Jump to content

Geo Metro

From Wikipedia, the free encyclopedia

This is an old revision of this page, as edited by 166.137.191.25 (talk) at 17:36, 22 April 2014 (→Second generation). The present address (URL) is a permanent link to this revision, which may differ significantly from the current revision.

Geo Metro
Overview
ManufacturerSuzuki
CAMI Automotive
General Motors
Production1989–2001
Body and chassis
ClassSupermini
Subcompact
B-segment
Chronology
SuccessorChevrolet Aveo

The Geo Metro was a marketing and manufacturing variation of the Suzuki Cultus available in North America from 1989 through 2001 as a joint effort of GM and Suzuki. In the US, the Metro carried a Geo nameplate from 1989 through 1997, and a Chevrolet nameplate from 1998 to 2001. It evolved with the Cultus and its siblings over 13 years, three generations and four body styles: 3-door hatchback, 4-door sedan, 5-door hatchback and 2-door convertible — and was ultimately replaced in the General Motors lineup by a family of vehicles based on the Daewoo Kalos.

From 1985 through 1989, Cultus-derived models sold in North America — under the nameplates Suzuki Forsa, Suzuki Swift, Chevrolet Sprint, Geo Metro and Pontiac Firefly — were sourced from Suzuki's facilities in Japan. Beginning in 1990, all North American M-cars were produced at CAMI Automotive, a 50-50 joint venture between General Motors and Suzuki in Ingersoll, Ontario, Canada. Production was Japan-sourced until 1990 manufacture commenced at CAMI Automotive, although Japanese production continued to source Canada bound sedan models. CAMI never reached its intended Metro/Firefly/Swift capacity.[1] While at its peak, Canadian Swift/Metro/Firefly production reached more than 100,000 vehicles a year, the number fell to just 32,000 in 2000.[2] In response to the waning popularity of smaller automobiles in the North American markets, Chevrolet/Geo sold only 55,600 Metros in 1997, off from 88,700 the year before.[3] In a 2004 Autoweek article, Osamu Suzuki, chairman of Suzuki, called CAMI "a fishbone in my throat" because of its low production.[1]

Beginning in late 2003 as a model year 2004 model, the Daewoo Kalos, marketed variously as the Chevrolet Aveo, Pontiac Wave and Suzuki Swift+, effectively replaced the Metro/Firefly, although the Aveo is more of a Daewoo Lanos replacement as opposed to the Metro, the same time when Daewoo closed majority of its dealerships outside South Korea in 2002.

The Suzuki Swift was replaced by the Suzuki Aerio hatchback in 2002, although the Aerio also replaced the Suzuki Esteem.

Chevrolet Sprint

Further information: Suzuki Cultus

GM began marketing the first generation Cultus in North America as the Chevrolet Sprint. The car was also sold as the Suzuki Forsa, and as the Pontiac Firefly in Canada. The Chevrolet Sprint was sold only in the Western United States until 1986, when nationwide sales in the US commenced. in 1987, the "Metro" name first appeared on a model of the naturally aspirated Chevrolet Sprint: the "Chevrolet Sprint Metro."

First generation

Further information: Suzuki Cultus
1992 Metro convertible

Production of the first Geo Metro models, equivalent to the second generation Suzuki Cultus, began at Suzuki's plant in Hamamatsu, Japan, in late 1988. In 1989, it debuted and replaced the Chevrolet Sprint in the United States. Canadian models continued with the Chevrolet Sprint and Pontiac Firefly nameplates, while the second generation Suzuki Swift replaced the Forsa nameplate. This generation was also marketed by Suzuki as the "Swift" in the United States. The Metro/Swift/Sprint lineup received a facelift, while the Firefly was temporarily discontinued. The first generation Metro was replaced by a rebodied model unique to the North American market.

