Toyota Prius

Toyota Prius
Overview
Manufacturer	Toyota Motor Corporation
Production	1997–present
Body and chassis
Class	poor efficiency car
Layout	FF layout

The Toyota Prius (Template:Pron-en) is a full hybrid electric mid-size car developed and manufactured by the Toyota Motor Corporation. It first went on sale in Japan in 1997, making it the first mass-produced hybrid vehicle. It was subsequently introduced worldwide in 2001. The Prius is sold in more than 40 countries and regions, with its largest markets being those of Japan and North America. As a top seller in the US market, the U.S. Toyota Prius made up more than half of the 1.2 million Prius sold worldwide by early 2009.

The Prius is the most fuel efficient gas car sold in the U.S. according to the United States Environmental Protection Agency. The EPA and California Air Resources Board (CARB) also rate the Prius as among the dirtiest vehicles sold in the United States based on non-CO₂ toxic emissions. The UK Department for Transport reported the latest Prius is the second least CO₂-emitting vehicle on sale in the UK with 89 g/km.

1997-2001 (model NHW10)

NHW10 (First Generation)
Overview
Production	1997–2001
Assembly	Takaoka, later Motomachi, Japan
Body and chassis
Class	Compact car
Body style	4-door sedan
Powertrain
Engine	Toyota Hybrid System Gasoline: 1.5 L 1NZ-FXE DOHC I4 13.5:1 compression 43 kW (58 hp) @ 4000 rpm 102 N·m (75 lb·ft) @ 4000 rpm Electric: 288 V motor 30 kW (40 hp) @ 940 rpm 305 N·m (225 lb·ft) @ 0 rpm
Dimensions
Wheelbase	2,550 mm (100.4 in)
Length	4,275 mm (168.3 in)
Width	1,694 mm (66.7 in)
Height	1,491 mm (58.7 in)

The first Prius, model NHW10, went on sale in December 1997. It was sold only in Japan, though it has been imported privately to the United Kingdom, Australia, and New Zealand. Many of these cars are now being exported as second-hand vehicles to New Zealand and other countries.

2001–2003 (model NHW11)

NHW11 (Second Generation)
Overview
Production	2000–2003
Assembly	Toyota City (Motomachi), Japan
Body and chassis
Class	Compact car
Body style	4-door sedan
Powertrain
Engine	Toyota Hybrid System Gasoline: 1.5 L 1NZ-FXE DOHC I4 VVT-i 13.0:1 compression 52 kW (70 hp) @ 4500 rpm 110 N·m (82 lb·ft) @ 4200 rpm Electric: 273.6 V motor 33 kW (44 hp) @ 1040 rpm 350 N·m (258 lb·ft) @ 0 rpm SULEV
Transmission	1-speed planetary gear
Dimensions
Wheelbase	2,550 mm (100.4 in)
Length	4,308 mm (169.6 in)
Width	1,694 mm (66.7 in)
Height	1,463 mm (57.6 in)
Curb weight	1,254.2 kg (2,765 lb)

Toyota Prius Kyoto Palace patrol car

The 2001–2003 Prius for the United States market was powered by a 1.5-liter 4 cylinder gasoline engine, a permanent magnet AC electric motor, and a 274-volt nickel-metal hydride (Ni-MH) battery pack. The gasoline engine developed 70 hp (52 kW) and 82 ft⋅lbf (111 N⋅m) of torque. The electric motor generated a maximum of 44 hp (33 kW) and 258 ft⋅lbf (350 N⋅m) of torque. Japanese versions were faster but less powerful.

The engine and motor power were increased over the previous model. Air conditioning and a continuously variable transmission were standard equipment.

In the United States, the NHW11 was the first Prius to be sold. The Prius was marketed between the smaller Echo and the larger Corolla. The published retail price of the car was US$19,995. The California Air Resources Board (CARB) classified the car as a Super Ultra Low Emission Vehicle (SULEV).

European sales began in September 2000.

The official launch of the Prius in Australia occurred in 2001 after the Sydney Motor Show, although sales were slow until the NHW20 model arrived.

2004–2009 (model NHW20)

NHW20 (Third Generation)
Overview
Production	2004–2009 (North America) 2004–present (Japan, China, Europe)
Assembly	Tsutsumi, Japan (Toyota City) Kariya, Aichi, Japan (Fujimatsu) Chengdu, Sichuan, China (Chinese domestic market only)
Body and chassis
Class	Midsize car
Body style	5-door hatchback
Powertrain
Engine	Toyota Hybrid System II Gasoline/Petrol: 1.5 L 1NZ-FXE DOHC I4 VVT-i 57 kW (76 hp) @ 5000 rpm 115 N·m (85 lb·ft) @ 4200 rpm Electric: 500 V 50 kW (67 hp) @ 1200 rpm 400 N·m (295 lb·ft) @ 0 rpm AT-PZEV Hybrid system net horsepower: 110 hp (82 kW)
Transmission	1-speed planetary gear
Dimensions
Wheelbase	2,700 mm (106.3 in)
Length	4,450 mm (175.2 in)
Width	1,725 mm (67.9 in)
Height	1,490 mm (58.7 in)
Curb weight	1,317 kg (2,903 lb)

The Prius was completely redesigned into a mid-size liftback which is between the Corolla and the Camry in size, with redistributed mechanical and interior space that significantly increased the rear-seat legroom and luggage room to exceed that of many larger automobiles. The new model is 6 inches (150 mm) longer than the previous version. Its more aerodynamic Kammback body balances length and wind resistance resulting in a drag coefficient of 0.26 C_d.

The Prius uses an all-electric A/C compressor for cooling, an industry first. The redesigned Prius also adds an electric power steering system to further minimize engine belt-driven engine accessories. Combined with a smaller and lighter NiMH battery, the NHW20 is more powerful and more efficient than the NHW11. In the U.S., the battery pack of the 2004 Prius is warranted for 100,000 miles (160,000 km) or 8 years. The warranty for hybrid components in California and the seven Northeastern states that have adopted the stricter California emission control standards is 150,000 miles (240,000 km) or 10 years.

