Project Gemini

This article is about the NASA program. For other uses, see Gemini (disambiguation).

McDonnell Gemini spacecraft
Gemini 7 in orbit, as seen by the crew of Gemini 6.
Volume:	90 ft³	2.55 m³
Weights
Retrograde module:	1,303 lb	591 kg
Equipment module:	2,815 lb	1,277 kg
Total:	8,490 lb	3,851 kg
Rocket engines
Retros (solid fuel) x 4:	2,500 lbf ea	11.12 kN
Reentry Control System (N2O4/MMHH) x 16:	25 lbf ea	111 N
OAMS (N2O4/MMHH) x 2:	85 lbf ea	378 N
OAMS (N2O4/MMHH) x 6:	100 lbf ea	445 N
OAMS (N2O4/MMHH) x 8:	25 lbf ea	111 N
Performance
Endurance:	14 days	206 orbits
Apogee:	250 miles	402 km
Perigee:	100 miles	160 km
Spacecraft delta v:	728 ft/s	222 m/s
Gemini spacecraft diagram
Gemini spacecraft diagram (NASA)
McDonnell Gemini Spacecraft

Project Gemini was the second human spaceflight program of NASA, the civilian space agency of the United States government. Project Gemini operated between Projects Mercury and Apollo, with 10 manned flights occurring in 1965 and 1966. Its objective was to develop techniques for advanced space travel, notably those necessary for Project Apollo, whose objective was to land humans on the Moon. Gemini missions included the first American spacewalks, and new orbital maneuvers including rendezvous and docking.

kurt fails

Specifications

Replica of a Gemini spacecraft at the Neil Armstrong Air and Space Museum

A cutaway of the Project Gemini spacecraft

Gemini's primary difference from Mercury was that the earlier spacecraft had all systems other than the reentry rockets situated within the capsule, to which access of nearly all was through the astronaut's hatchway. In contrast, Gemini housed power, propulsion, and life support systems in a detachable Equipment Module located behind the Reentry Module, which made it similar to the Apollo Command / Service module design. Many components in the capsule itself were reachable through their own small access doors.

The original intention was for Gemini to land on solid ground instead of at sea, using a paraglider rather than a parachute, with the crew seated upright controlling the forward motion of the craft. To facilitate this, the paraglider did not attach just to the nose of the craft, but to an additional attachment point for balance near the heat shield. This cord was covered by a strip of metal which ran between the twin hatches. However, this design was ultimately dropped and parachutes were used in a conventional nose-up sea landing.

Early short-duration missions had their electrical power supplied by batteries; later endurance missions used the first fuel cells in manned spacecraft.

The "Gemini" designation comes from the fact that each spacecraft held two people, as "gemini" in Latin means "twins". Gemini is also the name of the third constellation of the Zodiac and its twin stars, Castor and Pollux.

Unlike Mercury, which could only change its orientation in space, the Gemini spacecraft could translate in all six directions, and alter its orbit. It was designed to dock with the Agena Target Vehicle, which had its own large rocket engine which was used to perform large orbital changes.

Gemini was the first American manned spacecraft to include an onboard computer, the Gemini Guidance Computer, to facilitate management and control of mission maneuvers. It was also unlike other NASA craft in that it used ejection seats, in-flight radar and an artificial horizon - devices borrowed from the aviation industry. Using ejection seats to push astronauts to safety was first employed by the Soviet Union in the Vostok craft manned by cosmonaut Yuri Gagarin.

The Gemini program cost $5.4 billion.

Team

Project Gemini insignia

Gemini was designed by a Canadian, Jim Chamberlin, formerly the chief aerodynamicist on the Avro Arrow fighter interceptor program with Avro Canada. Chamberlin joined NASA along with 25 senior Avro engineers after cancellation of the Arrow program, and became head of the U.S. Space Task Group’s engineering division in charge of Gemini. The prime contractor was McDonnell Aircraft, which was also the prime contractor for the Mercury capsule.

In addition, astronaut Gus Grissom was heavily involved in the development and design of the Gemini spacecraft. He writes in his posthumous 1968 book Gemini! that the realization of Project Mercury's end and the unlikelihood of his having another flight in that program prompted him to focus all of his efforts on the upcoming Gemini Program.

