Boeing 727

Boeing 727
Syrian Air Boeing 727-269/Adv
Role	Airliner
National origin	United States
Manufacturer	Boeing Commercial Airplanes
First flight	February 9, 1963
Introduction	February 1, 1964 with United Airlines
Primary users	FedEx Express Astar Air Cargo
Produced	1963–1984
Number built	1,832

The Boeing 727 is a mid-size, narrow-body, three-engine, T-tailed commercial jet airliner. The 727's fuselage has an outer diameter of 148 inches (3.8 m). This allows six-abreast seating (three per side) and a single central access walkway when coach-class (18 inch width) seats are installed.

The first Boeing 727 flew in 1963 and for over a decade it was the most produced commercial jet airliner in the world. A total of 1,831 727s were delivered. The 727's sales record for the most jet airliners ever sold was broken in the early 1990s by its younger stablemate, the Boeing 737. In August 2008, there were a total of 81 Boeing 727-100 aircraft and 419 727-200 aircraft in airline service.

Design and development

The 727 design arose as a compromise between United Airlines, American Airlines, and Eastern Air Lines requirements over the configuration of a jet airliner to service smaller cities which often had shorter runways and correspondingly smaller passenger demand. United Airlines wanted a four-engined aircraft for its flights to high-altitude airports, especially its hub at Stapleton International Airport at Denver, Colorado. American, which was operating the four-engined Boeing 707 and 720, wanted a twin-engined aircraft for efficiency reasons. Eastern wanted a third engine for its overwater flights to the Caribbean, since at that time twin-engined commercial flights were limited by regulations to routes with 60-minute maximum flying time to an airport (see ETOPS/LROPS). Eventually, the three airlines agreed on a trijet, and thus the 727 was born. The third JT8D engine, which is located at the very rear of the fuselage (called engine 2), is supplied with air from an inlet at the front of the vertical fin through an S-shaped duct to the engine's inlet. The 727 featured high-lift devices on its wing, thus being one of the first jets able to operate from relatively short runways. Later models of the 727 were stretched to accommodate more passengers and they ended up replacing earlier jet airliners, such as the Boeing 707 and Douglas DC-8, on domestic routes.

Lloyd Aereo Boliviano 727-200 at Jorge Wilsterman Airport. The rear air stairs are visible at the tail ot the plane.

The 727 proved to be such a reliable and versatile airliner that it came to form the core of many start-up airlines' fleets. The 727 was successful with airlines worldwide partly because of its capability to use smaller runways while still flying medium range routes. This effectively allowed airlines to attract passengers from cities with large populations but smaller airports to worldwide tourist destinations. One of the features that gave the 727 its ability to land on shorter runways was its unique wing design. Due to the absence of wing-mounted engines, leading-edge lift enhancement equipment (Krueger, or hinged, flaps on the inner portion of the leading edge, and extendable leading-edge slats on the remainder of the leading edge), and trailing-edge lift enhancement equipment (triple-slotted, aft-moving flaps) could be used on the entire wing. The combination of these high-lift devices produced a maximum wing lift coefficient of 3.6 (based on the flap-retracted wing area). Thus the 727 could fly with great stability at very low speeds compared to other early jets. The 727 also had nosegear brakes fitted in the beginning to further decrease braking distance upon landing. However, these were soon removed from service, as they provided little useful reduction in braking distances, while adding weight and increasing maintenance requirements.

The 727 was designed to be used at smaller, regional airports, so independence from ground facilities was an important requirement. This gave rise to one of the 727's most distinctive features: the built-in airstair that opens from the rear underbelly of the fuselage. D. B. Cooper, a hijacker, parachuted from the back of a 727 as it was flying over the Pacific Northwest. Boeing subsequently modified the design with the Cooper vane so that the airstair could not be lowered in flight. Another innovation was the inclusion of an APU (auxiliary power unit), which allowed electrical and air-conditioning systems to run independent of a ground-based power supply, without having to start one of the main engines. The 727 can also back itself up, thus not requiring the push tractor needed for most other jet airliners to leave an airport gate. The 727 is equipped with a retractable tail skid which is designed to protect the aircraft in the event of an over-rotation on takeoff.

