NATO reporting name: SA-19 Grison
9K22 "Tunguska-M" Gun/Missile Air Defence System.
|Type||Tracked SPAAW system|
|Place of origin||Soviet Union
|Wars||2008 South Ossetia war|
|Designer||KBP Instrument Design Bureau|
|Manufacturer||Ulyanovsk Mechanical Factory|
|Unit cost||$16 million |
|Variants||9K22 (Tunguska), 9K22M (Tunguska-M), 2K22M1 (Tunguska-M1)|
|Weight||about 35,000 kg (77,000 lb)|
|Length||about 7.90 m (25 ft 11 in)|
|Width||about 3.25 m (10 ft 8 in)|
|Height||about 4 m (13 ft 1 in) or about 3.35 m (10 ft) (radar stowed)|
|Crew||4 (vehicle commander, driver, gunner, radar operator)|
|Armour||protects the vehicle from 7.62 mm small arms fire and shell splinters|
|8 × 9M311, 9M311K, 9M311-1, 9M311M, 9M311-M1 or 57E6 missiles|
2 × 30 mm 2А38Mguns (1,904 rounds carried)
|Engine||V-46-6-MS centrifugal turbocharged V-12 direct fuel injection rotating at 2,000 rpm water cooled 4-stroke multi-fuel diesel starts at up to −5 °C functions at −40 to 50 °C with a relative humidity of 98 per cent by 20 °C and up to 3,000 m altitude
780 hp without input and output resistance
840 hp maximum
|Ground clearance||17–57 cm|
|500 km (310 mi)|
|Speed||65 km/h (40 mph) maximum on the road|
The 2K22 Tunguska (Russian: 2К22 "Тунгуска"; English: Tunguska) is a Russian tracked self-propelled anti-aircraft weapon armed with a surface-to-air gun and missile system. It is designed to provide day and night protection for infantry and tank regiments against low-flying aircraft, helicopters, and cruise missiles in all weather conditions. Its NATO reporting name is SA-19 "Grison".
Development of the 2K22 anti-aircraft system began on 8 June 1970. At the request of the Soviet Ministry of Defence, the KBP Instrument Design Bureau in Tula, under the guidance of the appointed Chief Designer A. G. Shipunov, started work on a 30mm anti-aircraft system as a replacement for the 23mm ZSU-23-4.
The project, code-named "Tunguska", was undertaken to improve on the observed shortcomings of the ZSU-23-4 (short range and no early warning) and a counter to new ground attack aircraft in development, such as the A-10 Thunderbolt II, which was designed to be highly resistant to 23 mm cannons. Studies were conducted and demonstrated that a 30 mm cannon would require from a third to a half of the number of shells that the 23 mm cannon of the ZSU-23-4 would need to destroy a given target, and that firing at a MiG-17 (or similarly at, in case of war, NATO's Hawker Hunter or Fiat G.91) flying at 300 m/s, with an identical mass of 30 mm projectiles would result in a kill probability 1.5 times greater than with 23 mm projectiles. An increase in the maximum engagement altitude from 2,000 to 4,000 m and increased effectiveness when engaging lightly armoured ground targets were also cited.
The initial requirements set for the system were to achieve twice the performance in terms of range, altitude and combat effectiveness of the ZSU-23-4, additionally the system should have a reaction time no greater than 10 seconds. Due to the similarities in the fire control of artillery and missiles, it was decided that the Tunguska would be a combined gun and missile system. A combined system is more effective than the ZSU-23-4, engaging targets at long-range with missiles, and shorter range targets with guns.
In addition to KBP as the primary contractor, other members of the Soviet military-industrial complex were involved in the project; the chassis was developed at the Minsk tractor factory, the radio equipment at the Ulyanovsk Mechanical Factory, central computer at NIEMI ("Antey"), guidance and navigational systems by VNII "Signal", and optics were developed by the Leningrad Optical Mechanical Association (LOMO).
However, development was slowed between 1975 and 1977 after the introduction of the 9K33 Osa missile system, which seemed to fill the same requirement but with greater missile performance. After some considerable debate, it was felt that a purely missile-based system would not be as effective at dealing with very low flying attack helicopters attacking at short range with no warning as had been proven so successful in the 1973 Arab-Israeli War. Since the reaction time of a gun system is around 8–10 seconds, compared to approximately 30 seconds for a missile-based system, development was restarted.