It is classified as a SULEV (Super Ultra Low Emissions Vehicle) and is certified by California Air Resources Board as an "Advanced Technology Partial Zero Emission Vehicle" (AT-PZEV).

2006 Prius cut-away in a Toyota showroom in Paris

Among the Prius's options are Toyota's implementation of a Smart Key System (the feature can be user-deactivated), DVD navigation on the MFD, Vehicle Stability Control and Bluetooth for hands-free calling. A new Intelligent Parking Assist system was available in Japan and Europe since its launch.

Production of the Prius for the Chinese market began in December 2005 by Sichuan FAW Toyota Motor, a joint venture with First Automobile Works.

Model year changes

The 2006 model introduced some minor cosmetic changes, such as a higher-resolution liquid crystal display, as well as new optional features such as a backup camera, advanced airbags and an upgraded audio system with an auxiliary input. The 2007 Prius adds side curtain airbags standard on all models. A Touring Edition was introduced that includes an elongated larger rear spoiler as well as larger, sharper-pointed 7-spoke 16" alloy wheels with plastic hub cap cover to protect it from scratches when parking against the curb. The Touring Edition also comes with a firmer European-style tuned suspension, standard high-intensity-discharge (HID) headlights and integrated (non-HID) fog lights.

Crash testing

NHTSA (United States) crash testing of the 2004 Prius yielded a five star driver and four star passenger rating in the frontal collision test (out of five stars). Side crash results were four out of five stars for both front and rear seats. The car scored four out of five stars in rollover testing.

IIHS crash tests score the Prius "Good" overall in frontal collisions and "Good" overall in side impact collisions in models equipped with side airbags. A "Poor" score is given to models without side airbags. Side curtain and torso airbags became standard on 2007 American models.

In 2004, EuroNCAP tested the Prius. It earned the following ratings: Adult Occupant: Child Occupant: Pedestrian: .

Research plug-in

In July 2007, Toyota received both Japanese and American governmental approval to begin testing plug-in hybrid models using a modified NiMH battery on public roads. The first plug-in Prius in America went to South Carolina. Researchers at the Advanced Power and Energy Program at the University of California, Irvine and the Institute of Transportation Studies at the University of California, Berkeley began testing two specially made Prius and analyze driver behavior, study air quality and energy use. However, electric-only driving range remains limited to around seven miles (eleven kilometers) per charge in all-electric mode at up to 100 kilometers per hour (62 miles per hour).

2010– (model ZVW30)

ZVW30 (Fourth Generation)
Overview
Production	2009-present
Assembly	Tsutsumi, Japan (Toyota City) Kariya, Aichi, Japan Chengdu, Sichuan, China (Chinese domestic market only)
Body and chassis
Class	Midsize car
Body style	5-door hatchback
Powertrain
Engine	Toyota Hybrid System Gasoline/Petrol engine: 1.8 L 2ZR-FXE I4 Dual VVT-i (Atkinson cycle) Power: 98 hp @ 5,200 rpm Torque: 105 lb-ft @ 4,000 rpm Electric motor: Power: 80 hp Torque: 153 lb-ft AT-PZEV Hybrid system net horsepower: 134 hp
Transmission	1-speed planetary gear
Dimensions
Wheelbase	2,700 mm (106.3 in)
Length	4,460 mm (175.6 in)
Width	1,745 mm (68.7 in)
Height	1,480 mm (58.3 in)
Curb weight	1379 kg (3,042 lb)

Interior (RHD)

Toyota debuted the 2010 Prius at the 2009 North American International Auto Show, and sales began in Japan on May 18, 2009. Its new body design is more aerodynamic with the coefficient of drag reduced to 0.25 C_d. An underbody rear fin helps stabilize the vehicle at higher speeds.

The estimated fuel efficiency rating using the U.S. EPA combined cycle is: 50 mpg_‑US (4.7 L/100 km; 60 mpg_‑imp). This figure surpasses the 1st-generation automatic Honda Insight's EPA estimated fuel economy making the new Prius the most fuel efficient mass produced gasoline powered automatic vehicle sold in the United States.

The official UK fuel efficiency data for the Prius T3 is: Urban 72.4 mpg_‑imp (3.90 L/100 km; 60.3 mpg_‑US), Extra Urban 76.4 mpg_‑imp (3.70 L/100 km; 63.6 mpg_‑US), Combined 72.4 mpg_‑imp (3.90 L/100 km; 60.3 mpg_‑US).

The 1.8-liter gasoline/petrol engine (previously 1.5-liters) generates 98 hp and with the added power of the electric motor total horsepower is 134 hp (previously 110 hp). The larger engine's displacement allows for increased torque reducing engine speeds (RPM) which in turn increases fuel economy at highway speeds. With an electric water pump, the Prius engine is the first production engine that requires no accessory belts which also further improves fuel economy. Also, the battery pack is smaller and more efficient, as are the electric motors and other components of the hybrid powertrain. Toyota estimates the new inverter, motor and transaxle are 20 percent lighter. Disc brakes replace the previous rear drum brakes.

For the Prius, Toyota used a new range of plant-derived ecological bioplastics made from the cellulose in wood or grass instead of petroleum. The two principal crops are kenaf (a member of the hibiscus family and related to cotton and okra) and ramie, commonly known as China grass and one of the strongest natural fibres, similar to flax in absorbency and density. Toyota says this is a particularly timely breakthrough for plant-based eco-plastics because 2009 is the United Nations’ International Year of Natural Fibres, which covers kenaf and ramie.

Toyota filed over one thousand patents during the development of the latest Prius. Toyota's global goal is to sell about 400,000 units annually by 2010. In May 2009 production was increased to 50,000 units per month or 600,000 annual units to help meet higher than projected demand.

