known as Lynemouth Power Station) is a coal and biomass fired power station which provides electricity for the Alcan Lynemouth Aluminium Smelter and the Nationial Grid. It is located on the coast of Northumberland, north east of the town of Ashington in North East England. The station has stood as a landmark on the Northumberland coast since it opened in the 1972, and has been privately owned by aluminium company Rio Tinto Alcan (formerly Alcan) throughout its operation.[1]

The station is one of the most recently built coal-fired power stations in the United Kingdom, but with a generating capacity of only 420 megawatts (MW), is now one of the smallest operating.[2] It is the most thermally efficient coal-fired power station in the UK.[3] In 2009, plans were granted to construct a 13 turbine wind farm to the north of the station,[4] and in the same year Alcan announced that they hope to fit the station with carbon capture and storage technology.[5]

History

In 1968, Alcan had applied for planning permission for the construction of a new aluminum smelter in Northumberland at Lynemouth.[6][7] Later that year, Alcan was granted the permission and site preparation would soon begin.[8] However, to meet the electric demand of the new smelter, a power station would also be needed to be built.[6] Therefore, Lynemouth Power Station was constructed only 800 m (2,600 ft) from the aluminum smelter.[9]

The two establishments were constructed in South East Northumberland as part of an incentive to lower the high unemployment numbers.[10] The site was also chosen because of the Ellington and Lynemouth collieries. Ellington Colliery sunk in 1909, with Lynemouth Colliery sinking 18 years later. However in 1968, the two collieries were connected underground by the Bewick Drift, from which coal was brought to the surface. The Drift had no rail connection, and so coal was sent to the washery at Lynemouth by conveyor belt.[11] The power station was constructed nearby the end of the conveyor belt.

Both buildings were designed by architects Yorke, Rosenberg & Mardall, with engineering consultation from Engineering & Power Consultants Ltd. The power station was constructed by Tarmac Construction and the smelter by M.J. Gleeson Company.[12] Both the power station and smelter were brought into operation in March 1972.[13]

Design and specifications

Electricity is fed from the power station to the smelter by a 24 kilovolt connection

The power station is divided into structures, which mainly include a boiler house and a turbine hall. Both of these structures have a steel frame foundation in the walls with aluminum cladding. Other structures include a single 114 m (374 ft) tall chimney made out of solid reinforced concrete, and coal delivery and sorting plant.[14]

The station's boiler house houses three 380 MWth International Combustion Ltd boilers, which are fueled by pulverised bituminous coal.[15][16] Each of these provide steam for on of three 140 megawatt (MW) Parsons turbo-alternators, situated in the station's turbine hall.[16] These give the station a total generating capacity of 420 MW. The electricity generated is fed at 24 kilovolt (kV) to a substation which powers the smelter. The substation also has a 132 kV connection to the National Grid, where electricity is distributed to homes and other industries by Northern Electric Distribution Limited. The smelter's two pot lines only require 310 MW of the 420 MW that the power station produces, so it is the excess 110 MW which is fed into the national grid.[1]

Between 1999 and 2000, the power station was given a turbine upgrade.[1] In 2000, the station's condensers were also refurbished. The condenser refurbishment was carried out by Alstom.[17] These improvements saw an increase in the station's generating capacity, thermal efficiency and MWh production.[1]

Operations

Coal supply and transport

Coal is delivered to the power station by railway and unloaded using a merry-go-round system

The power station is the leading coal customer in Northumberland, burning 1,200,000 tonnes of coal a year, with a weekly coal consumption between 25,000 and 27,000 tonnes.[1][18] The station has relatively limited coal storage facilities, and is only able to hold three to four weeks worth of its fuel.[18]

The station was designed specifically to burn coal from the Northumberland coalfields.[18] The neighbouring Ellington Colliery originally fed coal directly to the power station using a conveyor belt from its Bewick Drift Mine, situated 970 metres (3,180 ft) from the station. In 1994, Ellington Colliery connected underground with Lynemouth Colliery, but coal continued to be taken straight to the power station's coal sorting area using conveyor belts. This supply was supplemented by coal from local opencast mines.[18] However, Ellington Colliery was forced to close when it flooded in January 2005.[18] The station burned the colliery's remaining coal stock after it closed, and since then coal has been sourced from opencast mines in Northumberland and Scotland, but now a small amount of import is necessary.[18]