2001 metro aol autos lsi overviewautomobile |name=Second generation |image=Chevrolet Metro sedan.jpg |production=1995–2001 |aka=Geo Metro (1995–1997)
Chevrolet Metro (1998–2001)
Pontiac Firefly
Suzuki Swift |body_style = 3-door hatchback
4-door sedan |engine=1.0 L LP2 I3
1.3 L L72 I4
1.3 L LY8 16-valve I4 |assembly= Ingersoll, Ontario, Canada |transmission=5-speed manual
3-speed automatic |wheelbase= 93.1 in (2,365 mm) |length= 149.4 in (3,795 mm) (Hatchback)
164.0 in (4,166 mm) (Sedan) |width= 62.6 in (1,590 mm) |layout= Transverse front-engine, front-wheel drive |platform = M platform |height= 54.7 in (1,389 mm) (Hatchback)
55.4 in (1,407 mm) (Sedan) }}

The third generation of the Sprint/Metro line in North America was introduced in 1995 as a three-door hatchback and four-door sedan — using an adaptation of the longer wheelbase platform from the second generation Cultus for both body configurations. Also designed at GM's Design Center, it carried styling cues similar from the bigger Chevrolet Cavalier[4] and was built on the Suzuki developed M platform with Suzuki drivetrains. These models were marketed only in North America, carrying the nameplates Geo Metro (later re-branded the Chevrolet Metro), Pontiac Firefly, and Suzuki Swift — and sourced only from CAMI Automotive. Thus this version was never sold as a Cultus, which was replaced by the Cultus Crescent in Japan. Production ended after model year 2001.

Comparison of Generation III/II 3-door hatchback interior dimensions:

Gen III Gen II
Front Headroom (in.) 39.10 37.80
Rear Headroom (in.) 36.00 36.50
Front Legroom (in.) 42.50 42.50
Rear Legroom (in.) 32.80 29.8

In 1995, the second generation Metro came with the 3-cylinder still used on base models and becoming an option for non-LSi models in 1997. This generation had the first Pontiac Firefly to offer the 1.3 litre inline four cylinder engine.

The third generation North American "Cultus" featured two engines, a revised 1.3 L multi-point fuel injected four-cylinder engine (with hydraulic lifters and lash adjusters, and a 30,000-mile service interval[5]) and a 1.0 L throttle body injected three-cylinder engine. The 1.0 L became the last engine on a vehicle available in the US to use TBI. The 1.3 L I4 offered 70 hp (52 kW), and was the same engine that had been in use in the Suzuki Swift (except for the GT models) in prior years. LSi models produced after 1997 featured the four-cylinder engine with a sixteen-valve head instead of the eight valves of the earlier design, yet was still an SOHC design. It produced 79 hp (59 kW). Contemporary Suzuki Swifts were available with only the four-cylinder, and only as a hatchback. The hatchback body configuration featured a three-inch lower liftover height compared to the previous generation model.[5] Safety equipment included optional anti-lock brakes, safety cage construction with deformable front and rear crush zones and five structural crossbars engineered to spread side impact loads throughout the car's structure,[5] steel side impact door safety beams,[6] and daytime running lights (the second generation Metro was the second GM car to offer DRLs in the United States. The 1995 Chevrolet Corsica was the first.), and dual frontal airbags. A new, one-piece instrument panel was mounted to one of the five crossmembers with a new, full seal filling the gap between the instrument panel and the dash.[5] The sedan and coupe chassis were 20% and 5% stiffer respectively than the previous generation 5-door and coupe Metros,[5] and at the time of its introduction, the Metro was the smallest car in the world to meet the impending 1997 North American side impact standards.[5] The revised sedan was also introduced in the United States, replacing the 5-door hatchback. The third generation featured a coefficient of drag of 0.32.[6]

At the time of the third generation introduction, 41% of Metro buyers were first-car buyers, 62% of the buyers were female, and the median age of a Metro buyer was 37.[5]