In the US the Prius will have a starting base price (MSRP) of US$21,750. This base model or Prius I will be available in October. The Prius II will have a starting base price of $22,750 and improves the specification with 15-inch alloy wheels, Vehicle Stability Control and interior amenities including cruise control, 6-speaker audio, Toyota's keyless entry/ignition Smart Key System and a unique Touch Tracer Display designed to help the driver's eyes stay on the road ahead when using steering wheel mounted climate and audio controls.

Sales of the Prius also started in the Philippines on June 22, 2009, for a SRP of Php 2.2 million (approximately USD 41,800) about half for import duties and other taxes, making it the first hybrid vehicle available in the Philippines. The launching for the Latin American market took place in Costa Rica on July 3, 2009. The Prius will be sold in Costa Rica for USD 41,000 including tariffs and all taxes.

The US Prius will offer three optional packages:

• A Navigation Package which includes a voice-activated touch-screen DVD-based navigation system and an 8-speaker JBL audio system with XM satellite radio, MP3/WMA playback capability, Bluetooth and backup camera. The Prius in Japan is equipped with G-BOOK as of May 18, 2009.
• A Solar Roof Package includes the Navigation Package and adds a power tilt/slide moonroof along with a solar powered ventilation system which uses an electric fan to help keep the vehicle cooler when parked under the sun by venting the interior's heated air with the outdoors. The solar roof was originally intended to assist in charging the vehicle's battery, but the system was configured to only power ventilation when it was found that the battery-charging configuration created electromagnetic interference that affected the radio. A new remote air-conditioning feature allows the driver to activate the air conditioner prior to entering the vehicle.
• An Advanced Technology Package includes the Navigation Package while adding a Pre-Collision System, Dynamic Radar Cruise Control, Lane Keep Assist and Intelligent Parking Assist.

Other options include and Safety Connect, while LED headlamps come standard on the Prius V trim.

Toyota Prius plug-in hybrid proptotype exhibited at the Automotive Engineering Exposition 2008, Yokohama City, Japan.

Plug-in version

According to Toyota, a Prius plug-in hybrid (PHEV) powered by lithium-ion batteries will become available for fleet buyers beginning in late 2009. Nikkei news reported that Toyota will start mass producing the plug-in hybrid for regular consumers in 2012, and the estimated price will be ~USD48,000.

Different points:

• Electric FR layout (normal: FF layout)
• Series hybrid (normal: series-parallel hybrid)
• Lithium-ion battery (normal: nickel-hydrogen battery)

Comparison of models

Feature		Model code
		NHW10	NHW11	NHW20	ZVW30
Body style		4-door Sedan	4-door Sedan	5-door Hatchback	5-door Hatchback
First sales		1997	2000	2003	2009
Battery	Modules	40	38	28	28
	Cells per module	6	6	6	6
	Total cells	240	228	168	168
	Cell voltage	1.2	1.2	1.2	1.2
	Voltage total volts	288	273.6	201.6	201.6
	Capacity amp-hours	6.0	6.5	6.5	6.5
	Capacity watt-hours	1728	1778	1310	1310
	Weight kilograms (kg)	57	50	45	?
Gasoline Engine	Power kW/hp	43/58	52/70	57/76	73/98
	at rpm	4000	4500	5000	5200
Electric Motor	Operating voltage	288	273	500	650
	Power kW/hp	30/40	33/44	50/67	60/80
Combined	Power kW/hp	?/?	73/98	82/110	100/134

Background

History

In 1994, Toyota executive Takeshi Uchiyamada was given the task of creating a new car which would be both fuel efficient and environmentally friendly. After reviewing over 100 hybrid designs, the engineering team settled on a hybrid engine design based on a 1974 TRW patent, but many technical and engineering problems had to be solved within the three years that the team was given to bring the car to the Japanese market, a goal they barely achieved as the first Prius went on sale in December 1997. A main problem was the longevity of the battery, which needed to last between 7 and 10 years. The solution the engineers came up with was to keep the battery pack between 60% and 40% charged, proving to be the "sweet spot" for extending the battery life to roughly that of the other car components.

The car was a modest success in Japan and after gathering several years of test data from the Japanese early adopters, the company felt it was safe to put it on sale in the U.S. and European markets in 2001. Sales were limited and customer waiting lists of up to 6 months were common during the first few years. In 2004, a complete redesign, increased production, and soaring fuel prices led to significant increases in sales.

Name

"Prius" is not a verb but a Latin comparative adjective or adverb, the neuter nominative singular form of the adjective whose corresponding masculine and feminine nominative singular forms are prior (see also Latin declension - Irregular adverbs and their comparative and superlative forms) with meanings "ahead, in front, leading; previous, earlier, preceding, prior; former; basic".

A Toyota spokesperson stated that "Toyota chose this name because the Prius vehicle is the predecessor of cars to come."

Some enthusiasts enjoy using "Prii" as the plural, which would be correct if "prius" were a regular second declension Latin noun. The actual Latin plural of the adjective is "priora" (Reference is slightly in error here). All of these forms are nominative case and there are several other forms for the other cases. As for the plural of "Prius" in English, Toyota has said that it is simply "Prius" and also that owners are welcome to use whatever they like.

In Estonian, priius (very similar to prius) means freedom.

Sales

2006 Toyota Prius used by a car share agency.

2008 Toyota Prius used as a taxi in New York City.

Toyota announced on June 7, 2007 that it had sold 1 million hybrid vehicles globally, and that of those 757,600 were Prius. Nearly 345,000 of the first 1 million hybrid cars made by Toyota were sold in Japan. In May 2008, Toyota announced that its worldwide cumulative sales of the Prius had passed the 1 million mark. The Prius, which is sold in more than 40 countries and regions, has its largest markets in Japan and North America. Nearly 60% of all Prius sales have been in North America, where 183,800 vehicles were sold in 2007. That sales pace has accelerated in early 2008, with 66,100 vehicles sold in North America in the first four months, a rate that would result in nearly 200,000 sales if continued through the entire year. In fact, Toyota sold 21,757 Prius hybrids in the United States in April, setting a record for April sales and making the Prius the third most popular vehicle in the Toyota line, trailing the Corolla and the Camry.

