Canadair North Star
| North Star | |
|---|---|
| |
| BOAC DC-4M-4 Argonaut G-ALHS "Astra" at London Airport (Heathrow) in September 1954 | |
| Role | Passenger and cargo transport |
| Manufacturer | Canadair |
| First flight | 15 July 1946 |
| Introduction | 1946 |
| Retired | 1960s (RCAF), 1975 (last civil operator) |
| Primary users | Trans-Canada Air Lines Royal Canadian Air Force Canadian Pacific Air Lines BOAC |
| Produced | 1946 - 1950 |
| Number built | 71 |
| Developed from | Douglas DC-4 |
The Canadair North Star was a 1940s Canadian development of the Douglas C-54 / DC-4 aircraft. Instead of radial piston engines found on the Douglas design, Canadair used Rolls-Royce Merlin engines to achieve a faster cruising speed. The prototype flew on 15 July 1946 and the type was used by various airlines and by the RCAF. It provided reliable, if noisy, service through the 1950s and into the 1960s. Some examples continued to fly into the 1970s, converted to cargo aircraft.[1]
Design and development
Canadair Aircraft Ltd. took over the Canadian Vickers Ltd. operations on 11 November 1944. Besides the existing Consolidated PBY Canso flying patrol boats in production, a development contract to produce a new variant of the Douglas DC-4 transport, was still in effect. The new Canadair DC-4M powered by Rolls-Royce Merlin engines emerged in 1946 as the "North Star." More than just an engine swap, the North Star had the Douglas DC-6 nose, landing gear and fuselage shortened by 80 in (2 metres), DC-4 empennage, rear fuselage, flaps and wing tips, C-54 middle fuselage sections, wing centre and outer wing panel, cabin pressurisation, a standardized cockpit layout and a different electrical system.
Canadair built 71 examples under the designations: North Star, DC-4M, C-4 and C-5. With the exception of the single C-5 (which had Pratt & Whitney R-2800 engines, as fitted to the Douglas DC-6), these variants were all powered by Rolls-Royce Merlin engines and 51 of the production examples were pressurized.
Operational history
Trans-Canada Air Lines (TCA), the Royal Canadian Air Force (RCAF), Canadian Pacific Airlines (CPA) and British Overseas Airways Corporation (BOAC) were the principal operators of the "North Star", with the CPA examples known as the "Canadair Four" and BOAC examples known as the "Argonaut".
RCAF service
The RCAF North Stars were unpressurized and were used on a variety of transport duties. Like other North Stars, they were also notorious for the high level of cabin noise caused by the Merlin engines (since the Merlin engine is supercharged using a two-stage geared engine-driven supercharger, its exhaust is not run through a turbocharger, and thus exits the exhaust manifold in high-pressure bursts).
In an effort to reduce cabin noise, the sole C-5 variant was powered by Pratt & Whitney R-2800 Double Wasp engines that were considerably quieter.[2] The only C-5 was delivered to the RCAF in 1950, entering service with No. 412 Transport Squadron RCAF in Uplands, Ottawa, specially outfitted for the transportation of VIP passengers. It was used to transport the Canadian Prime Minister, the Queen, and numerous other dignitaries on various high profile missions, serving faithfully for 17 years, later becoming a crew trainer before being retired and sold in the United States.
North Stars were also employed by 412 Squadron RCAF on various VIP transport duties and, overall, the aircraft provided valuable and reliable long range transport services for the RCAF. From 1950 to 1952, during the Korean War, RCAF North Star aircraft were employed ferrying supplies to Korea across the Pacific Ocean. They flew 599 round trips over the Pacific and delivered seven million pounds of cargo and 13,000 personnel on return trips. They flew 1.9 million miles without a fatal crash and outhauled the United States Air Force C-54s on the Korean run. After 1967, the remaining North Stars were assigned to No. 426 Transport Squadron RCAF initially deployed to Dorval, Quebec and then to Trenton, Ontario. Gradually, their service life diminished in the 1970s and most were declared surplus.
TCA and BOAC operations
.jpg)
TCA received its fleet of twenty DC-4M-2 North Stars during 1947 and 1948 and operated them on routes within Canada and to the USA until 1961. Starting in 1954 the North Stars were replaced on TCA's routes to Europe by Lockheed Super Constellations. To deal with passenger complaints about noise, TCA engineers developed a cross-over for the fuselage-side exhausts that reduced cabin noise by 6-8 decibels.[2][3] "In the cabin, noise is reduced to 102 decibels near the windows and 93 at the aisle."[4]
BOAC ordered 22 DC-4M-4s and named them the "Argonaut class", each aircraft having a classical name beginning with "A". The Argonauts were delivered between March and November 1949; they flew to South America, Africa, the Middle East and the Far East from London Heathrow Airport until 1960. In February 1952 the BOAC Argonaut Atalanta transported the newly-acceded Queen Elizabeth II back to England from Kenya upon the death of her father, King George VI.[citation needed]
Later service
After service with TCA and BOAC, the surplused North Stars and Argonauts had long careers with secondary operators such as British Midland Airways, Overseas Aviation and other charter companies. Cargo conversions of available airframes also lengthened the service life of Argonauts and North Stars.CF-UXA,ex-RCAF 17510 was the last DC-4M in airline service, completing its final flight on 19 June 1975 at Miami, Florida. Despite the onset of jet airliners in the 1950s, the rugged Canadair North Star found a niche in both military and civil use.[1]
Variants
Operators
Accidents and incidents
- On 8 April 1954, a Royal Canadian Air Force Canadian Car and Foundry Harvard collided with a Trans-Canada Airlines North Star over Moose Jaw, Saskatchewan, killing 36 people on the aircraft and one person on the ground.