The initial designs were completed in 1973, with pilot production completed in 1976 at the Ulyanovsk Mechanical Factory. System testing and trials were conducted between September 1980 and December 1981 on the Donguzskiy range. It was officially accepted into service on 8 September 1982 and the initial version, which was designated 2K22/2S6, had four missiles in the ready to fire position (two on each side). The Tunguska entered into limited service from 1984, when the first batteries were delivered to the army.
After a limited production run of the original 2K22, an improved version designated 2K22M/2S6M entered service in 1990. The 2K22M featured several improvements with eight ready-to-fire missiles (four on each side) as well as modifications to the fire control programs, missiles and the general reliability of the system.
Tunguska underwent further improvement when, in 2003, the Russian armed forces accepted the Tunguska-M1 or 2K22M1 into service. The M1 introduced the new 9M311-M1 missile, which made a number of changes allowing the 2K22M1 to engage small targets like cruise missiles by replacing the eight-beam laser proximity fuze with a radio fuse. An additional modification afforded greater resistance to infrared countermeasures by replacing the missile tracking flare with a pulsed IR beacon. Other improvements included an increased missile range from 8 to 10 km, improved optical tracking and accuracy, improved fire control co-ordination between components of a battery and the command post. Overall, the Tunguska-M1 has a combat efficiency 1.3–1.5 times greater than the Tunguska-M.
The Tunguska family was until recently a unique and highly competitive weapons system, though in 2007 the Pantsir gun and missile system entered production at KBP—a descendant of the Tunguska, the Pantsir system offers even greater performance than its predecessor.
The GRAU index lists the "Tunguska" system as 2K22, although the army designation 9K22 is also a valid reference. A complete system or battery consists of six 2S6 combat vehicles armed with the 9M311 "Treugol'nik" (triangle) surface-to-air missile and two 2A38 30 mm cannons. These are accompanied by up to three 2F77 transloader trucks. The 2K22 is also associated with a variety of support facilities including the 2F55, 1R10 and 2V110 repair and maintenance vehicles, the MTO-AGZ workshop and the 9V921 test vehicle and others. These facilities provide maintenance for the 2K22 battery in the field as well as scheduled overhauls. Each system can attack six targets simultaneously (1 for each machine 2S6) limited in height of 3.5 km and a height of from −9 (gun)/−10(rocket) to +87 degrees. Minimum height of defeat 0 meters for guns and rockets to 15 meters (original 2K22).
The 2S6 combat vehicle uses the GM-352 and later GM-352M chassis developed and produced by the Minsk Tractor Plant (MTZ) which has six road wheels with hydropneumatic suspension on each side, a drive sprocket at the rear and three return rollers. An NBC system is also integrated into the chassis, which is protected -as the entire vehicle- from small arms fire (7,62) and shell splinters by the armor, as well as an automatic fire suppression system, an automatic gear change and diagnostic capability are available with latest Tunguska-M1 which uses the new GM-5975 chassis developed and produced by MMZ. GM-5975.25 has a cruising range of 500 km and a maximum speed of 65 km per hour. It can function at a relative humidity of 98 per cent at 35 degrees C, in ambient temperatures of −50 degrees C to 50 degrees C and up to an altitude of 3,000 m. It has an ability of climb up to 35 degrees, can cross slopes of 25 degrees, 2 m width ditch, 1 m depth ford. Overall, the layout is similar to the previous ZSU-23-4 with a large central 360-degree rotating turret (designated the 2A40) containing the armament, sensors and three of the crew: the commander, gunner and radar operator. The driver sits in the front left of the hull, with a gas turbine APU to his right and the multi-fuel diesel engine in the rear of the hull.
An electromechanically scanned parabolic E-band (10 kW power) target acquisition radar is mounted on the rear top of the turret that when combined with the turret front mounted J-band (150 kW power) monopulse tracking radar forms the 1RL144 (NATO:Hot Shot) radar system, which can detect and track targets flying high as 3,500 m. Alongside the 1A26 digital computer and the 1G30 angle measurement system form the 1A27 radar complex. Tunguska-M has the 1RL144M radar with detection range 18 km and tracking range 16 km-near of the original system's. The mechanically scanned target acquisition radar for the Tunguska-M1 offers a 360-degree field of view, a detection range of around 18 km and can detect targets flying as low as 15 m, the target acquisition radar can be stowed when in transit. Its tracking radar has a range of 16 km. A C/D-band IFF system is also fitted and designated 1RL138. The radar system is highly protected against various types of interference, and can work if there are mountains on the horizon, regardless of the background. The system is able to fire on the move using 30 mm cannons, although it must be stationary to fire missiles. The maximum target speed can be up to 500 m/s; reaction time 6–8 seconds. Each 2S6 has all facilities for independent warfare.
