Jump to content

Short C-23 Sherpa

From Wikipedia, the free encyclopedia

This is an old revision of this page, as edited by EpicstormchaserSWF (talk | contribs) at 23:35, 4 October 2023 (→Aircraft on display). The present address (URL) is a permanent link to this revision, which may differ significantly from the current revision.

This article is about the cargo aircraft. For experimental research aircraft, see Short SB.4 Sherpa.

C-23 Sherpa
A US Army C-23A Sherpa over San Diego 2014
Role Transport aircraft
National origin United Kingdom
Manufacturer Short Brothers
First flight 6 August 1984
Introduction 1984
Retired Army National Guard 2014
Status In service
Primary users United States Army
United States Air Force
Produced 1984–1990
Developed from Short 330, Short 360

The Short C-23 Sherpa is a small military transport aircraft built by Short Brothers. It was designed to operate from unpaved runways and make short takeoff and landings (STOL).[1] It features a large squared fuselage with a full-width rear cargo door/ramp. The C-23A and C-23B are variants of the Short 330 and the C-23B+ is a variant of the Short 360.

Design and development

The Short 330 was developed by Short Brothers of Belfast from their earlier Short SC.7 Skyvan STOL utility transport. The 330 has a longer wingspan and fuselage than the Skyvan, while retaining the Skyvan's square shaped fuselage cross section, allowing it to carry up to 30 passengers while retaining good short field characteristics. The 330 entered commercial service in 1976.[2]

In addition to the passenger aircraft, Shorts also planned two freight versions. The Short 330-UTT (for Utility Tactical Transport) was a military transport version fitted with a strengthened cabin floor and paratroop doors,[3] which was sold in small numbers, primarily to Thailand, which purchased four. The Short Sherpa was a freighter fitted with a full-width rear cargo door/ramp. This version first flew on 23 December 1982,[3] with the first order for 18 aircraft being placed by the United States Air Force in March 1983. These aircraft were assigned to Military Airlift Command (MAC) for the European Distribution System Aircraft (EDSA) role, flying cargo and personnel between United States Air Forces in Europe (USAFE) air bases.[3]

The first C-23A for U.S. Air Force during its official rollout ceremony

The Sherpa's cabin is 6.5 ft (1.98 m) wide, 6.5 ft (1.98 m) high and 29 ft (8.84 m) long.[1] It offers a cargo volume of 1,230 cu ft (34.83 m3), with a cargo capacity of 8,000 lb (3,629 kg).[1] The Sherpa is also capable of operating from unpaved runways and making short takeoff and landings (STOL).[1]

In U.S. military service, the Short 330 was designated C-23A Sherpa. The C-23B Sherpa is similar to the C-23A, but with cabin windows.[4] The C-23B+ Short 360 derivative was created by replacing the rear fuselage of Short 360s obtained on the second-hand market with the twin tail and rear loading ramp of the Short Sherpa.

The C-23 was produced at the Short Brothers' facility in Belfast, Northern Ireland for the U.S. Department of Defense.[5]

Operational history

C-23A with aft cargo door down
A C-23 Sherpa in center front with a C-5 Galaxy in rear

U.S. Air Force

The C-23A Sherpa entered service with the United States Air Force in Europe in 1985[5] based at Zweibrücken Air Base. It continued in use in the EDSA role until November 1990 with the post-cold war force reductions.[6] All the Sherpas returned to the United States; three aircraft were transferred to the USAF Test Pilot School at Edwards AFB, eight aircraft went to the U.S. Army and the remaining seven to the U.S. Forest Service. The Test Pilot School's aircraft were retired in 1997.[6]

U.S. Army

The eight former USAF aircraft were used for test duties at different units; two were re-designated as JC-23A.[6]

The Army purchased four civil Short 330 aircraft to replace the DHC C-7 Caribou being used to support the Kwajalein Missile Range. These were not given a C-23 designation, and were retired in 1992.[6] In 1988, the Army ordered ten new-build Short 330s designated C-23B to replace the DHC C-7 Caribou used by the U.S. Army National Guard Aviation and Repair Activity Depots. In 1990, a further six were ordered.[6]

When the Army wanted 20 more C-23s in 1990 the production line had closed; second-hand Short 360 aircraft were purchased instead. Designated the C-23B+, these were modified from the original single tail to the twin-tail and cargo ramp of the other C-23Bs.[6] In 1994, another eight aircraft were converted to replace the DHC UV-18 Twin Otters used in Alaska.[6]

During Iraq War (2003–2011), the C-23 served the Army's intra-theater needs of cargo and personnel transport. It provided an economic alternative for transporting some 20 people or three pallets of cargo when speed was not critical.[7]

As part of the U.S. Army's Constant Hawk intelligence gathering program, five Short 360s were modified for use in Iraq and flew in theater between 2006 and 2011. A further two modified aircraft collided in mid-air before delivery to Iraq. The Constant Hawk aircraft were not given a military designation.[6]