Coal is now delivered to the station mainly using rail transport and is unloaded at the station using a merry-go-round system. Trains supplying the station use the Newbiggin and Lynemouth branch line of the Blyth and Tyne Railway, which also serves the smelter. This line was originally used to export coal from Easington, and also had passenger services. These passenger services ceased in 1964, and now the line is only used to serve the power station and smelter.[19] Coal from the local opencast mines is brought to the station by road using heavy goods vehicles.[20] Coal is graded and washed at the station prior to being burned.[21]

With only one significant opencast in the local area mining past 2008, along with another smaller opencast at Stony Heap, there is a need for more local supplies of coal for the station because of the risks in depending upon overseas sources of coal.[18] Long distance supplies of coal can see sharp fluctuations in price, as well as the flexibility and security of the supply, whereas local sources aren't as vulnerable to interruptions and have fixed, contracted prices.[18] The station is not an established importer of coal, having only imported since 2005. It is situated a long way from the major coal unloading ports of Teesside, Hull and Immingham, which have been booked by power stations closer to them. This means that coal for the power station needs to be imported via Blyth or the Port of Tyne. However, because of the small sizes of these docks, they can only receive ships from Poland and Russia. Due to high production costs and industry restructuring in Poland though, the only realistic source of imported coal for the station is Russia.[18] The environmental impact of shipping 1,000,000 tonnes of coal from Russia to Lynemouth is the production of 12,812 tonnes of CO2, whereas hauling coal from local mines to the station would produce only 703 tonnes of CO2.[18] There are currently two local opencast mines for which planning approval have been granated, one at Shotton near Cramlington approved in 2007, the other at Potland Burn near Ashington approved in October 2008.[22] However, the coal mined from Potland Burn would have too high a sulphur content to meet the station's environmental requirements, meaning it wouldn't be an immediate choice of coal for the station.[23] Coal had been provided by the Delhi surface mine at Blagdon, owned by Banks Developments, since 2002. It finished extracting coal in March 2009, following the permission of extension proposals to its original plans in May 2007.[24]

Water use

For creating the steam to turn steam turbines and generate electricity, water is needed, and is thus beneficial to have near any thermal power station.[25] The water that is used in the Lynemouth power station is taken from a body of water located close to the plant, the North Sea. The water is transferred from the sea to the plant by a series of shafts and tunnels.[26] There are three condensers (one per each generating set) in the interior of the power station, which are used to cool the heated water before it can be transferred back to the North Sea.[17]

Operating close to the power station is a fishing bait company, Seabait. Seabait uses some of the excess hot water that the plant generates to grow worms four times as faster than in the wild.[27] The worms are used for several purposes, primarily for providing worms as bait while fishing. However, the worms are also frozen, packaged and exported to seafood farms.[28]

Ash removal

Ash from the station is usually either landfilled or recycled in the construction industry

Fly ash and bottom ash are two byproducts made through the burning of coal in power stations. Ash is normally dumped in the station's Ash Lagoons landfill site, which is located on site. Since 2006, ash produced at Lynemouth Power Station has been recycled and used as a sub-fill material in the construction industry and in the production of grout. In 2007, 63,000 tonnes of ash from the station, along with 100,000 tonnes of ash from the Ash Lagoons, was taken and recycled. In September 2007, Pulverised Fuel Ash was utilised as a filling material in the capping of Woodhorn Landfill, which had been used for the disposal of spent potlining from the smelter.[29]

Biomass usage

In December 2003 the Environment Agency granted permission for the plant to co-fire biomass fuels in the station. Since 2004 three different types of biomass fuel been in use at Lynemouth; Sawdust and Wood pellets from FSC certified forests and Olive residues. These fuels are mixed with the coal on the conveyor belt into the power station. In 2004 11,000 tonnes of biomass fuel were used in the station. Because biomass is considered 'Carbon neutral', this represents the equivalent to saving approximately 18,500 tonnes of CO2 by burning this material. Alcan aimed to increase the amount of biomass used in future.[30]