DHL Boeing 727-200F freighter at San Diego

Noise

The 727 is a stage II aircraft, making it one of the world's loudest commercial jetliners (the US Noise Control Act of 1972, 42USC 4901-4918, mandated the gradual introduction of quieter stages of aircraft, with the first introduction to be called Stage 3 airplanes. Aircraft which did not meet the ground-perceived noise levels specified for Stage 3 would be called Stage 2). The 727's JT8D jet engines use older low-bypass turbofan technology while Stage 3 aircraft utilize the more efficient and quieter high-bypass turbofan design. When the Stage 3 requirement was being proposed, Boeing engineers analyzed the possibility of incorporating quieter engines on the 727. They determined that the JT8D-200 engine could be used on the two side-mounted pylons, but the structural work required to fit the larger-diameter engine (49.2 inch fan diameter in the JT8D-200 vs. 39.9 inches in the JT8D-7) into the fuselage structure at the engine 2 location would be too great to be justifiable. Since the quieter engine could not be used in all three sites, the 727 could not be made into a Stage 3 aircraft.

At the turn of the 21st century, the 727 was still in service with a few airline fleets. However, because in the meantime the U.S. FAA and the ICAO had changed their requirements for overwater operations, most major airlines had already begun to switch to twinjets, aircraft with only two engines, which are more fuel-efficient and quieter than the three-engined 727. Also, the 727 was one of the last airliners in service to have a three-person flight crew, including a flight engineer, a crew member whose job is performed by computerized systems on newer planes.

If a 727 is used in commercial service at present, it must be retrofitted with hush kits to reduce engine noise to Stage 3 level. One such hushkit is offered by FedEx, and this kit has been purchased by over 50 customers. After market winglets have been installed on many 727s as a means of noise reduction as part of so called "Quiet Wing" Kits and for added fuel economy. Kelowna Flightcraft's maintenance division in Canada has installed winglets on Donald Trump's private 727-100. He owns one example of the aircraft.

Interior close-up photo of the pilot and co-pilot area of a flight simulator for a Boeing 727 at the Pan Am International Flight Academy

Operational history

In addition to domestic flights of medium range, the 727 was popular with international passenger airlines. The range of flights it could cover (and the additional safety added by the third engine) meant that the 727 proved efficient for short to medium range international flights in areas around the world. Prior to its introduction, four-engined jets or propeller-driven airliners were required for transoceanic service.

The 727 also proved popular with cargo airlines and charter airlines. FedEx Express introduced 727s in 1978. 727s were the backbone of its fleet until recently, but FedEx is now phasing them out in favor of the Boeing 757. Many cargo airlines worldwide now employ the 727 as a workhorse, since as it is being phased out of U.S. domestic service due to noise regulations, it becomes available to overseas users in areas where such noise regulations have not yet been instituted. Charter airlines Sun Country, Champion Air, and Ryan International Airlines were all started with 727 aircraft.

Yet another situation where the 727 has proven to be popular is in situations where the airline services airports with gravel, or otherwise lightly improved runways. The Canadian airline First Air, for example, uses a 727-200C to service the communities of Resolute Bay and Arctic Bay in Nunavut, both of which have gravel runways. The high mounted engines greatly reduces the risk of foreign object damage.

Other companies use the 727 as a way to transport passengers to their resorts or cruise ships. Such was the example of Carnival Cruise Lines, which used both the 727 and 737 to fly both regular flights and flights to transport their passengers to cities that harbored their ships. Carnival used the jets on its airline division, Carnival Air Lines.

