|International MaxxPro MRAP|
|Type||MRAP Category 1 & 2|
|Used by||See operators|
|Wars||Iraq war–War in Afghanistan|
28,000-29,500 lbs (12,7 - 13,4 t)
30,000-32,000 lbs (13,6 - 14,5 t)
|Length||21.17- 23.5 ft(6.5 - 7.2 m)|
|Width||8.25 ft(2.5 m)|
|Height||10 ft (3 m)|
|Engine||9.3L, 570 cubic inches MaxxForce D9.3I6 I6
330 hp @ 2,100 rpm; 375 hp in Plus and Dash variants
|Power/weight||18.9 - 20 hp/US ton|
|Payload capacity||3,650-11,150 lbs (1,6 - 5 t)|
|Transmission||Allison 3000 5-speed automatic|
|Suspension||4x4, wheeled Semi-elliptical leaf springs|
|Ground clearance||14" (0.35 m)|
The International MaxxPro MRAP (Mine Resistant Ambush Protected) vehicle is an armored fighting vehicle designed by American company Navistar International's subsidiary Navistar Defense along with the Israeli Plasan Sasa, who designed and manufactures the vehicle's armor. The vehicle was designed to take part in the US Military's Mine Resistant Ambush Protected vehicle program, led by the US Marine Corps, as well as a similar US Army-led Medium Mine Protected Vehicle program.
MRAPs are categorized as category 1 or category 2, depending on usage and passenger compartment space, and Navistar produces the MaxxPro in both sizes, although the vast majority of those sold have been category 1 MRAPs. The MaxxPro Plus model comes with dual rear wheels for increased load carrying capacity, such as an ambulance or EFP protected variant. The latest model produced is the MaxxPro Dash, which is a smaller and lighter category 1 model. Both the Plus and Dash models use the MaxxForce 10 engine with 375 hp, in place of the DT 530 with 330 hp, used in the original base model produced.
The MaxxPro utilizes a crew capsule with a V-shaped hull, mounted on an International 7000 chassis. The V-hull deflects the blast of a land mine or improvised explosive device (IED) away from the vehicle to protect its occupants. Because the chassis is mounted outside the armored crew capsule, there are concerns that it will likely be destroyed in the event of an ambush, leaving the soldiers inside stranded. However, according to Navistar Defense spokesperson Roy Wiley, the MaxxPro "did extremely well during the tests, and we are extremely pleased." This design may prove as effective as the Krauss-Maffei Wegmann ATF Dingo that uses a similar design, one which mounts an armored capsule to a Unimog chassis. This design has survived a 7 kg (15 lb) land mine blast with no injuries.
According to Navistar Defense, the vehicle is designed with operational readiness in mind and utilizes standardized, easily available parts, to ensure rapid repair and maintenance. The armored body is bolted together instead of welded, as in other MRAPs. This facilitates repair in the field and is a contributing factor to Navistar's greater production capacity for the MaxxPro.
In 2010, the Army initiated a development effort to add electronic stability control (ESC), a computerized technology designed to improve vehicle stability, to the MaxxPro. The MaxxPro's high ground clearance provides greater protection from underbody blasts, but also raises its center of gravity, causing rollovers in certain situations. The ESC combines road factors, vehicle data, and driver intent to automatically correct driving to ensure stability during maneuvers. Installation on MaxxPros began in late 2014 and is to be completed by late 2017, with other MRAPs planned to have ESC integrated onto them.
Initially just two vehicles were delivered for testing at the Aberdeen Proving Ground in March 2007.
Following testing, a first order for 1,200 MRAP Category 1 MaxxPro vehicles was placed by the US Marine Corps Systems Command on May 31, 2007 for delivery by February 2008. However, as the U.S. Army Research and Development laboratory is overseeing the entire MRAP program, it is unclear which branches of the US Armed Services will be receiving the vehicles, and in what numbers. The contract was worth over $623 million, making it then the biggest MRAP contract to date. The US Marine Corps plans to replace all HMMWVs "outside the wire" in Iraq with MRAP vehicles.