U.S. sales of the Prius began in August 2000. By 2001 sales there totaled 15,556, and by 2002 had reached 20,119. In 2004 sales there were 53,991, and doubled in 2005 to 107,897, about 60% of the world total of 180,000. By June 7, 2007, 266,212 Prius had been sold in the U.S., and accounted for 40% of the hybrid market there in 2006. As of November 2007 Toyota has sold 510,325 Prius in the US since its initial launch in 2000. Prius gas-electric hybrid mid-size sedan reported sales of 14,212 units for a best-ever December and best-ever year-end sales of 181,221 units, up 68.9 percent over 2006. By February 2009 the Prius sales in the US made up more than half of the 1.2 million Prius sold worldwide.

Annual sales worldwide and by region (in thousands)
Year	World	Japan	North America	U.S.	Europe	Other
1997	0.3	0.
1998	17.7	17.7
1999	15.2	15.2
2000	19.5	12.5	5.8	5.562	0.7	0.01
2001	29.0	11.0	16.0	15.556	2.3	0.2
2002	28.1	6.7	20.3	20.119	0.8	0.2
2003	43.2	17.0	24.9	24.627	0.9	0.4
2004	125.7	59.8	55.9	53.991	8.1	1.9
2005	175.2	43.7	109.9	107.897	18.8	2.9
2006	185.6	48.6	109.0	106.971	22.8	5.3
2007	281.3	58.3	183.8	181.221	32.2	7.0
2008				158.884

Design and technology

See also: Hybrid Synergy Drive

The Toyota Prius Hybrid Synergy Drive is a series-parallel full hybrid, sometimes referred to as a combined hybrid.

Toyota Prius used by NYPD Traffic Enforcement

The Prius is a power-split or series-parallel (full) hybrid, sometimes referred to as a combined hybrid, a vehicle that can be propelled by gasoline (petrol) and/or electric power. Components of the system include:

1. Regenerative braking, using motor-generators, which converts kinetic energy of motion into electrical energy that is stored in the traction battery and reduces wear on the brake pads;
2. A 1NZ-FXE internal combustion engine (ICE) using Atkinson cycle which is 12-14% more efficient than the more powerful Otto cycle. The gasoline engine normally shuts off during traffic stops and the accessories (including the air conditioning) are powered by the battery pack. The engine is used both to propel the vehicle and to recharge the batteries. Because of the availability of extra power from the electric motors for rapid acceleration, the engine is sized smaller than usual for increased fuel efficiency and lowered emissions with acceptable acceleration. The penalty of the Atkinson cycle is low specific power, so the battery and generator are needed to give extra power when accelerating, whilst allowing the vehicle to cruise on the low powered engine;
3. Two electric motor/generators: MG1 and MG2. MG1, reversible and up to 10,000 rpm, starts the engine and provides counter torque for the Continuously Variable Transmission (CVT). MG2 provides 50 kW (67 hp) between 1,200 to 1,540 rpm and 400 N·m (295 lb·ft) torque between 0 to 1,200 rpm, contributing to performance and economy. These motor-generators are used as generators when in regenerative braking mode, and as motors are capable of powering the vehicle at low speed (<~30 mph (48 km/h), 41 mph (66 km/h) in NHW20) travel;
4. A Hybrid Synergy Drive (HSD) unit that combines a planetary gearset that behaves like a Continuously Variable Transmission (CVT) called the Power Split Device to increase efficiency. The computer controlled HSD transaxle adjusts and blends the amount of power from the gasoline engine and electric motor-generator(s) as needed by the front drive wheels and rechargeable batteries;
5. A sealed 38-module nickel metal hydride (NiMH) battery pack providing 273.6 volts, 6.5 A·h capacity and weighing 53.3 kg (118 lb) is supplied by Japan's Panasonic. They are normally charged to 40–60% of maximum capacity to prolong battery life as well as provide a reserve for regenerative braking;
6. Wind resistance is reduced by a drag coefficient of 0.25 (0.29 for 2000 model) with a Kammback design to reduce air resistance. Lower rolling-resistance tires are used to reduce road friction;
7. A vacuum flask for storing hot coolant when the vehicle is powered off for reuse so as to reduce warm-up time (US market);
8. An EV mode (or stealth mode) that allows drivers to operate on electric power only under low-power conditions for a limited duration of time (Europe and Asian markets, aftermarket in the US). Advocates for the blind warn that the Prius is silent, and that it could be hazardous to blind pedestrians and others accustomed to engine noise to warn of a nearby vehicle;
9. Vehicle weight is reduced by the use of a flexible resin gasoline tank and by the use of aluminum instead of steel for the engine bay hood and hatchback;
10. Starting with the 2010 model year (3rd generation), the gasoline engine uses an electric water pump, permitting an engine design with no serpentine belts, improving efficiency.

THS inverter unit (from NHW11)

The computer program used in the Prius shuts off the engine when the car is stopped, is reversing, or is descending hills, thereby dramatically decreasing fuel consumption in city driving . The HSD's on-board computer program determines when and how to use the engine, motor, or both to power the car and recharge the battery so as to maximize efficiency. Typically, a gasoline engine runs inefficiently at half-throttle, creating a choking condition called pumping loss, a major reason for the inefficiency of gasoline engines compared to diesels. The Prius minimizes pumping loss by using a high torque range as much as possible with the throttle fully open. Drive-by-wire throttle control technology and Toyota's Hybrid Synergy Drive (a torque combiner, electric drive, and computer control) are essential to this engine control. In addition to the immediate benefit of reducing fuel consumption and emissions, stopping the gasoline engine also improves the performance of the catalytic converter, as the exhaust gases from an idling engine tend to cool the catalyst below its optimal temperature.