The station earned the world class OHSAS 18001 health and safety certificate in 2003 , ahead of Alcan's global targets. All of the station's staff were required to take place in safety audits to improve working practice at the station. The certificate was presented to the station's manager by Wansbeck MP Denis Murphy on 15 March 2003.[31] The station's attention to health and safety was further recognised on 6 June 2007 when they were honoured by the Royal Society for the Prevention of Accidents (RoSPA) with a RoSPA Occupational Health and Safety Award at the Hilton Birmingham Metropole Hotel.[32] Workers at the station had been audited by RoSPA for 10 years before receiving the award.[33]

Coastal defence

In late 1994, the power station was flooded to a foot deep of sea water, after a freak high tide and strong winds. This led to a sea defence system being constructed to protect the building.[34] The problems came about because of the temporary closure of Ellington Colliery. Tipped waste from the colliery had been used as a coastal defence measure, but as the colliery had closed, waste was no longer being tipped. The colliery was reopened by RJB Mining, and in July 1999 the station ensured the future of the colliery by signing a contract with RJB Mining to provided with 3,000,000 tonnes of coal from Ellington Colliery and opencast mines in Northumberland, over the course of three years. The colliery closed again in 2005, leading to problems with coastal defence again, threatening the station's coal stocking area.[35][36] This required to a £2.5 million new coastal defence scheme be put in place, involving the use of large rocks as a defence wall.[35]

Environmental impact and future

The power station's use of biomass since 2004 has been part of an attempt to reduce its carbon dioxide (CO2) output. In 2002 and 2004 the station met its targets for reduction in greenhouse gas emissions.[30] Despite this, in 2006 the power station was revealed as having the fourth highest CO2 emissions in the north of England, for producing 2,685,512 tonnes of CO2 per year.[37]

In 2006 a proposal was made to construct three 110 m (360 ft) tall wind turbines on a currently unused part of the station's coal sorting area, north of the power station.[38] ScottishPower Renewables were refused their initial planning application submitted in November 2006, as the site is spread over two council boundaries. Wansbeck Council approved the scheme, but Castle Morpeth refused. Following an appeal hearing in April 2008, permission was granted in January 2009 for the construction of up to 13 turbines. These will produce 30 MW of electricity, enough to supply over 16,000 homes with power.[4]

Following a visit to the station by Prime Minister Gordon Brown on 3 July 2009, it became apparent that Rio Tinto Alcan were hoping to be able to demonstrate Carbon Capture and Storage (CCS) technology at the station in the future. However due to the economic climate, Rio Tinto are not willing to commit the funding for the project themselves, and so are hoping to secure European Union funding available for demonstration of CCS technology.[5] The investment required could be up to £1 billion, but if funding is secured, "pre-combustion" CCS technology would be installed. This would involve treating the coal prior to burning so that less CO2 was produced, with any remaining CO2 being pumped under the North Sea into an aquifier.[39]

Despite these future plans, as of January 2009, the station and smelter's futures are under threat. The European Commission (EC) claim that Alcan is in breach of their operating license as the station has failed to "significantly reduce its emissions". The UK Government are contesting the allegations, as the power station and smelter combined provide 650 jobs and a contribution of £100,000,000 to the local economy. The EC are taking the UK Government to the European Court of Justice, with a hearing expected in late 2009.[40]

Cultural use and visual impact

Lynemouth power station's 370 ft tall chimney can be seen over an 8.2 mile stretch of the Northumberland coast.

Since its construction, the station has made appearances in a small number of films shot locally. These include:

  • Seacoal - a movie made by Amber Films in 1985. The station is features heavily as a backdrop in the beach scenes, where the characters are working, collecting seacoal.[41] Photographer Mik Critchlow (who would later become involved with Amber Films' sister company Side Gallery) also documented the seacoalers at Lynemouth, between 1981 and 1983. He also used the power station as an industrial backdrop to some of his images.[42][43]
  • Billy Elliot - a 2000 film directed by Stephen Daldry. The power station and the smelter both feature as an industrial backdrop in the film's cemetery scenes. The power station's coal sorting area is used to represent a colliery.[44]