A further order for 16 Category 2 versions (dubbed MaxxPro XL) was placed on June 19, 2007 for delivery by September 2007.
In the final order of 2007 a further 1,500 Category 1 MaxxPros were ordered bringing the total to 4,471. Of total MRAP orders to the end of 2007, 45% are MaxxPros (66% of Category 1 MRAPs).
In the first order of 2008, 743 Category I MaxxPros were ordered. The MaxxPro was by now the only Category I MRAP still receiving fresh orders.
On September 19, 2012, Navistar received an order worth $282 million to upgrade more than 2,300 MaxxPro Dash vehicles to the MaxxPro Dash ISS version. The upgrades include the Diamond Xtream Mobility Independent suspension system. The upgrade is designed to give the vehicles improved capability and technology for a lower cost than purchasing a brand-new vehicle. Work began in December in Afghanistan in the field and was completed by June 2013.
About 9,000 MaxxPro vehicles were bought by the U.S. Army between 2007 and 2011, and they plan to keep only about 3,000 of them. Navistar is pitching the MaxxPro MRAP as a vehicle that can be upgraded into a mobile command post or power generator. With budget cuts, the plan would allow the Army to get solutions they want from the existing fleet. The company is also planning to make it a maintenance vehicle and mortar carrier.
Navistar considered modifying the MaxxPro to fit Army requirements for the Armored Multi-Purpose Vehicle program to replace the M113 family of vehicles. Navistar felt that although it has less capabilities such as gap crossing, their wheeled MRAP could be capable enough to meet the solutions required and be cheaper by selecting a vehicle already in the inventory. Navistar offered the MaxxPro as a stop-gap solution to replace the M113 quickly with the more survivable MRAP, to be used until the AMPV can be fielded in 2020. BAE Systems was awarded the AMPV contract in December 2014.
The company is also pitching the MaxxPro to replace the M113 in units above brigade level not directly involved in fighting for the same cost saving reasons.
On June 16, 2008 Navistar debuted a new version called MaxxPro Plus. MaxxPro Plus has increased engine power and payload, as well as Frag Kit 6 enhancements for increased explosively formed penetrator protection.
On September 4, 2008 the U.S. Marine Corps awarded Navistar a $752 million contract to develop and produce a lighter, smaller, and more mobile MaxxPro variant that is less prone to the rollover problems that have plagued MRAP vehicles. MaxxPro Dash has a smaller turning radius and higher torque to weight ratio. Production of the MaxxPro Dash began in October 2008 with delivery of 822 units completed by February 2009.
MaxxPro Dash DXM
MaxxPro Dash with improved DXM suspension system.
MaxxPro Dash DXM Ambulance
On May 5, 2011 Navistar Defense received a $183 million delivery order for 250 International MaxxPro Dash ambulances with DXM independent suspension.
The MaxxPro XL is a Category II MRAP version of the MaxxPro. It is a larger and longer version of the base vehicle. Because it is longer, it has three bullet-resistant windows on each side, instead of two. The MaxxPro XL can carry up to 10 soldiers.
There is also an MRAP Recovery Vehicle; 250 have been ordered. These are well suited to recovering other vehicles which have been damaged by IEDs.
On July 18, 2011 Navistar Defense received a delivery order for an additional 140 MRV's with rocket-propelled grenade (RPG) nets from the U.S. Marine Corps Systems Command.
At Association of the United States Army 2013, a version called the Mission Command on the Move (MCOTM) was displayed as a command post with monitors, computers, and antennae mounted in the back for communications and surveillance. Five passengers can monitor incoming information, see unmanned aerial vehicle feeds, and keep track of where units are operating. The vehicle has an on-board transmission-integrated power generator that can produce up to 120 kilowatts of exportable power, which eliminates the need for a towed trailer and can single-handedly power a semi-permanent tactical operations center. It would allow commanders to be connected to dismounted troops and headquarters while on the move. The MCOTM version will undergo testing at the Army's network integration evaluations in February 2014.