Standard equipment of the 2S6 and 2S6M includes a computerized fire control system, heating, ventilation, NBC system, an automatic fire detection and suppression system, navigational equipment, night vision aids, 1V116 intercom, external communications system with an R-173 receiver -modernized in the 2S6M for better communication with the command post- and monitoring equipment. The vehicle also has protection against the effects of nuclear, biological and chemical weapons.
A battery of six Tunguska can automatically receive fire control information via an encrypted radio link, this allows targets to be distributed between individual units from a Ranzhir or PPRU battery command post, which can receive target information from either AWACS or early warning radar or in the case of the PPRU its own radar equipment.
- 2K22: Original system, with 9M311, 9M311K (3M87) or 9M311-1 missiles with a range of 8 km. Some of these early versions of the "Tunguska" system were known as "Treugol'nik" (Russian Треугольник—triangle). This system is mounted on the 2S6 integrated air defence vehicle.
- 2K22M (1990): Main production system, with 9M311M (3M88) missiles. This integrated air defence vehicle 2S6M is based on the GM-352M chassis. 2F77M transporter-loader. 2F55-1, 1R10-1 and 2V110-1 repair and maintenance vehicles.
- 2K22M1 (2003): Improved version with the 2S6M1 combat vehicle on a GM-5975 chassis, using the 9M311-M1 missile (range: 10 km) and with an improved fire control system. Passed state trials and entered service with the Russian armed forces on 31 July 2003.
- 2K22M with 57E6: Complete upgrade of system with new 57E6 missile and new radar system, with detection range of 38 km and a tracking range of 30 km. Missile range is increased to 18 km.
The dual 2 2А38 30 mm cannons (as well as the later 2A38M) were designed by the KBP Instrument Design Bureau and manufactured by the Tulamashzavod Joint Stock Company. The cannons are fired alternatively with a combined rate of fire of between 3,900 and 5,000 rounds per minute (1,950 to 2,500 rpm for each gun), and have a muzzle velocity of 960 m/s. Bursts of between 83 and 250 rounds are fired as determined by the target type, with an engagement range between 0.2 and 4.0 km and to an altitude of about 3 km. HE-T and HE-I shells are used and fitted with a A-670 time and impact fuze which includes an arming delay and self destruct mechanism. Sources vary on elevation capabilities (one estimate gives +85 to −9 degrees, while another +87 to −10 degrees), though this range allows the system to engage ground as well as aerial targets. The 2K22 can fire its cannons in two primary modes of operation, radar and optical. In radar mode, the target tracking is fully automatic, with the guns aimed using data from the radar. In optical mode, the gunner tracks the target through the 1A29 stabilized sight, with the radar providing range data. The 2K22 is reported to have a kill probability of 0.8 with cannon. The height of defeat for guns is 0–2000 meters—for missiles 10–3500 meters.
The system is able to fire on the move using 30 mm cannons, although it must be stationary to fire missiles, the maximum target speed can be up to 500 m/s, reaction time 6–8 seconds. Each 2S6 has all facilities for independent warfare.
|Place of origin||Soviet Union|
|Used by||Belarus, India, Morocco, Syria, Russia, former Soviet Union, Ukraine|
|Designer||KBP Instrument Design Bureau|
|Variants||9M311, 9M311K, 9M311-1, 9M311M, 9M311-M1, 57E6|
|Warhead||Continuous-rod and steel cubes|
|Warhead weight||9 kg|
|Laser fuze (Radio fuze for 9M311-M1)|
|8 kilometres (5.0 mi) (10 kilometres (6.2 mi) 9M311-M1)|
|Flight ceiling||3,500 metres (11,500 ft)|
|Boost time||2 stages: boost to 900 m/s, then sustained 600 m/s stage to range|
|Speed||900 m/s maximum|
|Radio Command guidance|
|rocket motor with four steerable control surfaces|
|2S6 combat vehicle|
The system uses the same 9M311 (NATO: SA-19/SA-N-11) missile family as the naval CIWS Kashtan which can engage targets at a range of 1.5–8 km and to an altitude of 5 m to 3.5 km, the Tunguska-M1 uses the improved 9M311-M1 missile with an increased range of 2.5–10 km and an altitude of 15 m – 3.5 km. The missile has two stages, a large booster stage with four folding fins, which boosts the missile to a velocity of 900 m/s, before falling away. The second stage has four fixed fins, and four steerable control surfaces. The complete missile is around 2.56 meters long with a weight of 57 kg.