On 13 June 2007, the Alenia C-27J was selected to replace the C-23 in U.S. Army service.[8][9] A total of 43 C-23s were in service with the U.S. Army as of November 2008 (all US C-27 aircraft were transferred to the US Coast Guard in 2012 due to budget shortfalls).[10] The C-23 Sherpa was retired from the Army National Guard in January 2014.[11] As part of the National Defense Authorization Act for Fiscal Year 2014, 8 C-23s may be transferred to the State of Alaska to operate from short rural runways for search-and-rescue and medium-lift missions.[12]

In December 2014, it was announced that US would supply eight aircraft to Estonia, Djibouti, and Philippines.[13][14]

Civilian and Army National Guard service

Alaska National Guard C-23 on an unimproved frozen runway in the Alaskan village of Anaktuvuk Pass to deliver medical supplies.

Several surplus aircraft were sold to United States operators,[15] who used them to transport equipment and crews to remote work sites. Others were used by Army National Guard units in the various states.

On 3 March 2001, a C-23B Sherpa belonging to the 171st Aviation Regiment of the Florida Army National Guard was carrying 18 construction workers of the Virginia Air National Guard from Hurlburt Field, Florida to Naval Air Station Oceana, Virginia. The pilot left the flight deck to use the aft bathroom. His weight in the tailcone shifted the center of gravity sufficiently that the airplane became unstable when a patch of severe turbulence was encountered. The violent g-force shifts then encountered rendered the crew unconscious and caused the breakup of the aircraft in flight near Unadilla, Georgia, killing the 21 persons on board.[16] Later calculations determined that the aircraft had been loaded outside its operating envelope at the start of the flight.

Variants

C-23A Sherpa
Twin-engine transport aircraft for the U.S. Air Force based on the Short 330-UTT; it was fitted with a strengthened cabin floor with a roller conveyor system, plus a forward cargo door on the port side of the fuselage, equipped with a hydraulically operated full-width rear cargo door/ramp; 18 built.
C-23B Sherpa
Twin-engine transport aircraft for the US Army National Guard, similar to the C-23A, but with cabin windows, stronger landing-gear, inward-opening paratroop doors at the rear of the fuselage and an air-operable two-section cargo ramp; 16 built.[6]
C-23B+ Super Sherpa
Short 360 aircraft purchased as used aircraft by the U.S. Army and modified by the West Virginia Air Center (WVAC) for the replacement of the rear fuselage of the Short 360, with its single tall fin, with the twin tail and rear loading ramp of the Short Sherpa.[17] 28 civil aircraft were modified.[6]
C-23C
Both C-23B and C-23B+ with flightdeck avionic upgrade under the "Avionics System Cockpit Upgrade" program, 43 modified.[6]
C-23D
C-23C with upgraded avionics under the "Safety Avionics Modification" program from 2010, program was cancelled and only four aircraft were modified.[6]

Operators

C-23B Sherpa in Iraq, 2004
Paratroopers on board a C-23 for training

 Philippines

 Brazil
 Djibouti
 United States

Civil operators

Former USAF and US Army aircraft have been sold to civil operators including:

 Philippines
 United States

Aircraft on display

United States

Specifications (C-23A)

3-view projection of the Short C23 Sherpa
A C-23A with an aircraft engine being unloaded
Unloading pallets of meals, ready to eat (MREs) from a C-23 Sherpa rear cargo door/ramp.

Data from Jane's All the World's Aircraft 1988–1989[3]

General characteristics

  • Crew: 3 (2 pilots plus 1 cabin crew)
  • Capacity: 30 passengers, or 18 Litter based passengers / 7,000 lb (3,175 kg) maximum payload
  • Length: 58 ft 0.5 in (17.691 m)
  • Wingspan: 74 ft 8 in (22.76 m)
  • Height: 16 ft 3 in (4.95 m)
  • Wing area: 453 sq ft (42.1 m2)
  • Airfoil: root: NACA 63A418; tip: NACA 63A414[21]
  • Empty weight: 14,727 lb (6,680 kg) including crew
  • Max takeoff weight: 22,900 lb (10,387 kg)
  • Maximum landing weight: 22,600 lb (10,251 kg)
  • Fuel capacity: 560 imp gal (670 US gal; 2,500 L) / 4,480 lb (2,032 kg)
  • Powerplant: 2 × Pratt & Whitney Canada PT6A-45-R turboprop engines, 1,198 shp (893 kW) each
  • Propellers: 5-bladed Hartzell, 9 ft 3 in (2.82 m) diameter constant-speed fully-feathering propeller