- On 21 September 1955, a BOAC Argonaut traveling from Rome to Tripoli crashed on its fourth landing attempt in poor visibility and strong winds. Fifteen of the 40 occupants died when the aircraft descended too low, struck trees approximately 1,200 ft short of runway 11 and subsequently impacted the terrain.[5]
- On 24 June 1956, a BOAC Argonaut, registered G-ALHE, crashed shortly after taking off from Kano Airport, Nigeria into a thunderstorm, killing 29 of the 38 passengers and three of the seven crew members.
- On 9 December 1956, Trans-Canada Air Lines Flight 810 crashed into Mount Slesse on a flight from Vancouver to Calgary, killing all 62 people on board the aircraft. Among the dead were five Canadian Football League players, including four members of the Saskatchewan Roughriders and one member of the Winnipeg Blue Bombers, as well as one CFL official; who were on their way home from the annual All-Star game played the previous day at Empire Stadium in Vancouver.
- On 27 August 1964, North Star registration CF-TFQ of Keegan Aviation was damaged beyond repair by Hurricane Leo at Miami, Florida, United States.[6]
- 4 June 1967, the Stockport Air Disaster occurred when an Argonaut aircraft (registration G-ALHG) owned by British Midland Airways crashed near the centre of Stockport, Greater Manchester, United Kingdom. Fatalities included 72 of the 84 on board; 12 others were seriously injured.
Surviving North Stars
A small number of surviving airframes are still in existence including an RCAF C-54GM example (17515 ) which is currently undergoing restoration at the Canada Aviation and Space Museum, Ottawa, Ontario.
Specifications (DC-4-M2 North Star)
Data from [citation needed]
General characteristics
- Crew: Seven
- Capacity: 52 First Class passengers, or 62 if operated as an all-Economy Class aircraft or 11,500 lbs (5,216 kg) of cargo
Performance
See also
Related development
Aircraft of comparable role, configuration, and era
Related lists
References
- Notes
- ^ a b Milberry 1982, pp. 213–214.
- ^ a b "Canadair North Star 1 ST." Canada Aviation Museum. Retrieved: 18 March 2011.
- ^ Aviation Week 7 Sept 1953 p53: "Crossovers reduce cabin noise level in the audio range by about 6–8 decibels."
- ^ American Aviation 12 May 1952 p28
- ^ "ASN Aircraft accident Canadair C-4 Argonaut G-ALHL Tripoli-Idris Airport (TIP)." Aviation Safety Network. Retrieved: 26 June 2011.
- ^ Eastwood and Roach 1991, pp. 57–58.
- Bibliography
- Berry, Peter et al. The Douglas DC-4. Tonbridge, Kent, UK: Air-Britain (Historians) Ltd, 1967.
- Blewett, R. Survivors. Coulsden, UK: Aviation Classics, 2007. ISBN 978-0-9530413-4-3.
- Bridgman, Leonard. Jane's All The World's Aircraft 1951–52. London: Sampson Low, Marston & Company, Ltd, 1951.
- Eastwood, Tony and John Roach. Piston Engine Airliner Production List. West Drayton, UK: Aviation Hobby Shop, 1991. ISBN 0-907178-37-5.
- Francillon, René. McDonnell Douglas Aircraft Since 1920: Volume I. London: Putnam, 1979. ISBN 0-87021-428-4.
- Milberry, Larry. The Canadair North Star. Toronto: CANAV Books, 1982. ISBN 0-07-549965-7.
- Pearcy, Arthur. Douglas Propliners: DC-1–DC-7. Shrewsbury, UK: Airlife Publishing, 1995. ISBN 1-85310-261-X.
- Pickler, Ron and Larry Milberry. Canadair: The First 50 Years. Toronto: CANAV Books, 1995. ISBN 0-921022-07-7.
- Yenne, Bill. McDonnell Douglas: A Tale of Two Giants. Greenwich, Connecticut: Bison Books, 1985. ISBN 0-517-44287-6.
External links
- Project North Star - restoration of North Star 17515
- Project North Star - restoration of North Star 17515, Canada Aviation and Space Museum web page
- Berlin Airlift Historical Foundation - Operates C-54 "Spirit of Freedom" as flying Berlin Airlift Museum
- "Canadair Four" a 1947 Flight article on the DC-4M
- "A Call on Canadair" a 1949 Flight article on the C4 - part 1
- "A Call on Canadair" a 1949 Flight article on the C4 - part 2
- "Quieter Argonaut" a 1952 Flight article on the Rolls-Royce exhaust system