The American Council for an Energy-Efficient Economy (ACEEE) named the third generation Chevrolet Metro and Suzuki Swift as the top two gasoline-fueled vehicles within their Top 12 Greenest Vehicles in 1998 and 1999. ACEEE assigns a Green Score to each vehicle make and model sold in the US, based on the vehicles’ exhaust emissions, fuel economy and other specifications.[7][8][9]

The Chevrolet Metro LSi sedan has more front legroom than the Toyota Echo and BMW 5 Series.[10]

  • 1995 – The second generation Metro was introduced with a revised 4-cylinder engine for LSi models with hydraulic lifters and lash adjusters, and a 30,000-mile service interval[5] — supplementing the 3 cylinder models. The hatchback featured a three-inch lower liftover height compared to the second generation,[5] and safety equipment included optional anti-lock brakes, safety cage construction with deformable front and rear crush zones, and steel side impact door safety beams [6] and new daytime running lights — the Metro was the first GM car to get DRLs as standard equipment, as well as dual frontal airbags. The sedan and hatchback chassis were 20% and 5% stiffer respectively than the previous generation Metros,[5] and at the time of its introduction, the Metro was the smallest car in the world to meet the impending 1997 side impact standards.[5] The revised sedan was also introduced in the United States, replacing the 5-door hatchback. Its twins, Pontiac Firefly and Suzuki Swift featured the same redesign. The Metro now featured a coefficient of drag of .32.[6] At the introduction of the third generation, GM arranged for a car carrier with 1995 Metros to drive to college campuses across the country. Local writers took a half-day seminar at "Metro University" with the head product planner and senior members of the engineering, assembly, and marketing teams.[5]
  • 1996 – OBD-II (On-Board Diagnostics, Second generation) was added to Metro models, at a cost of some fuel efficiency.
  • 1997 – The last year for the Geo brand. The Metro returned in 1998 with a Chevrolet nameplate.
  • 1998 – The Metro now carried the Chevrolet nameplate, along with new front and rear fascias and a SOHC 16v design I-4 1.3L engine with a horsepower increase of 12%. Electronic ignition replaced the distributor, and MPFI (Multiport Fuel Injection) replaced the TBI (Throttle Body Injection). The new motor offered more HP, torque, and higher fuel economy. This I-4 engine replaced the older 8v 4 cylinder, but the 3-cylinder engine remained unchanged.
  • 2001 – The Metro's final year. The only model available this year is the 4-door LSi sedan. The Metro continued on sale in Canada. General Motors announces that the Metro would not be included in the 2002 Chevrolet model lineup. CAMI Automotive manufactures the last Metro, a red sedan, on April 26, 2000.

Solectria, a Massachusetts company, converted examples of the first and second generation Geo Metro to electric operation. Approximately 500 examples of 1996 and 1997 models were converted to electric operation — the bare vehicles were provided by GM without engines. Called the Solectria Force and Solectria EV, the converted vehicles featured 3 phase AC induction motors and regenerative braking. The battery pack consists of 13 Group 27 Decca Dominator Sealed Gel Lead Acid modules.[11]

Nameplate Market Body
1995–2000 Suzuki Swift N. America 3
1995–2000 Pontiac Firefly Canada 3/4
1995–1997 Geo Metro N. America 3/4
1998–2000 Chevrolet Metro N. America 3/4

3= 3-dr hatchback
4= 4-dr sedan

  • Geo Metro 3-Door, Gen III
    Geo Metro 3-Door, Gen III
  • 1997 Gen III Geo Metro LSI Sedan
    1997 Gen III Geo Metro LSI Sedan
  • 1995–1997 Pontiac Firefly 3dr hatchback, Gen III
    1995–1997 Pontiac Firefly 3dr hatchback, Gen III
  • 1998–2001 Pontiac Firefly sedan, Gen III
    1998–2001 Pontiac Firefly sedan, Gen III

Safety

US third generation models received the following NHTSA's New Car Assessment Program ratings:

  • Front Impact, Driver:
  • Front Impact, Passenger:

Test numbers indicate the chance of serious injury: 4 = 10–20%
See NHTSA Test Results: 1996 Geo Metro
See Video: 1998 Canadian Geo Metro Crash Test

Bubble in used Metro prices

The Metro enjoyed increased interest as a used car in 2008, by virtue of its fuel mileage and rising fuel costs[12] [13] [14] [15] [16] .[17]

"As gas prices spike and consumers increasingly look for ways to get to work more efficiently, heavy media coverage has spurred interest in one particular old car: the Geo Metro."