- Afghanistan —155 with 15 MRAP recovery vehicles will be in service with Afghan National Army. So far, 10 have been received.
- Albania – used by the Special Operations Battalion
- Bulgaria - 4 in service with the Bulgarian Army, all deployed in Afghanistan
- Croatia 35 in service with Croatian Army, 5 with Croatian contingent in Afghanistan. In April 2014, the US Army donated 30 MRAP MaxPro to the Croatian Army.
- Iraq used by Iraqi special operations forces
- Egypt - 12 MaxxPro MRAP Recovery Vehicles (MRV) 
- Hungary 42 MaxxPros in service, with the last 12 received in September 2013. 12 more loaned to the Hungarian Army on 26 November 2013 for training.
- Jordan 100 MaxxPros in service with JAF
- Lithuania Used by special forces in Afghanistan.
- Pakistan 62 MaxxPros in service with the armed forces after their recent order for 40 MAxxpros, consisting of 60 personnel carriers and two haulers.
- Poland 30 MaxxPro Dashes in service in Afghanistan with the Polish Land Forces
- Romania 60 MaxxPro Dashes in service in Afghanistan with the Romanian Land Forces
- Slovakia Donated to the Slovakian Army by the United States.
- Singapore 15 MaxxPro Dashes in service with Singapore Army, deployed in Afghanistan as part of NATO-led International Security Assistance Force.
- South Korea 10 MaxxPro Dashes in service with Republic of Korea Army, deployed in Charikar, Afghanistan under "Ashena" unit, as part of International Security Assistance Force.
- Turkey MaxxPros donated from the US Army are deployed in Afghanistan.
- United Arab Emirates 3,375 MaxxPros of various versions on order.
- United States
- Estonia 6 MaxxPros in service with the Estonian Afghanistan Contingent.
- Greece 5 MaxxPros under leasing, from the US Army, were deployed in Afghanistan. These 5 vehicles were given back to US Army after Hellenic Army disengaged from ISAF in October 2012.
- United States
- U.S. Department of Homeland Security
- Several Tennessean law enforcement agencies
- Dakota County Sheriff's Office
- Jefferson County Police
- Ohio State University Department of Public Safety
- Dallas County Sheriff's Office
- Clovis Police Department
- Citrus Heights Police Department
- Davis Police Department
- Salinas Police Department
- Yreka Police Department
- Pinetop-Lakeside Police Department
- Hamtramck Police Department
- Navistar Defense Receives $282 Million Order for MRAP Upgrades - Trucktrend.com, September 19, 2012
- Chicago Auto Show: International MaxxPro
- "D9.3I6 - MaxxForce&trade". Retrieved 4 November 2014.
- $200M+ to Plasan to Armor MaxxPro MRAPs - Defense Industry Daily
- More MRAPs: Navistar’s MaxxPro Maintains the Pole Position
- DefenseNews.com - U.S. Orders 1,200 MRAPs - 05/31/07 12:56
- Krauss-Maffei Wegmann – Ihr Partner rund um Wehrtechnik
- International : News Detail
- Navistar wins $414M contract for 755 MRAPs - Army News, opinions, editorials, news from Iraq, photos, reports - Army Times
- U.S. Army Outfits First Vehicles with Electronic Stability Control ESC - Armyrecognition.com, 26 May 2015
- "Navistar : U.S. Marine Corps Awards $623 Million Contract for Mine-Resistant Ambush Protected (MRAP) Vehicles to International Military and Government, LLC". Archived from the original on September 28, 2007. Retrieved 4 November 2014.
- U.S. Marine Corps Awards $8.5 Million Contract for Category II Mine-Resistant Ambush Protected (MRAP) Vehicles to International Military and Government, LLC
- More MRAPs: Navistar’s MaxxPro Maintains the Pole Position - Defense Industry Daily
- DONNA BORAK. "Pentagon orders 2,400 armored vehicles". Archived from the original on May 23, 2011. Retrieved 4 November 2014.