Energy monitor on the 2005 Prius multi-function display (MFD), showing energy flow to/from the engine, battery, and from the regenerative braking, as well as battery charge level.

Hybrid Synergy Drive

Typical gasoline- or diesel-engined vehicles consume fuel when the vehicle is stopped, as is common in city driving. The Prius typically shuts down the gasoline engine and runs solely off the battery pack at low speeds and when stopped. A non-hybrid car also gets worse fuel consumption in city driving because its engine is continually used to accelerate the car to driving speed and then this energy is lost to friction brakes during stop-and-go driving. The Prius recaptures some of this energy by using regenerative braking to charge its battery pack while slowing down with its motor-generators in generator mode. For acceptable acceleration the IC engine on a "standard" car typically is much larger than needed for constant-speed travel, and is a relatively high power to rate weight ratio Otto cycle engine. By using both an Atkinson cycle gasoline engine, which whilst more efficient, has a much poorer power to weight ratio and an electric motors for acceleration the Prius engine can nevertheless be a smaller size and still provide acceptable acceleration. This means such a hybrid can have high fuel efficiency (but slower top speed than the smaller non-hybrid vehicles) when cruising on the Atkinson cycle engine, and in city driving, though factors including driving style, air conditioning use, and short trips may offset some of this advantage. The frequent starting and stopping of the Prius engine does not cause noticeable additional wear and tear or emission problems because the electric drive motors have enough power to quickly spin the engine to optimal speed (around 1,000 rpm) before fuel is admitted.

Energy screen on the 2003 Prius

For any car, aerodynamic losses, which vary roughly as the velocity squared due to air drag are much greater on the highway than in low speed city driving. The Prius hybrid has less of an advantage in higher speed open road driving, typical of intercity driving. Nevertheless, the Prius still obtains improved fuel consumption under these circumstances since it can use a smaller and more efficient engine than would otherwise be required. The electric motor(s), powered by the battery pack, can provide the extra peak power needed for acceleration, passing and limited hill climbing. The lower weight, cross sectional area and lowest drag coefficient of a production car in the U.S. market make the Prius a very efficient highway traveler, getting 45 mpg_‑US (5.2 L/100 km; 54 mpg_‑imp) on the highway according to the U.S. EPA.

The environmental impact of the car's batteries has been questioned. To encourage battery recycling, dealers are paid a $200 fee for return of the car's batteries. Toyota has laboratory reports that some Prius battery packs have lasted the equivalent of 180,000 miles (290,000 km). As the cars start to age, early reports have shown that in at least some cases the batteries can last in excess of 250,000 miles (400,000 km). Individual battery longevity will vary depending upon the treatment and use history of the battery pack. A degraded battery pack will reduce performance and fuel economy, but not leave the car inoperable.

EV mode

When the vehicle is turned-on with the "start" button, it is ready to drive immediately with the electric motor, while electric pumps warm the engine with previously saved hot engine coolant, before the internal combustion engine is started. The delay between starting the car and starting the internal combustion engine is approximately seven seconds. The Asian and European versions of this vehicle provide a button labeled "EV" that maintains Electric Vehicle mode after start up, under most low-load driving conditions. This permits driving with low noise and no fuel consumption, and is advertised as a "quiet" option for short journeys, for example in residential areas at night, in the Asia manual. The car automatically reverts to normal mode if the battery becomes exhausted. Prior to the 2010 model, the North American model did not have the "EV" button, although the "EV" mode is still supported internally by the Prius Hybrid Vehicle management computer.

Fuel consumption

Monitor on a 2005 Toyota Prius MFD, displaying accumulative fuel economy for 59 miles (95 km) since last gas fill-up.

Fuel consumption, or fuel-efficiency in cars is generally measured as distance travelled per unit volume of fuel, as in miles per gallon (mpg), or as the volume of fuel required to cover a given distance, as in litres per 100 kilometres (L/100 km). Diesel fuel does have about an 11% higher energy density than gasoline (petrol), so that needs to be taken into account in pure energy-efficiency calculations and comparisons. Fuel-price-efficiency calculations will vary between various parts of the world, with diesel fuel pump prices being higher than gasoline prices in some countries, whilst in others it is less expensive than gasoline.

Official government data

United States

In the United States, the Environmental Protection Agency (EPA) test results must be posted on new vehicle windows, and are the only fuel consumption figures that can be advertised. EPA testing procedures for all vehicles were revised in 2007 in an attempt to better match what the average driver would achieve. The following data is taken from these figures:

2010 Prius:

• 51 mpg_‑US (4.6 L/100 km; 61 mpg_‑imp) city driving
• 48 mpg_‑US (4.9 L/100 km; 58 mpg_‑imp) highway driving
• 48 mpg_‑US (4.9 L/100 km; 58 mpg_‑imp) combined

2005 Prius:

• 48 mpg_‑US (4.9 L/100 km; 58 mpg_‑imp) city driving
• 45 mpg_‑US (5.2 L/100 km; 54 mpg_‑imp) highway driving
• 45 mpg_‑US (5.2 L/100 km; 54 mpg_‑imp) combined

2001 Prius:

• 42 mpg_‑US (5.6 L/100 km; 50 mpg_‑imp) city driving
• 41 mpg_‑US (5.7 L/100 km; 49 mpg_‑imp) highway driving
• 41 mpg_‑US (5.7 L/100 km; 49 mpg_‑imp) combined

The Prius is the most efficient car available in the U.S. in 2009, based on the official rating.

United Kingdom

The official fuel consumption data, provided by the Department for Transport, rates the Prius as: 56.5 mpg_‑imp (5.00 L/100 km; 47.0 mpg_‑US) urban, 67.3 mpg_‑imp (4.20 L/100 km; 56.0 mpg_‑US) extra urban and 65.7 mpg_‑imp (4.30 L/100 km; 54.7 mpg_‑US) combined. Eleven diesel-powered vehicles with manual transmissions, most of them smaller cars have better fuel-efficiency (by fuel volume) than the second generation Prius for combined use.