US News, 2008[12]

Partially because of the renewed interest in the Metro, the July 2009 issue of Car and Driver included a base model 1998 Chevrolet Metro 3-door hatchback among vehicles tested for fuel efficiency alongside two hybrid models: the redesigned Honda Insight and Toyota Prius models. Car and Driver jokingly ridiculed the Metro's age and equipment, docking seven points from its overall score for its lack of amenities and mentioning that it was originally sold brand-new without hubcaps. Regardless, the Metro tied the Prius for best overall fuel economy at 42 mpg‑US (5.6 l/100 km). The vehicle finished third overall behind the Insight and Prius.[18]

References

  1. ^ a b "Pontiac planning to add Chevrolet Equinox-based sport wagon to lineup". Autoweek.com, March 5, 2004.
  2. ^ "CANADA: CAMI ends Suzuki Swift production". Just-auto.com, 5 June 2001.
  3. ^ "CAMI gets a new lease on life". Wards Auto World, December 1, 1998.
  4. ^ Bill Russ. "1995 Geo Metro LSi Sedan". The Auto Channel. Retrieved 2010-12-10.
  5. ^ a b c d e f g h i j k l "Little Big Man, First Look: 1995 Geo Metro". Hardive.com, J.J. Gertler.
  6. ^ a b c d "New Car Review 1995 GEO METRO LSi SEDAN". The Auto Channel, Bill Russ. Cite error: The named reference "autoch" was defined multiple times with different content (see the help page).
  7. ^ "The 12 Greenest Vehicles in 1999". Ecomall.com.
  8. ^ O'Dell, John (February 18, 1999). "Guide: It Isn't Easy Being Green". The LA Times, John O'Dell, February 18, 1999. Retrieved May 24, 2010.
  9. ^ "Guide to green cars, trucks released". CNN.com, March 19, 1998. Retrieved May 24, 2010.
  10. ^ http://autos.aol.com/cars-compare?cur_page=details&v1=USB00CHC102A0&v2=USB00HYC012A0&v3=USB00TOC092A0&v4=USA90DAC012B0&v5=USB00BMC061A0&v6=&v7=&v8=&v9=&state=&mileage=
  11. ^ "1997 Solectria EV". Nextautos.com, Seyth Miersma, 05/01/2008.
  12. ^ a b "Geo Metro Madness Hits High". USNEWS, May 22, 2008.
  13. ^ "Who's laughing now? Subcompact owners". London Free Press, Norman De Bono, May 16, 2008.
  14. ^ "Gas prices drive Geos from clunkers to chic". Cnn.com, Mallory Simon, May 20, 2008. May 20, 2008. Retrieved May 24, 2010.
  15. ^ "The Geo Metro Rides Again, Sort Of". Business Week, Jim Henry, June 2, 2008.
  16. ^ "All Hail (or Mourn) the Geo Metro". The New York Times, The Lede, June 10, 2008, Mike Nizza. June 10, 2008. Retrieved May 24, 2010.
  17. ^ "Gas costs have drivers thinking smaller, older". Mercury News, Linda Goldston, 05/20/2008.
  18. ^ "2010 Honda Insight vs. 2010 Toyota Prius, 1998 Chevy Metro – Comparison Tests".
Retrieved from "https://en.wikipedia.org/w/index.php?title=Geo_Metro&oldid=605325043"