The chimneys of both the power station and the smelter are strong landmarks on the local coastline, and can be seen over a 25 kilometres (16 mi) stretch of coast, from Cresswell[45] down to South Shields pier.[46]

See also

References

  1. ^ a b c d e "No Slide Title" (PDF). John Clarkson. Alcan. Retrieved 2008-07-29.
  2. ^ "Power Station Locations and Capacities". United Kingdom Quality Ash Association. Retrieved 26 September 2009.
  3. ^ "Energy efficiency, electricity production and air quality improved at Lynemouth" (HTML). http://www.publications.alcan.com/. Alcan. Retrieved 2008-07-29. {{cite web}}: External link in |work= (help)
  4. ^ a b "Planning Approval For Lynemouth Windfarm in Northumberland". Scottish Power. 9 January 2009. Retrieved 14 July 2009.
  5. ^ a b "Prime Minister pays visit to Alcan Lynemouth plant". The Journal. 3 July 2009. Retrieved 15 July 2009.
  6. ^ a b Crosland, Anthony (29 May 1968). "Aluminium Smelters". Hansard. Retrieved 2 September 2009.
  7. ^ Pevsner, Nikolaus (1992). Northumberland (2 ed.). Yale University Press. p. 103. ISBN 0300096380. Retrieved 2009-02-08. {{cite book}}: Unknown parameter |coauthors= ignored (|author= suggested) (help)
  8. ^ Crosland (10 July 1968). "Aluminium Smelters". Hansard. Retrieved 2 September 2009.
  9. ^ "Structure details". SINE Project (Structural Images of the North East). Newcastle University. Retrieved 2008-07-29.
  10. ^ Fernyhough (1 July 1968). "Unemployment (Northumberland)". Hansard. Retrieved 2 September 2009.
  11. ^ Catford, Nick (15 March 2005). "Site Records" (SHTML). http://www.subbrit.org.uk/. Retrieved 2009-02-08. {{cite web}}: External link in |work= (help)
  12. ^ "RIBA Journal". 80. 1973: 433. Retrieved 14 July 2009. {{cite journal}}: Cite journal requires |journal= (help)
  13. ^ "Cornerstone that looked far from secure". http://www.wiki-north-east.co.uk/. The Journal. 3 July 2002. Retrieved 2008-12-28. {{cite web}}: External link in |work= (help)
  14. ^ "30MW Northumberland wind farm wins consent on appeal". http://www.newenergyfocus.com/. 12 January 2009. Retrieved 2009-02-22. {{cite web}}: External link in |work= (help)
  15. ^ "EU Emissions Trading Scheme Benchmark Research for Phase 2" (PDF). http://www.berr.gov.uk/. Entec Engine Corporation. 2005. p. 318. Retrieved 2009-02-17. {{cite web}}: External link in |work= (help); Unknown parameter |month= ignored (help)
  16. ^ a b "Coal-Fired Power Plants in England - North" (HTM). http://www.industcards.com/. 30 May 2008. Retrieved 2009-02-17. {{cite web}}: External link in |work= (help)
  17. ^ a b "ALSTOM wins euros 7 million condensor contract from Alacan in the UK". Alstom. 24 November 2000. Retrieved 23 September 2009.
  18. ^ a b c d e f g h i j Price, David (2006). "SHOTTON SURFACE MINING SCHEME" (PDF). http://pscm.northumberland.gov.uk/. pp. 3–5. Retrieved 2009-01-08. {{cite web}}: External link in |work= (help)
  19. ^ "Newbiggin Station" (PHP). Retrieved 2009-02-22.
  20. ^ "Coal mining in the 21st Century". BBC News. Retrieved 2009-01-08.
  21. ^ "Coal mining in the 21st Century". BBC News. Retrieved 2009-01-08.
  22. ^ Honeysett, Simon (8 October 2008). "Ashington loses opencast mine fight" (HTML). http://ashington.journallive.co.uk/. The Journal. Retrieved 2009-01-08. {{cite web}}: External link in |work= (help)
  23. ^ "Dispute Over Jobs Promise". http://www.redorbit.com/. 19 October 2005. Retrieved 2009-01-08. {{cite web}}: External link in |work= (help)