The third generation Prius is rated at 72.4 mpg_‑imp (3.90 L/100 km; 60.3 mpg_‑US) combined. Three smaller manual diesel powered cars exceed that figure.

Independent test data and comparisons with other vehicles

Several organizations have tested the fuel economy of the Prius and compared it directly with other cars.

Consumer tests have shown that petrol-electric hybrid cars in general are a little more fuel-efficient (by fuel volume) than top of the range manual transmission diesels. However, diesel fuel has a significantly higher energy density than the gasoline used by the Prius, and in some countries diesel is less expensive than gasoline, so overall diesel with manual transmission may be competitive with hybrid technology in some cases.

• January 2009: Edmunds.com compared the 2009 Prius to the all-new 2010 Honda Insight. The Prius returned 54.4 mpg_-US compared to the Insight's 51.5 mpg_-US.

• September 2008: A Popular Mechanics comparison shows that the 2009 Volkswagen Jetta TDI diesel has slightly better highway fuel economy than the 2008 Prius with 45.4 mpg_-US compared to 44.8 mpg_-US. The Prius did better than the Jetta in city fuel economy, however: 44.7 mpg_-US compared to 32 mpg_-US.

• August 2008: Edmunds.com test of Prius and Honda Fit, resulted in the Prius averaging 42 mpg_‑US (5.6 L/100 km; 50 mpg_‑imp). While the compact-sized non-hybrid Fit averaged 28 mpg_‑US (8.4 L/100 km; 34 mpg_‑imp). The Honda Fit was priced $8,425 less in this test.

• June 2008: The Prius is the most fuel efficient car that Consumer Reports has tested since the discontinuation of the 3-door Honda Insight. Consumer Reports gave a real-world fuel consumption rating of 44 mpg_‑US (5.3 L/100 km; 53 mpg_‑imp) for the Prius.

• May 2008: The Prius was the overall winner of the Edmunds.com "Gas-Sipper Smackdown" fuel economy test, winning three of the five tests. The 2005 Jetta TDI won the remaining two tests, but factoring in the higher cost of diesel the Jetta ranked third in fuel costs behind both the Prius and Smart Fortwo. The other car tested was the North American Ford Focus.

• March 2008: The UK's Sunday Times did a comparison of the Prius with another car in long distance town and country driving. The results showed that the other car, a BMW 520d SE with a Template:Auto bhp diesel engine, 6-speed manual transmission and regenerative braking, averaged 50.3 mpg_‑imp (5.62 L/100 km; 41.9 mpg_‑US) whilst the Prius averaged 48.1 mpg_‑imp (5.87 L/100 km; 40.1 mpg_‑US) over exactly the same route. The comparison was performed on a journey of 545 miles (877 km) from London to Geneva, including 100 miles (160 km) of urban driving, about 200 miles (320 km) of driving on rural roads, and about 200 miles (320 km) of motorway driving at speeds of up to 78 miles per hour (126 km/h) on one French autoroute.

• August 2007: UK's Auto Express magazine performed independent fuel efficiency tests, on public roads, on a number of hatchbacks, and in August 2007 published their list of the ten most efficient. The Prius achieved 10th place in the list, returning 41.5 mpg_‑imp (6.81 L/100 km; 34.6 mpg_‑US). A Citroën C4 Coupé 1.6 HDi got 1st place with 49.6 mpg_‑imp (5.70 L/100 km; 41.3 mpg_‑US) .

• Motor Trend conducted a test comparing the Prius with a Civic Hybrid. The Prius had the better fuel economy with 43.8 mpg_‑US (5.37 L/100 km; 52.6 mpg_‑imp) compared to 39.9 mpg_‑US (5.90 L/100 km; 47.9 mpg_‑imp) for the Civic.

• December 2005: Edmunds.com test of the Prius and Honda Civic Hybrid resulted in the Prius outperforming its competitor by an additional 4.5 mpg_‑US (52 L/100 km; 5.4 mpg_‑imp) at 48.3 mpg_‑US (4.87 L/100 km; 58.0 mpg_‑imp).

• February 2005: In a Popular Mechanics magazine diesel versus hybrid comparison, the Prius outperformed the Volkswagen Jetta GL TDI diesel in both city and highway fuel economy.

• September 2004: Car and Driver tested the Prius, the Civic Hybrid, Toyota Echo, and Jetta TDI over three separate routes. The Prius yielded the best mileage on the highway and town routes, while tying the Echo for top spot on the suburban route.

Air pollution

In the United States the EPA measures a vehicle's air-borne pollution based on hydrocarbons, nitrogen oxides, carbon monoxide, particulate matter and formaldehyde before assigning them a score. In most states the NHW20 Prius is rated Tier II Bin 3. CARB also does its own emission scoring, the NHW20 Prius meets AT-PZEV certification in California and states that adopted CARB emission rules.

CO₂ emission

According to the UK Department for Transport, the third-generation Prius launched in the UK in August 2009 emits 89 g/km, overtaking other cars except the two passenger Smart fortwo with its 0.8-liter turbocharged 45 hp diesel which emits 88 g/km.

The previous Prius tied with the MINI Cooper D as the fourth least CO₂-emitting vehicles at 104 g/km, behind the Ford Fiesta Econetic at 98 g/km and the tied Volkswagen Polo 1.4 TDI/SEAT Ibiza 1.4 TDI at 99 g/km - it is the least CO₂-emitting petrol-powered car, since the Ford and the Polo/Ibiza (both of which are city cars) run on diesel.

Criticisms

CO₂ advertising claims

In the UK, the Advertising Standards Authority, an independent body charged with policing the rules of the advertising industry, ruled that a television advert for the Toyota Prius should not be broadcast again in the same form, having breached rules concerning misleading advertising. The advert claimed the Prius "emits up to one tonne less CO₂ per year," while on-screen text included: "1 tonne of CO₂ less than an equivalent family vehicle with a diesel engine. Average calculated on 20,000 km a year." Points of contention were the vehicles chosen for comparison, whether "up to one tonne less" adequately communicated that reductions could be lower, and whether the distance used was appropriate: 20,000 km per year is around a U.S. car's average annual driving distance, while a UK car's is 13,440 km.