The Gemini program was managed by the Manned Spacecraft Center, Houston, Texas, under direction of the Office of Manned Space Flight, NASA Headquarters, Washington, D.C, Dr. George E. Mueller, Associate Administrator of NASA for Manned Space Flight, served as acting director of the Gemini program. William C. Schneider, Deputy Director of Manned Space Flight for Mission Operations, served as Mission Director on all Gemini flights beginning with Gemini VI.

Guenther Wendt was a McDonnell engineer who supervised launch preparations for both the Mercury and Gemini programs. His team was responsible for completion of the complex pad close-out procedures just prior to spacecraft launch, and he personally closed the hatches before flight. The astronauts appreciated his taking absolute authority over the condition of the spacecraft and developed a good-humored rapport with him.

Astronauts

The following astronauts flew on the 10 manned Gemini missions:

From Astronaut Group 1
Astronaut	Service	Mission
L. Gordon Cooper	USAF	Gemini V
Virgil "Gus" Grissom	USAF	Gemini III
Walter M. Schirra	USN	Gemini VI-A
From Astronaut Group 2
Astronaut	Service	Mission
Neil A. Armstrong	Civilian	Gemini VIII
Frank Borman	USAF	Gemini VII
Charles "Pete" Conrad	USN	Gemini V, Gemini XI
James A. Lovell	USN	Gemini VII, Gemini XII
James A. McDivitt	USAF	Gemini IV
Thomas P. Stafford	USAF	Gemini VI-A, Gemini IX-A
Edward H. White II	USAF	Gemini IV
John W. Young	USN	Gemini III, Gemini X
From Astronaut Group 3
Astronaut	Service	Mission
Edwin "Buzz" Aldrin	USAF	Gemini XII
Eugene A. Cernan	USN	Gemini IX-A
Michael Collins	USAF	Gemini X
Richard F. Gordon	USN	Gemini XI
David R. Scott	USAF	Gemini VIII

Crew selection

Deke Slayton, as head of the Astronaut Office, had the main role in the choice of crews for the Gemini program. With Gemini it became a procedure that each flight had a primary crew and backup crew, and that the backup crew would rotate to primary crew status three flights later. Slayton also intended for first choice of mission commands to be given to the four remaining active astronauts of the Mercury Seven: Alan Shepard, Grissom, Cooper, and Schirra. (John Glenn had retired from NASA in January 1964 and Scott Carpenter, who was blamed by some in NASA management for the problematic reentry of Aurora 7, was on leave to participate in the Navy's SEALAB project and was grounded from flight in July 1964. Slayton himself continued to be grounded due to a heart problem.)

In late 1963, Slayton selected Shepard and Stafford for Gemini 3, McDivitt and White for Gemini 4, and Schirra and Young for Gemini 5 (which was to be the first Agena rendezvous mission). Backup crew for Gemini 3 was Grissom and Borman, who were also slated for Gemini 6, to be the first long-duration mission. Finally Conrad and Lovell were assigned as backup crew for Gemini 4.

Delays in the production of the Agena Target Vehicle caused the first rearrangement of the crew rotation. The Schirra and Young mission was bumped to Gemini 6 and they now were the backup crew for Shepard and Stafford. Grissom and Borman now had their long-duration mission assigned to Gemini 5.

The second rearrangement occurred when Shepard developed Meniere's disease, an inner ear problem. Grissom was then moved to command Gemini 3. Slayton felt that Young was a better personality match with Grissom and switched Stafford and Young. Finally, Slayton tapped Cooper to command the long-duration Gemini 5. Again for reasons of compatibility, he moved Conrad from backup commander of Gemini 4 to pilot of Gemini 5, and Borman to backup command of Gemini 4. Finally he assigned Armstrong and Elliot See to be the backup crew for Gemini 5.

The third rearrangement of crew assignment occurred when Slayton felt that See wasn't up to the physical demands of EVA on Gemini 8. He reassigned See to be the prime commander of Gemini 9 and put Scott as pilot of Gemini 8 and Charles Bassett as the pilot of Gemini 9.

The fourth and final rearrangement of the Gemini crew assignment occurred after the deaths of See and Bassett when their trainer jet crashed, ironically into a McDonnell building which held their Gemini 9 capsule in St. Louis. The backup crew of Stafford and Cernan was then moved up to the new prime crew of the re-designated Gemini 9A. Lovell and Aldrin were moved from being the backup crew of Gemini 10 to be the backup crew of Gemini 9. This cleared the way through the crew rotation for Lovell and Aldrin to become the prime crew of Gemini 12.