  24. ^ "Delhi Surface Mine". http://www.banksdevelopments.com/. Retrieved 2009-01-08. {{cite web}}: External link in |work= (help)
  25. ^ "Steam turbines" (PHP). Retrieved 23 September 2009.
  26. ^ "Offshore Shaft Construction In The North Sea". 1 January 1997. Retrieved 2009-02-22.
  27. ^ "Bait company bought out of administration". http://www.nebusiness.co.uk/. The Journal. Retrieved 2008-08-02. {{cite web}}: External link in |work= (help)
  28. ^ Walker, Howard (14 August 2003). "University casts out and US takes bait". http://www.wiki-north-east.co.uk/. The Journal. Retrieved 2009-01-08. {{cite web}}: External link in |work= (help)
  29. ^ Anderson, R.J. (2007). "Environmental Report 2007" (PDF). http://ec.europa.eu/. Rio Tinto Alcan. pp. 4–5. Retrieved 2009-01-08. {{cite web}}: External link in |work= (help)
  30. ^ a b "Environmental Report 2004" (PDF). John Clarkson. Alcan. Retrieved 2008-07-29.
  31. ^ "A powerful accolade". http://www.wiki-north-east.co.uk/. Evening Chronicle. 15 March 2003. Retrieved 2009-01-02. {{cite web}}: External link in |work= (help)
  32. ^ Burn, Zoe (6 June 2007). "Safety record praise". http://www.wiki-north-east.co.uk/. Herald & Post. Retrieved 2009-01-02. {{cite web}}: External link in |work= (help)
  33. ^ Tomlinson, Gayle (9 June 2005). "In safe hands". http://www.wiki-north-east.co.uk/. Evening Chronicle. Retrieved 2009-01-02. {{cite web}}: External link in |work= (help)
  34. ^ "Those in peril from the sea". http://www.wiki-north-east.co.uk/. Evening Chronicle. 27 January 1995. Retrieved 2008-12-28. {{cite web}}: External link in |work= (help)
  35. ^ a b Black, Dave (8 April 2005). "Bid to protect key plant from waves". http://www.wiki-north-east.co.uk/. The Journal. Retrieved 2008-12-28. {{cite web}}: External link in |work= (help)
  36. ^ "Big Coal Deal Protects Jobs". http://www.wiki-north-east.co.uk/. Evening Chronicle. 5 July 1999. Retrieved 2009-01-02. {{cite web}}: External link in |work= (help)
  37. ^ Doherty, Phil (27 August 2006). "Shame of North's Worst Pollution". http://www.wiki-north-east.co.uk/. Sunday Sun. Retrieved 2008-12-28. {{cite web}}: External link in |work= (help)
  38. ^ Stirling, Nigel (1 November 2006). "Ward: Lynemouth". http://www.wiki-north-east.co.uk/. The Journal. Retrieved 2009-01-02. {{cite web}}: External link in |work= (help)
  39. ^ Thompson, Liam (2 April 2009). "Lynemouth power station leads the way". News Post Leader. Retrieved 15 July 2009.
  40. ^ "Alcan future threatened by Euro pollution laws". The Journal. 21 January 2009. Retrieved 17 September 2009.
  41. ^ "Seacoal (1985)". Amber Online. Retrieved 15 July 2009.
  42. ^ Critchlow, Mik. "004". Amber Online. Retrieved 16 July 2009.
  43. ^ "Seacoalers". Amber Online. Retrieved 16 July 2009.
  44. ^ Stephen Daldry - Director. Billy Elliot (DVD). Universal. Event occurs at 00:12:52 - 00:13:35, 01:13:00 - 01:14:30, 01:31:30 - 01:32:20. ISBN 820-372-7-11. Retrieved 17 July 2009. {{cite AV media}}: Check |isbn= value: length (help); Unknown parameter |year2= ignored (help)
  45. ^ Cornfoot, Roger (26 February 2007). "Broad Skear, Cresswell". Geograph. Retrieved 23 September 2009.
  46. ^ Smith, Quintin (2 March 2008). "Up the coast". Flickr. Retrieved 23 September 2009.
Wikimedia Commons has media related to Lynemouth Power Station.
Retrieved from "https://en.wikipedia.org/w/index.php?title=Lynemouth_power_station&oldid=316467178"