- Chicago Business News, Analysis & Articles | Navistar gets $1.2 billion MRAP truck order | Crain's
- http://today.reuters.com/news/articleinvesting.aspx?type%3DcompanyNews%26storyid%3D251803+14-Mar-2008+RTRS%26WTmodLoc%3DInvArt-L2-CompanyNews-3. Retrieved March 17, 2008. Missing or empty
- Industry Working To Give the MRAP New Life - Defensenews.com, 21 October 2013
- Navistar Pitches New Uses for Old MRAPs - DoDBuzz.com, 23 October 2013
- Industry to Army: The Vehicles You Own Can Perform Future Missions - Nationaldefensemagazine.org, 24 October 2013
- More Disputes Likely in US Army's AMPV Contest - Defensenews.com, 29 March 2014
- BAE Systems wins $1.2 bn contract to launch Armored Multi-Purpose Vehicle program - Armyrecognition.com, 24 December 2014
- MRAPs Join Competition to Replace Troop Carriers - Military.com, 20 May 2014
- "Navistar News". Retrieved 4 November 2014.
- Navistar Gets $752 Million for 800+ 'MRAP-Lite' MaxxPro-Dash Vehicles
- "Navistar Defense Wins $752 Million Contract for Lighter, More MRAP Variant". Retrieved 4 November 2014.
- MaxxPro XL - Armyrecognition.com
- "Navistar's MaxxPro: 1st Place in MRAP Orders". 2010-12-15. Retrieved 2010-12-15.
- http://www.army.mil/article/142937/AFSBn_Afghanistan_plays_key_role_in_historic_title_transfer_of_equipment_directly_to_Afghan_National/. Missing or empty
- Informacje in: "Raport - Wojsko Technika Obronność" Nr. 05/2014, p. 79 (Polish)
- "U.S. Delivers Armored MRAP Vehicles to Egyptian Military". 12 May 2016. Archived from the original on 13 May 2016.
- "Excess Defense Articles (EDA)".
- Hungarian army receive 12 MRAP armoured vehicles MaxxPro Plus from United States - Armyrecognition.com, 9 December 2013
- Source: PAKISTAN ORDERS 40 MAXXPRO MRAP VEHICLES FROM THE U.S - Quwa.org, 2 February 22, 2017
- Army of Slovakia takes delivery of first MRAP Navistar MaxxPro donated by the United States - Armyrecognition.com, 6 December 2013
- "SIPRI arms transfer database". Stockholm International Peace Research Institute. 21 June 2011. Retrieved 21 June 2011.
- United States approved major contract of MRAP vehicles for UAE - Armyrecognition.com, 27 September 2014
- "Estcoy-12 Receives US Combat Vehicles". News - ERR. Retrieved 4 November 2014.
- "Dakota County Sheriff's Office Acquires Decommissioned Military-grade, Mine-resistant Vehicle". Northfield, Minnesota Patch. Retrieved 4 November 2014.
- "Watertown Daily Times - Jefferson County Sheriffs Department to get $600,000 19-ton anti-IED military vehicle for free". Watertown Daily Times. Retrieved 4 November 2014. C1 control character in
|title=at position 49 (help)
- Stuart, Hunter (18 September 2013). "This College Now Has A 19-Ton Military-Style Armored Truck". Huffington Post.
- Eric Nicholson (27 September 2013). "Dallas County Now Has Its Very Own Bulletproof, "Mine-Protected" Military SUV". Unfair Park. Retrieved 4 November 2014.
- "Davis acquires mine-resistant war vehicle while some complain of militarization of police". sacbee. Retrieved 4 November 2014.
- "YPD gets armored truck". Siskiyou Daily News, Yreka, CA. Retrieved 4 November 2014.
|Wikimedia Commons has media related to Navistar MaxxPro.|