An earlier complaint to the New Zealand Advertising Standards Authority, decision 03/360 2003 was also upheld. It was ruled that Toyota was in breach of the New Zealand advertising standards code of ethics, by claiming "up to 89% fewer smog forming emissions”. The figure was based on comparison with Euro 3 standards, which most new cars also met comfortably at the time.

Lifetime energy usage

The British Government and British media have requested Toyota release detailed figures for the energy use and CO₂ emissions resulting from the building and disposal of the Prius. The UK Government Car Service runs 130 Priuses. Toyota has not supplied the detailed data they requested to support claims that the lifetime energy usage of the Prius (including the increased environmental cost of manufacture and disposal of the nickel-metal hydride battery) are outweighed by lower lifetime fuel consumption. Toyota states that lifetime CO2 saving is 43 percent.

Repair costs

According to a study by Audatex, Prius repairs are slightly more expensive than those for comparable non-hybrid cars, with a greater cost difference in the past due to the lack of availability of recycled parts.

Political symbolism

The large number of Prius-owning progressive celebrities in 2002 prompted the Washington Post to dub hybrids "Hollywood's latest politically correct status symbol." While conservative "Prius Patriots" were also cited in 2005, the vehicle carries an image as being a car for politically liberal environmentalists. A 2007 San Francisco Chronicle article said "Prius Progressives" were becoming an archetype, quoting conservative U.S. pundit Rush Limbaugh opining that "these liberals think they're ahead of the game on these things, and they're just suckers."

Some conservatives promote use of the Toyota Prius. For example, Jim Road from What Would Jesus Drive? encouraged people to drive hybrid cars because of the damage that large SUVs and/or faster cars can do to others.

Former Central Intelligence Agency chief R. James Woolsey, Jr. drives a Prius because of its low fuel consumption. Woolsey noted the volatility of the Middle East, coupled with anti-US sentiment in much of the region. Noting that the high percentage of oil drilled in the Middle East gives vast profits to Middle Eastern regimes, Woolsey believes that it is a patriotic obligation to drive more efficient vehicles. In a Motor Trend magazine article, Woolsey claimed that those oil profits find their way to terrorist groups like al-Qaeda, meaning that Americans who buy inefficient vehicles would, in effect, be indirectly funding terrorism. "We're paying for both sides in this war, and that's not a good long-term strategy," said Woolsey. "I have a bumper sticker on the back of my Prius that reads, 'Bin Laden hates this car.'"

Fashion over function

In 2004, industry analyst Art Spinella of CNW Marketing Research (CNWMR), whose skepticism towards hybrids is well known (see Lifetime energy cost), said "the Prius was a fashion statement", attributing its success over the Honda Civic Hybrid, which has a nearly identical appearance to its non-hybrid versions, to its distinctive styling, which lets "other people know the driver is driving a hybrid vehicle".

In July 2007 the The New York Times published an article using data from CNW Marketing Research finding that 57% of Prius buyers said their main reason for buying was that "it makes a statement about me.", while just 36% cited fuel economy as a prime motivator. Shortly afterwards Washington Post columnist Robert Samuelson coined the term "Prius politics" to describe a situation where the driver's desire to "show off" is a stronger motivator than the desire to curb greenhouse gas emissions.

Quietness

The Wall Street Journal reported in February 2007 on concerns that quiet cars like the Prius may pose a safety risk to those who rely on engine noise to sense the presence or location of moving vehicles. Blind pedestrians are a primary concern, and the National Federation of the Blind advocates audio emitters on hybrid vehicles, but increased risks may also affect sighted pedestrians or bicyclists who are accustomed to aural cues from vehicles. In July 2007, a spokesperson for Toyota said the company is aware of the issue and is studying options. Both State and Federal legislation have been proposed and the National Highway Traffic Safety Administration held a public hearing. Different groups and companies are looking at solutions. Further, Japan is also considering enforcing a noise-making device for quiet hybrid cars such as the Prius due to concerns from visually-impaired pedestrians.

Government and corporate incentives

Government incentives

A number of governments have incentives that are intended to encourage hybrid car sales. In Belgium, the national government offers reductions in the purchase price of up to 15% for buying cars that have lower CO₂ exhaust.

The federal government in Canada offers to those who buy or lease hybrid cars a rebate, however the rebate program expired on December 31, 2008. Some provincial governments also offer incentives such as in British Columbia, Manitoba, Quebec, Ontario, and Prince Edward Island.

In the United Kingdom, there are both fiscal and parking-related incentives. The fiscal incentives are general; road tax is just £15 a year. Businesses can now (from 1 April 2008) claim a 100% first year tax write-off for the Prius because the car has CO2 emissions of less than 110 grams per kilometre. The tax charge for a Prius that is provided as a company car is just 10% of its list price, rather than the heftier rates that can be up to 35% of a car's list price. Parking incentives exist in Richmond upon Thames (south west London), Westminster (Central London) for resident parking permits, Winchester (now discontinued), Manchester, and Brighton has similar plans. Drivers can pay £10 to register for an annual exemption from the £8 daily London congestion charge Some of the incentives in the United Kingdom have been criticized in the press given that non-hybrid cars, some of which may have better fuel economy in some circumstances, are not afforded the same incentives.

In the United States, the federal government offers a tax credit to purchasers until a certain number of cars has been sold by a manufacturer. This has ranged from US$787 to $3,150, which expired in 2007 for hybrids sold by Toyota. Some state governments, including Colorado, Connecticut, Illinois offer tax incentives. Hybrid engine automobiles are exempt from high-occupancy vehicle lane restrictions in some U.S. states.) California (currently until January 1, 2011. Los Angeles and San Jose, California had exempted hybrid cars from paying for street parking. New York State offers a special "green" version of their E-Z-Pass toll payment tag for hybrid owners who use the NYS Thruway system, which gives the owners a 10% discount on tolls. Also, the Port Authority of New York and New Jersey offers their "green E-Z-Pass" to hybrid owners, who pay $4 instead of $8 to use all the bridges and tunnels between New York and New Jersey, except in rush hours.