Guidance is performed by the target tracking radar, it constantly relays target range, elevation and bearing to the fire-control computer, and on the basis of this data the computer generates the laying commands for the guns or the trajectory corrections for the missiles. A back-up tracking method can be used by the gunner, who uses the 8× magnification (8 degree field of view) 1A29 stabilized sight of the Tunguska to track the target in elevation and azimuth, the altitude or range of the target being set manually. The gunner is initially cued towards the target by the system's search radar. Once the missile is steered to within 5 m of the target, an active laser or radio fuse (9M311-M1) is triggered. A contact fuse is also fitted. The warhead weighs about 9 kg, and is a continuous-rod system, consisting of 600 mm long, 6 to 9 mm diameter rods with a flower-like cross section. The cross section ensures the rods break into fragments weighing 2–3 grams. The rods form a complete ring about 5 m from the missile. Outside the rods is a fragmentation layer of steel cubes weighing 2–3 grams. The 9K22 is reported to have a kill probability of 0.6 with missiles (9M311).
- 9M311: Original missile, laser proximity fuze, range 8 km.
- 9M311K (3M87): Naval version of the 9M311 used by the Kortik system. Export version of Kashtan uses the 9M311-1E missile.
- 9M311-1: Export version of the missile.
- 9M311M (3M88): Improved version of the missile.
- 9M311-M1: Used with the Tunguska-M1 radar proximity fuse for improved capability against cruise missiles. Pulsed tracking light instead of constant flare for better resistance to infrared countermeasures. Range improved to 10 km.
- FK-1000: 9M311 missiles were first exported to China in 2005, and at the 9th Zhuhai Airshow held in November 2012, a suspected Chinese derivative of 2K22 Tunguska designated as FK-1000 was revealed to public. The China Aerospace Science and Technology Corporation (CASIC) developed FK-1000, differs from 2K22 Tunguska in that FK-1000 is mounted on an 8 x 8 truck, and the 30 mm guns of Tunguska are replaced by 25 mm autocannons. The radars of FK-1000 are arranged in the exactly the same way as in 2K22 Tunguska, but mechanically scanned surveillance and tracking radars of Tunguska are both replaced by a phased array radars in FK-1000. A total of 12 missiles are mounted on the sides of weapons station, with 6 on each side, in the form of 2 rows of 3 containers/launchers each. The missile of FK-1000 is designated as KS-1000, which is also surprisingly similar to 9M311, and this has led many in the west to claim that FK-1000 system is derived from 2K22 Tunguska, but with cheaper price tag than the latest Russian system: in comparison to the 15 million dollars of Pantsir-S1 (SA-22), FK-1000 system is priced at 5 million dollars.
Variants of the 2K22 system have continued to serve in the Soviet and later Russian armed forces since their initial introduction in 1984. The 2K22 has also been inducted into the armed forces of a number of foreign states, most notably India. The 2K22 has been used in the 2008 South Ossetia war by Russian armed forces.
- Belarus: a number of 2S6
- India: according to various data, from 20 to 92 2S6 units, as of 2012
- Morocco: 12 complexes 2К22М as of 2012, according to Military Balance 2012, page 340
- Russia: more than 250 complexes 2К22 as of 2012, according to Military Balance 2012, page 193
- Syria: 6 2S6М1 units delivered in 2008 
- Ukraine: 70 2S6 units as of 2012, according to Military Balance 2012, page 166
- Yemen: a number of 2S6М1, as of 2005. According to Stockholm International Peace Research Institute neither supply nor licensed production of 2S6М1 in Yemen is made.
- Soviet Union: Passed on to successor states.
- Air Defense Anti-Tank System
- Flugabwehrkanonenpanzer Gepard
- PZA Loara
- Tor missile system
- Type 87 Self-Propelled Anti-Aircraft Gun
- Type 95 SPAAA
- "ЗTunguska-M". Deagel.com. Retrieved 2010-08-01.
- "Diesel engine B-46-6 MC – Chelyabinsk tractor plant (ChTZ)".
- ЗПРК "Тунгуска-М1" ведет бой по своим правилам. Военно-промышленный курьер (in Russian). ВПК-Медиа. 2008. Archived from the original on 26 September 2008. Retrieved 2008-09-04.
- "A-10/OA-10 Thunderbolt II". GlobalSecurity.org. 12 November 2006. Archived from the original on 13 August 2008. Retrieved 9 August 2008.