Performance

  • Cruise speed: 190 kn (220 mph, 350 km/h) ::::157 kn (181 mph; 291 km/h) at 21,000 lb (9,525 kg) AUW at 10,000 ft (3,048 m)
  • Stall speed: 73 kn (84 mph, 135 km/h) at MLW flaps and gear down
90 kn (104 mph; 167 km/h) flaps and gear up
  • Range: 195 nmi (224 mi, 361 km) with 7,000 lb (3,175 kg) payload, max fuel, reserves for 45 minute hold and 43 nmi (49 mi; 80 km) diversion
669 nmi (770 mi; 1,239 km) with 5,000 lb (2,268 kg) payload, max fuel, reserves for 45 minute hold and 43 nmi (49 mi; 80 km) diversion
  • Service ceiling: 12,900 ft (3,900 m) one engine inoperative at 21,000 lb (9,525 kg) AUW
  • Rate of climb: 1,180 ft/min (6.0 m/s)
  • Wing loading: 50.55 lb/sq ft (246.8 kg/m2)
  • Power/mass: 0.1046 shp/lb (0.1720 kW/kg) maximum
  • Take-off run (FAR & BCAR Gp.A): 3,420 ft (1,042 m) ISA
  • Take-off run (FAR & BCAR Gp.A): 3,420 ft (1,042 m) ISA +15 °C (59 °F)
  • Landing run at MLW BCAR: 4,020 ft (1,225 m) normal field
  • Landing run at MLW BCAR: 3,150 ft (960 m) short field
  • Landing run at MLW FAR: 3,650 ft (1,113 m)

See also

Related development

Aircraft of comparable role, configuration, and era

References

  1. ^ a b c d "Aircraft profile: Short Brothers' C-23 Sherpa | Air Forces Monthly". Archived from the original on 25 December 2018. Retrieved 25 December 2018.
  2. ^ Donald, David, ed. (1997). The Encyclopedia of World Aircraft. Aerospace Publishing. p. 838. ISBN 1-85605-375-X.
  3. ^ a b c d Taylor, JWR, ed. (1988). Jane's All the World's Aircraft, 1988–1989. Jane's Information Group. pp. 304–306. ISBN 0-7106-0867-5.
  4. ^ Donald, David; Lake, John, eds. (1996). Encyclopedia of World Military Aircraft (Single Volume ed.). London: Aerospace Publishing. p. 384. ISBN 1-874023-95-6.
  5. ^ a b "C-23 Sherpa". Archived from the original on 19 October 2007. Retrieved 21 August 2007.
  6. ^ a b c d e f g h i j k l m n o p q r "Whatever happened to .. C-23 Sherpa". Scramble Magazine. No. 427. Dutch Aviation Society. December 2014. pp. 150–157. ISSN 0927-3417.
  7. ^ "C-23: A Small Cargo Plane that Makes a Big Difference" Archived 13 October 2017 at the Wayback Machine, Military.com, 9 February 2004.
  8. ^ "C-27J Spartan named as Joint Cargo Aircraft". Air Force Link. 14 June 2007. Archived from the original on 26 May 2012. Retrieved 17 June 2007.
  9. ^ "C-27J tapped for Joint Cargo Aircraft". Air Force Times. 14 June 2007. Archived from the original on 14 August 2007. Retrieved 17 June 2007.
  10. ^ "Directory: World Air Forces", Flight International, 11–17 November 2008.
  11. ^ C-23 Sherpa makes final flight as Army Guard retires the venerable aircraft Archived 10 January 2014 at the Wayback Machine – Dvidshub.net, 10 January 2014
  12. ^ The Final Army Flight of the C-23 Sherpa Archived 3 February 2014 at the Wayback Machine – Defensemedianetwork.com, 27 January 2014
  13. ^ "Estonia to replace Soviet-era An-2 aircraft with US-supplied Sherpas - IHS Jane's 360". Archived from the original on 3 January 2015. Retrieved 19 December 2014.
  14. ^ "USA kingib Eestile kaks transpordilennukit – Eesti uudised – Postimees.ee". Archived from the original on 19 December 2014. Retrieved 19 December 2014.
  15. ^ "SHORTS Turboprop Aircraft For Sale". Controller.com. Archived from the original on 13 August 2016. Retrieved 5 July 2017.
  16. ^ Veillette Ph.D., Patrick (26 May 2016). "Weighty Matters: Miscalculation when loading can have unwelcome consequences". Aviation Week Network. Archived from the original on 13 October 2017. Retrieved 5 July 2017.
  17. ^ "C-23 Sherpa". GlobalSecurity.org. Archived from the original on 15 August 2007. Retrieved 5 July 2017.
  18. ^ Orpiano, Pitz (26 June 2022). "The Donated SD3-30 (C-23) Sherpa Aircraft of the Philippine Army". Pitz Defense Analysis. Retrieved 25 March 2023.
  19. ^ "O Retorno dos Aviões ao EB: Projeto de Incorporação dos 6 C-23B Sherpa da AVEx". 3 June 2018.
  20. ^ "C-23 Sherpa." Archived 27 April 2017 at the Wayback Machine NASA Airborne Science Program. Retrieved: 26 May 2017.
  21. ^ Lednicer, David. "The Incomplete Guide to Airfoil Usage". m-selig.ae.illinois.edu. Retrieved 16 April 2019.
Wikimedia Commons has media related to C-23 Sherpa.
Retrieved from "https://en.wikipedia.org/w/index.php?title=Short_C-23_Sherpa&oldid=1178641145"