In the Netherlands, the government has lowered the tax for company-cars with CO₂ emissions below a certain level (such as the Prius) to 14%. The tax on all other class company-cars has been raised from 22 to 25%. As a result, in the month January alone, more than 1800 cars have been sold. The importer has already indicated that he can no longer meet the demand for the year 2008. Privately owned cars with low CO₂ emissions benefit from lower road taxes.

In Sweden, private purchasers of the Prius (or any other vehicle in the environmentally less destructive class) are awarded SEK 10,000 (roughly USD 1700, €1100) after six months of ownership, in order to stimulate sales and use of such vehicles. The subsidy program has been very successful.

Corporate incentives

Several U.S. companies offer employees incentives. Bank of America will reimburse $3000 on the purchase of new hybrid vehicles to full- and part-time associates working more than 20 hours per week. Google, software company Hyperion Solutions, and organic food and drink producer Clif Bar & Co^{[broken footnote]} offer employees a $5000 credit toward their purchase of certain hybrid vehicles including the Prius. Integrated Archive Systems, a Palo Alto IT company, offers a $10,000 subsidy toward the purchase of hybrid vehicles to full-time employees employed more than one year.^{[broken footnote]} Clothing companies Timberland and Patagonia, law firm DLA Piper, non-profit American Jewish Committee, software publisher Topics Entertainment, Logistics Giant Exel Contract Logistics, and research firm ABR, Inc. are among companies offering eligible employees significant discounts on certain hybrid vehicles including the Prius.^{[broken footnote]}

Travelers Companies, a large insurance company, offers hybrid owners a 10% discount on auto insurance in most states. The Farmers Insurance Group offers a similar discount of up to 10% in most states.^{[broken footnote]}

Aftermarket products

Plug-in

Main article: Plug-in hybrid

Toyota Prius plug-in hybrid converted by CalCars exhibited at the Maker Faire 2008, San Mateo, California.

Plug-in hybrids use a larger electric vehicle battery pack that is recharged from external sources in order to further reduce fuel consumption. The NiMH batteries in a production PHEV will be built to handle deeper discharge cycles without loss of lifespan such as the NiMH battery pack in the Toyota RAV4 EV. Operation of the vehicle will be very similar to a normal hybrid, except that the electric operation will be more prevalent. In the case of a Prius PHEV, on the highway, the gasoline engine will operate as before, leaving the car with the same ability to accelerate and use freeways. Current converted Prius also operate in a high speed blended mode which can reduce but not eliminate fuel consumption on the freeway. When driving in slower conditions or with light loads, the batteries will be used first in a charge-depleting mode, allowing moderate commutes at low speeds (particularly under 41 mph/65 km/h) to be driven entirely on electricity. Once the batteries have been sufficiently discharged the car will automatically revert back to the charge-sustaining mode of the current stock Prius.

A Raleigh, North Carolina firm, Advanced Vehicle Research Center, converts the Prius by adding a second battery, improving its fuel efficiency by increasing the distance it runs on electricity alone.

The PRIUS+ Project run by CalCars made the first conversion of a Toyota Prius to plug-in, and also offers conversion instructions for do-it-yourselfers.

Awards

• 1997–98 Car of the Year Japan
• 2003 Scientific American names Toyota Motor Corporation as "Business Leader of the Year" ("Scientific American 50"; December, 2003) for its singular accomplishment in the commercialization of affordable hybrid cars.
• Motor Trend Car of the Year, 2004
• Car and Driver magazine's Ten Best list for 2004.
• North American Car of the Year award for 2004. Nominated in 2001.
• International Engine of the Year for 2004.
• "Best Engineered Vehicle for 2004" by SAE's Automotive Engineering International magazine.
• 2005 European Car of the Year (406 points, ahead of Citroën C4 with 267 points and Ford Focus II with 228).
• 2006 EnerGuide Award (Midsize)
• 2006 Intellichoice Best Overall Value of the Year, Midsize
• 2007 Intellichoice Best in Class Winner :Best Retained Value, Lowest Fuel, Lowest Operating Costs, Lowest Ownership Costs
• Swiss government named Toyota Prius the world's greenest car in a draft study of over 6,000 cars.
• Green Engine of the Year 2008 from International Engine of the Year Awards.
• 2008 Nominated for WhatGreenCar.com Car of the Year Awards 2008, shortlisted for the UK's top Green Car Awards
• JD Power and Associates "Most Dependable Compact Car" for 2008 and 2009

Competitors

• Honda Insight, which emphasizes affordability. Honda Insight, billed as the cheapest gas-electric hybrid on the market, ranked as the top-selling vehicle in Japan for April 2009—the first time a hybrid has clinched that spot. When the Prius launched in May 2009 it took Japan's top spot while Insight sales fell to third. Features such as 15" alloy wheels, 6-speaker audio, cruise control and electronic stability control while standard on the US-spec Prius II (MSRP $22,000) are optional on the Insight.

See also

• Comparison of Toyota hybrids
• List of hybrid vehicles
• Fuel economy-maximizing behaviors
• Chevrolet Volt
• Honda Civic Hybrid
• Hybrid Synergy Drive
• Hypermiler Driving (drivers who exceed EPA estimated MPG)
• Hybrid electric vehicle
• Plug-in hybrid electric vehicle
• Toyota Camry Hybrid
• Toyota eCom
• ACT Hybrid Vehicle Authority

External links

• Official Toyota Prius site – UK Template:En icon
• Official Toyota worldwide website
  • Third Generation (Toyota Official Website)
• Toyota Prius at Curlie