- "Зенитный ракетно-пушечный комплекс 2К22 "Тунгуска" (SA-19 Grison)". Вестника ПВО (in Russian). 3 October 2000. Archived from the original on 18 August 2008. Retrieved 9 August 2008.
- "Tunguska". Encyclopedia Astronautica. 2007-11-18. Archived from the original on 2008-04-28. Retrieved 2008-09-04.
- "SA-19 Grison / Tunguska". Warfare.ru. Retrieved 2008-08-09.[dead link]
- "Russian Pantsir-S1 – best air defence money can buy". Russia Today. TV-Novosti. 2007-11-30. Archived from the original on October 11, 2008. Retrieved 2008-08-09.
- "Tula KBP 9M311 Tunguska (NATO SA-19 'Grison') low- to medium-altitude surface-to-air missile system (Russian Federation)". Janes Land-Based Air Defence. Jane's Information Group. 2008-03-20. Archived from the original on 23 July 2008. Retrieved 2008-08-09.
- Russia's Arms 2001–2002. Moscow: Military Parade Ltd. 2001. Archived from the original on November 17, 2010.
- "Зенитный ракетно-пушечный комплекс 2К22 Тунгуска". Retrieved 14 November 2014.
- "ЗПРК 2К22 "Тунгуска" (СССР/Россия)". Retrieved 14 November 2014.
- "2S6 Tunguska 30-mm Self-Propelled Anti-Aircraft Gun/Missile System". Military-Today.com. 2014. Retrieved 13 June 2015.
- "GM-5975 Specifications". MetroWagonMash. 2006-08-11. Archived from the original on July 20, 2011. Retrieved 2008-08-09.
- "HOT SHOT radar system". GlobalSecurity.org. Archived from the original on 26 July 2008. Retrieved 2008-08-09.
- Зенитный ракетно-пушечный комплекс 2К22 "Тунгуска". New-Factoria.ru (in Russian). Балтийского Государственного Технического Университета "ВОЕНМЕХ". 2000. Archived from the original on 2008-10-11. Retrieved 2008-08-09.
- "2S6 2S6M 9K22 9K22M Tunguska Tunguska-M self-propelled air defence cannon missile data sheet picture – Army Recognition – Army Recognition".
- "2С16 "ТУНГУСКА" Зенитно-ракетный комплекс". Retrieved 14 November 2014.
- ""Бук" и "Тунгуска": опции совершенства". Retrieved 14 November 2014.
-  Archived June 7, 2012, at the Wayback Machine.
- "30 mm 2A38M Automatic Anti-Aircraft Gun". KBP Instrument Design Bureau. Archived from the original on April 29, 2008. Retrieved 2008-08-09.
- "Зенитный пушечно- ракетный комплекс "Тунгуска-М"". structure.mil.ru. Retrieved 13 June 2015.
- "ЗПРК 2К22 "Тунгуска" (СССР/Россия)". Retrieved 14 November 2014.
- Peter Goon. "Russian/PLA Point Defense". Air Power Australia. Archived from the original on 15 July 2008. Retrieved 2008-07-21.
- "9M311 sold to China in 1005". Deccan Herald.
- "FK-1000 SAM".
- "KS-1000 missile".
- China offered a combination of cheap flak[dead link]
- "Air Defense: China Does It Cheaper Again". strategypage.com. Retrieved 13 June 2015.
- "FK-1000". Archived from the original on 2013-12-14.
- John Pike. "Indian Army Equipment".
- "Национальная оборона / Рынки вооружений".
- "Чем будет воевать Сирия в случае агрессии стран западной коалиции?".
- John Pike. "Yemen Army Equipment".
- Koll, Christian (2009). Soviet Cannon: A Comprehensive Study of Soviet Arms and Ammunition in Calibres 12.7mm to 57mm. Austria: Koll. p. 276. ISBN 978-3-200-01445-9.
|Wikimedia Commons has media related to 2K22 Tunguska.|
- Tunguska-M1 Air Defense Missile/Gun System, KBP Instrument Design Bureau website
- Federation of American Scientists
- Warfare.ru SA-19[dead link]
- Threat Update: 2S6 Tunguska Self-Propelled Air Defense System, Red Thrust Star, April 1995 issue
- YouTube Tunguska-M1 Video
- Tunguska-M1 Walkaround
- The FK-1000 mobile air defence system, both marketed by CPMIEC November 6, 2013
- CHINA OFFERS FD-2000 / HQ-9, FK-1000 AND FL-3000N MISSILE SYSTEMS TO THAILAND