Along with the deaths of Grissom, White, and Roger Chaffee in the fire of Apollo 1, this final arrangement helped determine the makeup of the first seven Apollo crews, and who would be in position for a chance to be the first to walk on the Moon.

In his autobiography Deke! Slayton relates that he would probably have replaced Aldrin with Cernan, the backup pilot for Gemini 12, if the second flight of the AMU had flown on Gemini 12. Cernan makes a similar claim in his autobiography.

As it happened, despite these random substitutions and similar ones in Apollo, and a different number of unmanned flights in both programs, Slayton's rotation philosophy dominated to create a curious coincidence: most of the Gemini astronauts who went on to fly in Apollo occupied an Apollo mission numbered one more than their corresponding Gemini mission:

• Schirra commanded Gemini 6 and Apollo 7.
• Borman and Lovell flew together on Gemini 7 and Apollo 8.
• David Scott flew on Gemini 8 and Apollo 9.
• Stafford and Cernan flew together on Gemini 9A and Apollo 10.
• Collins flew on Gemini 10 and Apollo 11.
• Conrad and Gordon flew together on Gemini 11 and Apollo 12.
• Lovell commanded Gemini 12 and Apollo 13.

The only exceptions to this pattern were:

• McDivitt, who commanded Gemini 4 and Apollo 9
• Young, who flew Gemini 3 and Apollo 10
• Armstrong, who commanded Gemini 8 and Apollo 11

Missions

File:Titan2.jpg

Liftoff of Gemini 6A from Pad 19 with astronauts Walter Schirra and Thomas Stafford aboard (15Dec65)

There were 12 Gemini flights, including two unmanned flight tests. All were launched by Titan II rockets.

Unmanned

Mission	LV Serial No	Mission Dates	Launch Time	Duration	Remarks
Gemini 1	GLV-1 12556	8 April-12, 1964	16:01 UTC	03d 23h	First test flight of Gemini
Gemini 2	GLV-2 12557	19 January 1965	14:03 UTC	00d 00h 18m 16s	Suborbital flight to test heat shield

Manned

Mission	LV Serial No	Command Pilot	Pilot	Mission Dates	Launch Time	Duration
Gemini III	GLV-3 12558	Grissom	Young	23 March 1965	14:24 UTC	00d 04h 52m 31s
	First manned Gemini flight, three orbits.
Gemini IV	GLV-4 12559	McDivitt	White	3-7 June, 1965	15:15 UTC	04d 01h 56m 12s
	Included first extravehicular activity (EVA) by an American; White's "space walk" was a 22 minute EVA exercise.
Gemini V	GLV-5 12560	Cooper	Conrad	21-29 August, 1965	13:59 UTC	07d 22h 55m 14s
	First week-long flight; first use of fuel cells for electrical power; evaluated guidance and navigation system for future rendezvous missions. Completed 120 orbits.
Gemini VII	GLV-7 12562	Borman	Lovell	4-18 December, 1965	19:30 UTC	13d 18h 35m 01s
	When the original Gemini VI mission was scrubbed because its Agena target for rendezvous and docking failed, Gemini VII was used for the rendezvous instead. Primary objective was to determine whether humans could live in space for 14 days.
Gemini VI-A	GLV-6 12561	Schirra	Stafford	15-16 December, 1965	13:37 UTC	01d 01h 51m 24s
	First space rendezvous accomplished with Gemini VII, station-keeping for over five hours at distances from 0.3 to 90 m (1 to 300 ft).
Gemini VIII	GLV-8 12563	Armstrong	Scott	16-17 March, 1966	16:41 UTC	00d 10h 41m 26s
	Accomplished first docking with another space vehicle, an unmanned Agena stage. While docked, a Gemini spacecraft thruster malfunction caused near-fatal tumbling of the craft, which, after undocking, Armstrong was able to overcome; the crew effected the first emergency landing of a manned U.S. space mission.
Gemini IX-A	GLV-9 12564	Stafford	Cernan	3-6 June, 1966	13:39 UTC	03d 00h 21m 50s
	Rescheduled from May to rendezvous and dock with augmented target docking adapter (ATDA) after original Agena target vehicle failed to orbit. ATDA shroud did not completely separate, making docking impossible. Three different types of rendezvous, two hours of EVA, and 44 orbits were completed.
Gemini X	GLV-10 12565	Young	Collins	18-21 July, 1966	22:20 UTC	02d 22h 46m 39s
	First use of Agena target vehicle's propulsion systems. Spacecraft also rendezvoused with Gemini VIII target vehicle. Collins had 49 minutes of EVA standing in the hatch and 39 minutes of EVA to retrieve experiment from Agena stage. 43 orbits completed.
Gemini XI	GLV-11 12566	Conrad	Gordon	12-15 September, 1966	14:42 UTC	02d 23h 17m 08s
	Gemini record altitude, 1,189.3 km (739.2 mi) reached using Agena propulsion system after first orbit rendezvous and docking. Gordon made 33-minute EVA and two-hour standup EVA. 44 orbits.
Gemini XII	GLV-12 12567	Lovell	Aldrin	11-15 November, 1966	20:46 UTC	03d 22h 34m 31s
	Final Gemini flight. Rendezvoused and docked manually with its target Agena and kept station with it during EVA. Aldrin set an EVA record of 5 hours 30 minutes for one space walk and two stand-up exercises, and demonstrated improvements to previous EVA problems.