Faced with higher fuel costs (although all major United States airlines phased them out immediately prior to the oil price increases since 2003), lower passenger volumes due to the post-9/11 economic climate, increasing restrictions on airport noise, and the extra expenses of maintaining older planes and paying flight engineers' salaries, most major airlines have phased 727s out of their fleets. Delta Air Lines, the last major U.S. carrier to do so, retired its last 727 in March, 2003. However, the 727 is still flying for smaller start-up airlines, cargo airlines, and charter airlines, and it is also sometimes used as a private means of transportation. The official replacement for the 727 in Boeing's lineup was the Boeing 757. However, the smallest 757 variant, the 757-200, is significantly larger than the 727-200, so many airlines replaced their 727s with either the 737-800 or EADS' Airbus A320, both of which are closer in size to the 727-200.

Variants

File:N4734-727-PanAm-LHR-May90.jpg

Pan Am 727-200

There are two variants of the 727. The 727-100 was launched in 1960 and placed into service in February 1964. The 727-200 was launched in 1965 and placed into service in December 1967.

727-100

The first production model.

727-100C

Convertible passenger cargo version. Additional freight door and strengthened floor and floor beams. Three alternate fits:

• 94 mixed-class passengers
• 52 mixed class passengers and four cargo pallets (22,700lb (10297kg))
• Eight cargo pallets (38,000lb (17237kg))

727-100QC

QC stands for Quick Change. This is similar to the Convertible version with a roller-bearing floor for palletised galley and seating and/or cargo to allow much faster changeover time (30 minutes).

727-100QF

QF stands for Quiet Freighter. A cargo conversion for United Parcel Service, re-engined with Stage III-compliant Rolls-Royce Tay turbofans.

727-200

File:SRQ 9-15 007.jpg

Delta Air Lines 727-200.

Stretched version of the 727-100. The -200 is 20 feet (6.1 m) longer (153 feet, 2 inches) than the -100 (133 feet, 2 inches). A ten foot fuselage section was added in front of the wings and another ten foot fuselage section was added behind them. The wing span and height remain the same on both the -100 and -200 (108 feet and 34 feet (10 m), respectively). The gross weight was increased from 169,000 to 209,500 pounds.

The dorsal intake of the number 2 engine was also redesigned to be round in shape, as opposed to oval as it was on the 100 series.

Advanced 727-200

MTOW and range increased. Also, Cabin improvements

Advanced 727-200F

All freight version of the 727-200.

Super 27

Speed increased by 50 mph (80 km/h), due to replacement of the two side engines with the JT8D-217, which are also found on many MD-80s, and addition of hush kits to the center engine. These aftermarket modifications were performed by companies independent of Boeing, such as Valsan and Dee Howard.

Operators

Major airlines that have flown the jet include Aerocontinente, AeroGal, AeroSur, Aerolíneas Argentinas, Aerolíneas Internacionales, Aeroperu, Air Algerie, Air Canada, Air France, Air Jamaica, Air Panama, Allegheny Airlines, ANA, Air Vanuatu, Alaska Airlines, Alitalia, American, ATA Airlines, Ansett Australia, Australian Airlines/taa - later Qantas Domestic, ASTAR, Avensa, Avianca, Aviacsa, Braniff International, Chanchangi Airlines, Nigeria, China Airlines, Continental Airlines, Continental Micronesia, Copa, CP Air, Dan-Air Services, Delta Air Lines, Dominicana, Eastern Air Lines, FedEx Express, First Air, Hughes Airwest, Iberia, Iran Air, Japan Airlines, JAT, Kiwi International Air Lines, Korean Air, Lloyd Aereo Boliviano, Lufthansa, Mexicana, MGM Grand,MIAT Mongolian Airlines, LACSA, LaNica Nicaraguan Airlines, Northeast Airlines, Northwest Airlines, Olympic Airways, Pacific Southwest Airlines, Paramountjet, Pan Am, People Express, Philippine Airlines, Piedmont Airlines, Pride Air, Republic Airlines (1979-1986), Royal Air Maroc, Sabena,Sabre Airways, Singapore Airlines, South African Airways, Southwest Airlines, Sterling, TAA,TAME,TAP Portugal Transbrasil, Tunisair, TWA, United Airlines,UPS, US Airways, Varig, VASP, Viasa, and Western Airlines. Also the 727 has been operated by charter airlines such as Carnival Air Lines and Hapag-Lloyd.