Gemini-Titan launches and serial numbers

Gemini 6A launch. USAF serial number location on Titan II.

The Gemini-Titan launch vehicles, like the Mercury-Atlas vehicles before them, were ordered by NASA through the U. S. Air Force and were in reality missiles. The Gemini-Titan II rockets were assigned U.S. Air Force serial numbers, which were painted in four places on each Titan II (on opposite sides on each of the first and second stages). U.S. Air Force crews maintained Launch Complex 19 and prepared and launched all of the Gemini-Titan II launch vehicles.

The USAF serial numbers assigned to the Gemini-Titan launch vehicles are given in the tables above. Fifteen Titan IIs were ordered in 1962 so the serial is "62-12XXX", but only "12XXX" is painted on the Titan II. The order for the last three of the fifteen launch vehicles was cancelled on 30 July 1964, and they were never built. Serial numbers were, however, assigned to them prospectively: 12568 - GLV-13; 12569 - GLV-14; and 12570 - GLV-15.

All Gemini Launches from GT-1 through GT-12.

Current location of hardware

Spacecraft

Gemini 1 -Destroyed

Gemini 2 - Air Force Space & Missile Museum, Cape Canaveral Air Force Station, Fla.

Gemini III - Grissom Memorial, Spring Mill State Park, Mitchell, Ind.

Gemini IV - National Air and Space Museum, Washington D.C.

Gemini V - Johnson Space Center, NASA, Houston, Texas

Gemini VI - Oklahoma History Center, Oklahoma City, Okla.

Gemini VII - Steven F. Udvar-Hazy Center, Chantilly, Va.

Gemini VIII - Armstrong Air and Space Museum, Wapakoneta, Ohio

Gemini IX - Kennedy Space Center, NASA, Cape Canaveral, Fla.

Gemini X - Kansas Cosmosphere and Space Center, Hutchinson, Kan.

Gemini XI - California Museum of Science and Industry, Los Angeles, Calif.

Gemini XII - Adler Planetarium, Chicago, Ill.

Trainers

Gemini 3A - St. Louis Science Center, St. Louis, Mo.

Gemini MOL-B - National Museum of the United States Air Force, Wright-Patterson Air Force Base, Dayton, Ohio

Gemini Trainer - U.S. Space & Rocket Center, Huntsville, Ala.

Gemini Trainer - Goddard Space Flight Center (Visitor Center), NASA, Greenbelt, Md.

Gemini Trainer - Louisville Science Center, Louisville, Ken.

6165 - National Air and Space Museum, Washington D.C. (not on display)

El Kabong - Kalamazoo Air Museum, Kalamazoo, Mich.

Gemini Trainer - Kalamazoo Air Museum, Kalamazoo, Mich.

TTV-2 Royal Museum, Edinburgh, Scotland

Trainer - Pate Museum of Transportation, Fort Worth, Texas

MSC 313 - Private residence, San Jose, Calif.

Rogallo Test Vehicle - White Sands Space Harbor, White Sands, N. M.

TTV-1 - Stephen F. Udvar-Hazy Center, Chantilly, Va.

unnamed - U.S. Air Force Space Museum, Cape Canaveral Air Force Station, Fla.

unnamed - U.S. Air Force Space Museum, Cape Canaveral Air Force Station, Fla.