In August 2008, a total of 500 Boeing 727 aircraft (all variants) were in airline service with FedEx Express (86), Astar Air Cargo (25), Champion Air (16), Kitty Hawk Aircargo (16), Capital Cargo International Airlines (13), Cargojet Airways (12), Kelowna Flightcraft Air Charter (13), Libyan Arab Airlines (10), Transmile Air Services (5) and other operators with fewer aircraft.

Zero-Gravity Corporation uses a modified Boeing 727 to give paying customers a brief experience of weightlessness, similar to NASA's Vomit Comet that is used to train astronauts.

The 727 carries the distinction of being one of the two planes used by all six US legacy carriers, the other being the Boeing 757.

Government Agencies and Military Operators

In addition, the 727 has seen sporadic government use, having flown for the Belgian, Yugoslavian, Mexican, New Zealand and Panama air forces, among the small group of government agencies that have used it. The United States military used the 727 as a military transport, designated as the C-22. The 727 that carried New Zealand Prime Minister Jim Bolger was known as Spud One. The New Zealand Air Force 727s have since been replaced by 757s.

Belgium

• Belgian Air Force (Two operated from 1975) (Replaced by two Airbus A310)

Mexico

• Mexican Air Force
• Federal Preventive Police

Ecuador

• Ecuadorian Air Force

Panama

• Panamanian Air Force until 1989

Yugoslavia

• SFR Yugoslav Air Force

Accidents and incidents

As of 2007, a total of 282 incidents involving 727s had occurred, including 106 hull-loss accidents resulting in a total of 3,703 fatalities. The 727 has also been in 178 hijackings involving 256 fatalities.

Notable accidents

• On August 16, 1965, a new Boeing 727-22, United Airlines Flight 389, crashed into Lake Michigan 30 miles east northeast of Chicago's O'Hare Airport. The crew were told to descend and maintain 6,000 feet, which was the last radio communication with the flight. The NTSB was not able to determine why the airliner continued its descent into the water.
• On November 11, 1965 a United Airlines Boeing 727-100 departed New York-LaGuardia for a flight to San Francisco via Cleveland, Chicago, Denver, and Salt Lake City. Flight 227 crashed on landing at Salt Lake International Airport, causing the deaths of 43 of the 91 people on board.
• In 1971, an Alaska Airlines Boeing 727-100 operating as flight 1866 crashed into a mountain while on approach to Juneau, Alaska. The cause included the crew's receiving misleading navigational information. All seven crew members and 104 passengers were killed.
• In 1971, passenger D. B. Cooper hijacked Northwest Airlines Flight 305 while it was en route from Portland, Oregon to Seattle, Washington. After receiving a payment of $200,000 and 4 parachutes when he was in Seattle, he told the pilots to fly to Mexico, and jumped out of the aircraft from the aft airstairs over Washington or Oregon. Cooper's fate is unknown as of 2008.
• In 1972, during an attempted coup d'état, jets from the Royal Moroccan Air Force fired upon the Boeing 727 of King Hassan II of Morocco while he was traveling to Rabat. After the aircraft survived the attack, the king awarded the plane a medal of honor.
• In 1973, on February 21, a Libyan Arab Airlines Flight 114 Boeing 727-200 flying over the Sinai Desert was shot by Israeli air forces that suspected it of being an enemy military plane. Of 113 people on board, 108 died.
• On December 1, 1974, a TWA Boeing 727-200 (registration N54328), operating as Flight 514, crashed on Mount Weather while flying from Indianapolis, Indiana, and Columbus, Ohio, to Washington Dulles International Airport in turbulent weather. All 85 passengers and 7 crewmembers aboard were killed.
• In 1975, Eastern Air Lines Flight 66 crashed on approach for John F. Kennedy International Airport. 112 people died.It was the worst air disaster in the United States at the time.The cause was a microburst.
• On November 19, 1977, TAP Portugal Flight 425 overran the runway at Madeira Airport and plunged over a steep bank, bursting into flames and killing 131 of the 164 people on board.
• On September 25, 1978, PSA Flight 182, a Pacific Southwest Airlines Boeing 727, crashed after colliding with a Cessna 172 aircraft in San Diego, killing 144 people.
• In 1980, a Dan-Air Boeing 727-46 crashed in Tenerife. All on board were killed when the aircraft hit terrain while circling.
• In 1982, VASP Flight 168, a Boeing 727-200A, a scheduled passenger flight from Rio de Janeiro, Brazil to Fortaleza crashed into a hillside on final approach to Fortaleza, killing all 137 people on board.
• In 1985, an Iberia Boeing 727 crashed after striking a television antenna while landing in Bilbao, killing 148 people.
• In 1996, 143 people were killed when an ADC Boeing 727 went down near Ejirin, Nigeria, losing control after taking evasive action to avoid a midair collision.
• On May 25, 2003, a 727 registration number N844AA, formerly used by American Airlines, was stolen from Luanda's international airport in Angola. The mechanic who was on the plane, Ben Charles Padilla, has never been heard from again.

Specifications

Measurement	727-100	727-200
Max seating capacity	149	189
Cockpit crew	Three
Length	133 ft 2 in (40.6 m)	153 ft 2 in (46.7 m)
Span	108 ft (32.9 m)
Height	34 ft (10.3 m)
Zero fuel weight	100,000 lb (45,360 kg)
Maximum take-off weight	169,000 lb (76,818 kg)	209,500 lb (95,028 kg)
Maximum landing weight	137,500 lb (62,400 kg)	161,000 lb (73,100 kg)
Take-off runway length (at 148,000 lb)	5,800 ft (1,768 m)
Landing runway length (at max landing wt)	4,800 ft (1,463 m)	5,080 ft (1,585 m)
Cruising speed	.81 Mach
Maximum speed	.90 Mach
Range fully loaded	2700 NM (5000 km)	2400 NM (4450 km)
Max. fuel capacity	8,186 US gal (31,000 L)	9,806 US gal (37,020 L)
Engines (3x)	P&W JT8D-7, -17R&S

Sources: Boeing 727 Specifications, Boeing 727 Airport report

Orders and deliveries

Orders

1983	1982	1981	1980	1979	1978	1977	1976	1975	1974	1973	1972
1	11	38	68	98	125	133	113	50	88	92	119
1971	1970	1969	1968	1967	1966	1965	1964	1963	1962	1961	1960
26	48	64	66	125	149	187	83	20	10	37	80

Deliveries

1984	1983	1982	1981	1980	1979	1978	1977	1976	1975	1974	1973
8	11	26	94	131	136	118	67	61	91	91	92
1972	1971	1970	1969	1968	1967	1966	1965	1964	1963	1962	1961
41	33	55	114	160	155	135	111	95	6	0	0

See also

• Trijet

Related development

• Boeing C-22
• Boeing 707
• Boeing 737

Aircraft of comparable role, configuration, and era

• Airbus A320
• Boeing 757
• Hawker Siddeley Trident
• McDonnell Douglas MD-80
• McDonnell Douglas MD-90
• Tupolev Tu-154

Related lists

• List of airliners

External links

• Boeing.com 727 Family
• 727 Prototype
• 727 Datacenter - Brazilian site
• Boeing-727.com
• Aircraft-Info.net - Boeing 727-100
• Aircraft-Info.net - Boeing 727-200
• Airsafe.com Fatal Boeing 727 Events