Gemini Trainer - BDL Aerospace and Flight Museum, NAS Whidbey Island, Oak Harbor, WA.

Trainer - U.S. Astronaut Hall of Fame, Titusville, Fla.

MSC-307 - USS Hornet Museum, Alameda, Calif.

Proposed Gemini applications

Main article: Advanced Gemini

McDonnell Aircraft was one of the original bidders on the prime contract for Apollo, but lost out to North American Aviation. McDonnell later sought to extend the Gemini program by proposing a derivative which could be used to fly a cislunar mission and even achieve a manned lunar landing earlier and at less cost than Apollo, but these proposals were rejected by NASA.

Military

The United States Air Force had an interest in the system, and decided to use its own modification of the spacecraft as the crew vehicle for the Manned Orbital Laboratory. To this end, one of the unmanned Gemini spacecraft was refurbished and flown again atop a mockup of the MOL, sent into space by a Titan III-M. This was the first time a spacecraft went into space twice.

The USAF also had the notion of adapting the Gemini spacecraft for military applications, such as crude observation of the ground (no specialized reconnaissance camera could be carried) and practicing making rendezvous with suspicious satellites. This project was called Blue Gemini. The US Air Force did not like the fact that Gemini would have to be recovered by the US Navy, so they intended for Blue Gemini eventually to use the paraglider and land on three skids, something from the original design of Gemini.

At first some within NASA welcomed sharing of the cost with the USAF, but it was later agreed that NASA was better off operating Project Gemini by itself. MOL was cancelled in 1968 and Blue Gemini too was cancelled without any use by military astronauts.

Other proposals

Other Gemini derivatives were proposed, including Big Gemini, Gemini LOR, Gemini Lunar Lander, Gemini-Centaur, Gemini Ferry, Gemini Transport, Gemini - Saturn I, Gemini - Saturn IB, Gemini - Saturn V, Gemini Pecan, Extended Mission Gemini, Gemini - Double Transtage, Gemini Satellite Inspector, Gemini Lunar Surface Rescue Spacecraft, Gemini Observatory, Gemini Para glider, Rescue Gemini, Winged Gemini, Gemini LORV and Gemini Lunar Surface Survival Shelter.

See also

• National Aeronautics and Space Administration
• Titan (rocket family), including the Titan II rocket
• Big Gemini
• Blue Gemini
• Manned Orbital Laboratory
• Splashdown
• Agena Target Vehicle
• Timeline of hydrogen technologies

Further reading

• Francis French and Colin Burgess, In the Shadow of the Moon: A Challenging Journey to Tranquility, 1965-1969. History of the entire Gemini program.
• Gene Kranz, Failure is Not an Option. Factual, from the standpoint of a chief flight controller during the Mercury, Gemini, and Apollo space programs. ISBN 0-7432-0079-9
• David M. Harland, How NASA Learned to Fly in Space: An Exciting Account of the Gemini Missions, Apogee Books, 2004, ISBN 1-894959-07-8
• David J. Shayler, Gemini, Springer-Verlag Telos, 2001, ISBN 1-85233-405-3
• On the Shoulders of Titans: A History of Project Gemini - (NASA report SP-4203) (PDF format)
• Project Gemini - A Chronology (NASA report SP-4002) (PDF format)
• Gemini Midprogram Conference - Including Experiment Results (NASA report SP-121) - Manned Spacecraft Center - Houston, Texas, February 23-25, 1966
• Gemini Summary Conference (NASA report SP-138) - Manned Spacecraft Center - Houston, Texas, February 1-2, 1967

External links

• On the Shoulders of Titans: A History of Project Gemini by Barton C. Hacker and James M. Grimwood
• John F. Kennedy Space Center - The Gemini Program
• NASA Project Gemini site
• Space history: Gemini Program space history - Gemini missions spaceflight
• Project Gemini Drawings and Technical Diagrams
• Technical Diagrams and Drawings
• Gemini familiarization Manuals (PDF format).
• Gemini Designer Jim Chamberlin Bio
• Direct Flight Apollo Study: Gemini Spacecraft Applications : document on the proposed Gemini-based Apollo program.
• NASA History Series Publications (many of which are on-line)

Archival Materials:

• Project Gemini McDonnell Employee Video Interviews and Archival Documents: Western Historical Manuscripts Collection in St. Louis, Missouri